Poulan PO15538C User Manual

Poulan PO15538C Manual

Get Poulan PO15538C PDF manuals and user guides View all Poulan PO15538C manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PO15538C manual content summary:

  • Poulan PO15538C | User Manual - Page 1
    MODEL NO. PO15538C 15.5 HP 38 Inch Lawn Tractor For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For Technical Assistance: call 1-800-829-5886 191713 03.09.04 RD PRINTED IN U.S.A.
  • Poulan PO15538C | User Manual - Page 2
    to improve stability. mended parts, when necessary. • Use extra care with grass catchers or other attachments. • Mower blades are sharp and can cut. Wrap the blade(s) These can change the stability of the machine. or wear gloves, and use extra caution when servicing • Keep all movement on
  • Poulan PO15538C | User Manual - Page 3
    Ride-On Mowers • Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. • Never carry passengers or children even with the blades with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain
  • Poulan PO15538C | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PO15538C | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Wheel Insert Steering Wheel Adapter Steering Extension Shaft Steering Boot (1) Large Flat Washer (1) Locknut 1/2-20 (1) Hex Bolt 1/4-28 x 1-1/4 (1) Locknut 1/4-28 5 (1) Washer
  • Poulan PO15538C | User Manual - Page 6
    Utility knife When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted lines on all four
  • Poulan PO15538C | User Manual - Page 7
    into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in the Maintenance section of this manual for charging instructions). SEAT PAN LABEL 02602 FIG. 3 NOTE: You may now roll or drive your tractor
  • Poulan PO15538C | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PO15538C | User Manual - Page 9
    MOWER HEIGHT 15 MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan PO15538C | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PO15538C | User Manual - Page 11
    TRACTOR TO A COMPLETE STOP BEFORE SHIFTING OR CHANGING GEARS. FAILURE TO DO SO WILL SHORTEN THE USEFUL LIFE OF YOUR TRANSAXLE. FIG.5 STOPPING (See Fig. 5) MOWER BLADES • To stop mower blades types of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches during the cool
  • Poulan PO15538C | User Manual - Page 12
    mower blades by engaging attachment clutch control. • TO STOP MOWER BLADES - disengage attachment clutch control. CAUTION: Do not operate the mower without either the entire grass catcher, on mowers of your tractor. Use common manual). • To change engine oil, see the Maintenance section in this manual
  • Poulan PO15538C | User Manual - Page 13
    To avoid engine problems, the fuel See Storage Instructions for additional information mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PO15538C | User Manual - Page 14
    to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for wear
  • Poulan PO15538C | User Manual - Page 15
    performing any maintenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). TIRES • Maintain proper air pressure in all tires (See
  • Poulan PO15538C | User Manual - Page 16
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PO15538C | User Manual - Page 17
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 17
  • Poulan PO15538C | User Manual - Page 18
    blades and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 13) Mower (BOTH SIDES) HOUSING GUIDE LARGE RETAINER SPRING 02695 BRACKET FIG. 13 18 DEFLECTOR SHIELD
  • Poulan PO15538C | User Manual - Page 19
    small retainer spring. • Install belt onto engine pulley. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly
  • Poulan PO15538C | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 18) The mower blade drive belt may be replaced without tools. Park the tractor position. The rear wheels must lock and skid when you try to manually push the tractor forward. If the rear wheels rotate, the brake needs to be adjusted
  • Poulan PO15538C | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO REPLACE MOTION DRIVE BELT (See Fig. 20) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE:
  • Poulan PO15538C | User Manual - Page 22
    SERVICE AND ADJUSTMENTS TO REMOVE CABLES, REVERSE ORDER • BLACK cable first from RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO REPLACE FUSE Replace with 20
  • Poulan PO15538C | User Manual - Page 23
    not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 02778 FIG. 25
  • Poulan PO15538C | User Manual - Page 24
    tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING
  • Poulan PO15538C | User Manual - Page 25
    air screen/fins. 12. Clean/replace muffler. 13. Check all wiring. 14. See "To Adjust Carburetor" in Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part(s). 1. Replace blade
  • Poulan PO15538C | User Manual - Page 26
    before mowing. 4. Level mower deck. 5. Check tires for proper air pressure. 6. Replace/sharpen blade. Tighten blade bolt. 7. Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11. Clean around mandrels
  • Poulan PO15538C | User Manual - Page 27
    parts or labor incurred in replacing parts, any part the instructions furnished. blade adapters, normal wear, normal adjustments, standard hardware and normal maintenance. 7. In the event you have a claim under this Warranty, you must return the product to an authorized service the model number
  • Poulan PO15538C | User Manual - Page 28
    43 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PO15538C | User Manual - Page 29
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
MODEL NO. PO15538C
15.5 HP 38 Inch
Lawn Tractor
For Parts and Service, contact our authorized distributor: call 1-800-849-1297
For Technical Assistance:
call 1-800-829-5886
191713
03.09.04
RD
PRINTED IN U.S.A.