Poulan PO14542LT User Manual
Poulan PO14542LT Manual
 |
View all Poulan PO14542LT manuals
Add to My Manuals
Save this manual to your list of manuals |
Poulan PO14542LT manual content summary:
- Poulan PO14542LT | User Manual - Page 1
Do Not Throw Away 5000 OPERATOR'S MANUAL MODEL: PO14542LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com 438511 09.16.10 TH - Poulan PO14542LT | User Manual - Page 2
understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under the machine. large percentage of riding mowerrelated injuries. These operators should evaluate their ability to operate the riding mower safely enough to - Poulan PO14542LT | User Manual - Page 3
and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary - Poulan PO14542LT | User Manual - Page 4
. Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to - Poulan PO14542LT | User Manual - Page 5
UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert (1) Large Flat Washer (1) Hex Bolt 5/16-18 x 4 (1) 5/16 Lock Washer Steering Wheel Adapter Steering Boot Seat (1) Seat Steering Extension Shaft (1) Washer (1) Knob Keys (1) Oil Drain Tube For Future Use Slope Sheet (2) Keys 5 - Poulan PO14542LT | User Manual - Page 6
manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. STEERING WHEEL STEERING BOOT ADAPTER SEAT LABEL LOWER STEERING SHAFT EXTENSION SHAFT 02819 02602 Fig. 1 BEFORE REMOVING TRACTOR - Poulan PO14542LT | User Manual - Page 7
this manual. ✓CHECKLIST BEFORE YOU OPERATE YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton. ✓ Battery is - Poulan PO14542LT | User Manual - Page 8
OVER TEMP LIGHT FUEL OIL PRESSURE BATTERY REVERSE FORWARD MOWER HEIGHT 15 MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED without the alert symbol, indicates a situation that could result in damage to the tractor and/or engine. HOT SURFACES indicates a hazard which, if not avoided, - Poulan PO14542LT | User Manual - Page 9
TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual ON" POSITION - Allows operation of mower deck or other powered attachment while - Poulan PO14542LT | User Manual - Page 10
operating your tractor or performing any adjustments or repairs. We BATTERY TO BE DISCHARGED, (DEAD). NOTE: Under certain conditions when tractor LIFE OF YOUR TRANSAXLE. TO ADJUST MOWER CUTTING HEIGHT (See Fig. 5) The . For healthier and better looking lawns, mow often and after moderate growth - Poulan PO14542LT | User Manual - Page 11
, turn the ignition key clockwise to engine "ON" position. ROS "ON" POSITION 02828 ENGINE "ON" POSITION (NORMAL OPERATING) Fig. 6 TO OPERATE MOWER (See Fig. 7) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running - Poulan PO14542LT | User Manual - Page 12
• Check engine oil with tractor on level ground. • Remove engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or Service and Adjustments section of this manual. 12 - Poulan PO14542LT | User Manual - Page 13
TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so - Poulan PO14542LT | User Manual - Page 14
with maintenance-free battery. EVERY SEASON BEFORE STORAGE GENERAL RECOMMENDATIONS The warranty on this tractor does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some - Poulan PO14542LT | User Manual - Page 15
remove battery from tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the Service and Adjustments section of this manual). 15 - Poulan PO14542LT | User Manual - Page 16
if necessary. The belts are not adjustable. Replace belts if they begin before oil change. All oil must meet API service classification C. • Be sure tractor is on level surface. • Oil will approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick - Poulan PO14542LT | User Manual - Page 17
or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 02744 Fig. 13 17 - Poulan PO14542LT | User Manual - Page 18
ANY SERVICE OR MOWER (See Fig. 15) Mower will be easier to remove from the right side of tractor. • Place attachment clutch in "DISENGAGED" position. • Move attachment lift lever forward to lower mower to its lowest position. • Roll belt cable housing guide into bracket, slide collar onto guide and - Poulan PO14542LT | User Manual - Page 19
SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE ADJUSTMENT (See Figs. 16 and 17) • Raise mower to its - Poulan PO14542LT | User Manual - Page 20
qualified service center. TO REPLACE MOTION DRIVE BELT (See Fig. 21) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE - Poulan PO14542LT | User Manual - Page 21
parts dealer. Tire sealant also prevents tire dry rot and corrosion. If your battery is too weak to start the engine, it should be recharged. (See "BATTERY" in the Maintenance section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR - Poulan PO14542LT | User Manual - Page 22
adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 22 - Poulan PO14542LT | User Manual - Page 23
. Store in a clean, dry area. • Clean entire tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Maintenance section of - Poulan PO14542LT | User Manual - Page 24
TROUBLESHOOTING POINTS PROBLEM service center/department. 1. Recharge or replace battery. 2. Clean battery terminals. 3. Check all wiring. 4. Check/replace solenoid or starter. 1. Raise cutting height/reduce speed. 2. Adjust throttle control. 3. Clean underside of mower - Poulan PO14542LT | User Manual - Page 25
and trash under mower. 7. Clean underside of mower housing. 8. Mower drive belt worn. 8. Replace mower drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes - Poulan PO14542LT | User Manual - Page 26
SERVICE NOTES 26 - Poulan PO14542LT | User Manual - Page 27
27 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than - Poulan PO14542LT | User Manual - Page 28
repair or replace, at our option, without charge for parts or labor incurred in replacing parts, any part Battery, charging you 1/12 of the price of a new Battery for each full month from the date of the original sale. Battery must be maintained in accordance with the instructions are belts, service
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
 |
 |
OPERATOR'S MANUAL
MODEL:
PO14542LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions.
Failure to do so can
result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
5000
438511
09.16.10
TH
Printed in the U.S.A.