Home » Poulan Manuals » Lawn & Garden » Poulan PO14538LT » Manual Viewer

Poulan PO14538LT User Manual

Poulan PO14538LT Manual

Get Poulan PO14538LT PDF manuals and user guides

View all Poulan PO14538LT manuals

Add to My Manuals
Save this manual to your list of manuals

Poulan PO14538LT manual content summary:

Poulan PO14538LT | User Manual - Page 1
NOT THROW AWAY 5000 OPERATOR'S MANUAL MODEL: PO14538LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com Gasoline containing up to
Poulan PO14538LT | User Manual - Page 2
and cause you to lose control of your tractor. WARNING Engine exhaust, some of its instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts riding mower-related injuries. These operators should evaluate their ability to operate the riding mower
Poulan PO14538LT | User Manual - Page 3
and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
Poulan PO14538LT | User Manual - Page 4
. Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
Poulan PO14538LT | User Manual - Page 5
UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert Steering Wheel Adapter Steering Wheel (1) Large Flat Washer (1) Lock Washer Steering Boot (1) Hex Bolt Steering Extension Shaft Seat (1) Seat (1) Cup
Poulan PO14538LT | User Manual - Page 6
"BATTERY" in Maintenance section of this manual for charging instructions). INSERT BOLT LOCK WASHER LARGE FLAT WASHER • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. STEERING WHEEL STEERING BOOT LABEL ADAPTER LOWER
Poulan PO14538LT | User Manual - Page 7
BRAKE" in the Service and Adjustments section of this manual. ✓CHECKLIST BEFORE YOU OPERATE YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed
Poulan PO14538LT | User Manual - Page 8
tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER Models only) Failure to follow instructions
Poulan PO14538LT | User Manual - Page 9
and adjustments. Save this manual for future reference. G B D A C E H F J Fig. 4 Our tractors conform to the applicable safety (E) ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. (F) IGNITION SWITCH - Used for starting and stopping
Poulan PO14538LT | User Manual - Page 10
parking brake lever. Pedal should remain in brake position. Make sure parking brake will hold tractor secure. C B Fig. 5 STOPPING (See Fig. 6) MOWER BLADES • To stop mower blades, place attachment clutch control in the "DISENGAGED" position ( ). ENGINE - • Move throttle control (D) between half
Poulan PO14538LT | User Manual - Page 11
and to over 3" during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, 02828 ENGINE "ON" POSITION (NORMAL OPERATING) Fig. 10 TO OPERATE MOWER Your tractor is equipped with an operator presence sensing switch. Any attempt by
Poulan PO14538LT | User Manual - Page 12
mower without either the entire grass catcher, on mowers sure you have allowed room for tractor to roll slightly as you manual). • To change engine oil, see the Maintenance section in this manual storage. To avoid engine problems, the fuel system should be Instructions for additional information. Never use
Poulan PO14538LT | User Manual - Page 13
TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
Poulan PO14538LT | User Manual - Page 14
C Check/Replace Mower Blades T Lubrication instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual
Poulan PO14538LT | User Manual - Page 15
local parts dealer. Tire problem immediately. CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor and void your warranty. BLADE REMOVAL (See Fig. 14) • Raise mower
Poulan PO14538LT | User Manual - Page 16
range expected before oil change. All oil must meet API service classification SG-SL. • Ensure tractor is on level surface. • Oil will drain more freely overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level
Poulan PO14538LT | User Manual - Page 17
pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. FUEL FILTER 00667 Fig
Poulan PO14538LT | User Manual - Page 18
SERVICE the blades and all moving parts have completely stopped. • MOWER IS TO BE MOUNTED ON THE TRACTOR, REMOVE THE FRONT LINK (E) AND REAR LIFT LINKS (C) FROM TRACTOR AND HOOK THE CLUTCH SPRING (Q) INTO THE CABLE GUIDE ON FRONT EDGE OF LOWER DASH. TO INSTALL MOWER (See Fig. 20-25) Ensure tractor
Poulan PO14538LT | User Manual - Page 19
SERVICE AND ADJUSTMENTS • ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring. • Repeat on opposite side of tractor. • Insert end of link (E) into hole in front mower bracket and secure with washer and
Poulan PO14538LT | User Manual - Page 20
SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower than the rear tip, go to the front of tractor. • With an 11/16" or adjustable wrench,
Poulan PO14538LT | User Manual - Page 21
(A) and clutching idler (B). 5. Make sure belt is in all pulley grooves and inside all belt guides and keepers. 6. Install mower (See "TO INSTALL MOWER" section in this manual). Fig. 30 TO CHECK BRAKE If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level
Poulan PO14538LT | User Manual - Page 22
is needed to get to adjustment bolt, move mower deck height to the lowest position. GEARSHIFT LEVER NEUTRAL sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER Your new tractor
Poulan PO14538LT | User Manual - Page 23
AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service
Poulan PO14538LT | User Manual - Page 24
enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
Poulan PO14538LT | User Manual - Page 25
TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE in "CHOKE" position. 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/dirty oil. 6. Faulty To Adjust Carburetor" in Service Adjustments section. 10. Contact an authorized service center/department. 1. Clean
Poulan PO14538LT | User Manual - Page 26
drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes from buildup 11. Clean around mandrels to open vent holes. of grass, leaves, and trash around mandrels
Poulan PO14538LT | User Manual - Page 27
27 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
Poulan PO14538LT | User Manual - Page 28
Outdoor Products Customer Service Dept. 9335 Harris Corners Parkway Charlotte, NC 28269 USA In Canada contact: HOP 5855 Terry Fox Way Mississauga, Ontario L5V 3E4 giving the model number, serial number and date of purchase of your product and the name and address of the authorized dealer from whom