Poulan PP5524ESC User Manual

Poulan PP5524ESC Manual

Get Poulan PP5524ESC PDF manuals and user guides View all Poulan PP5524ESC manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PP5524ESC manual content summary:

  • Poulan PP5524ESC | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL NUMBER: PP5524ESC SNOW THROWER WARNING: Read the Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. Always Wear Eye Protection During Operation 192030 07.29.04 BY Printed in
  • Poulan PP5524ESC | User Manual - Page 2
    reach an open flame or spark. WARNING: Snow throwers have exposed rotating parts, which can cause severe injury from contact, or from material thrown from with local inspection authorities. • Read the operating and service instruction manual • If snow thrower must be operated over gravel surface
  • Poulan PP5524ESC | User Manual - Page 3
    trouble parts guide instructions for important problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained technicians and the proper tools to service or repair this unit. Please read and retain this manual. The instructions THE MODEL
  • Poulan PP5524ESC | User Manual - Page 4
    SAFETY RULES 2-3 PRODUCT SPECIFICATIONS 3 CUSTOMER RESPONSIBILITIES 3 WARRANTY 32 ASSEMBLY / PRE-OPERATION 5-7 OPERATION 8-13 MAINTENANCE 14-15 MAINTENANCE SCHEDULE 14 SERVICE AND ADJUSTMENTS 16-18 STORAGE 18 TROUBLESHOOTING 19 REPAIR PARTS 20-31 PARTS PACKED SEPARATELY IN CARTON 4
  • Poulan PP5524ESC | User Manual - Page 5
    / PRE-OPERATION Read these instructions and this manual in its entirety before you attempt to assemble or operate your new snow thrower. Your new snow thrower has been assembled at the factory with the exception of those parts left unassembled for shipping purposes. All parts such as nuts, washers
  • Poulan PP5524ESC | User Manual - Page 6
    ASSEMBLY / PRE-OPERATION INSTALL TRACTION DRIVE CONTROL ROD (See Figs. 3 and 4) The traction drive control rod has the long loop on the end of the spring as shown. 1. Slide rubber sleeve up rod and hook end of spring into pivot bracket with loop opening down as shown. 2. With top end of rod
  • Poulan PP5524ESC | User Manual - Page 7
    ASSEMBLY / PRE-OPERATION INSTALL DISCHARGE CHUTE / CHUTE ROTATER HEAD (See Fig. 7) NOTE: The multi-wrench provided in your parts bag may be used to install the chute rotater head. 1. Place discharge chute assembly on top of chute base with discharge opening toward front of
  • Poulan PP5524ESC | User Manual - Page 8
    yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your snow READ AND FOLLOW ALL SAFETY INFORMATION AND INSTRUCTIONS BEFORE USE OF THIS PRODUCT. KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE. IGNITION KEY. INSERT
  • Poulan PP5524ESC | User Manual - Page 9
    OPERATION SAFETY IGNITION KEY SPARK PLUG CHOKE CONTROL ENGINE OIL CAP AUGER DISCHARGE CHUTE CONTROL LEVER WITH DIPSTICK CONTROL LEVER DRIVE SPEED CONTROL LEVER GASOLINE FILLER CAP CHUTE DEFLECTOR TRACTION DRIVE CONTROL LEVER FUEL SHUT-OFF VALVE THROTTLE / ENGINE CONTROL DISCHARGE
  • Poulan PP5524ESC | User Manual - Page 10
    (See Figs. 12 & 13) WARNING: Snow throwers have exposed rotating parts, which can cause severe injury from contact, or from material thrown from discharge chute or auger become clogged, shut-off engine and wait for all moving parts to stop.Use the clean-out tool, NOT YOUR HANDS, to unclog the
  • Poulan PP5524ESC | User Manual - Page 11
    tool to dislodge this blockage. When cleaning, repairing, or inspecting, make certain all controls are disengaged and the auger/impeller and all moving parts have stopped. Disconnect the spark plug wire and keep the wire away from the spark plug to prevent accidental starting. • Release the auger
  • Poulan PP5524ESC | User Manual - Page 12
    engine and wait for all moving parts to stop. 2. Adjust skid storage. To avoid engine problems, the fuel system should . See Storage Instructions for additional information providing additional service before requiring OIL" in the Maintenance section of this manual. ADD GASOLINE (See Fig. 18)
  • Poulan PP5524ESC | User Manual - Page 13
    downwind whenever possible. • Adjust the skid plates to proper height for current snow conditions. See "TO ADJUST SKID PLATES" in this section of this manual. • For extremely heavy snow, reduce the width of snow removal by overlapping previous path and moving slowly. • Keep engine clean and clear of
  • Poulan PP5524ESC | User Manual - Page 14
    snow thrower as instructed in this manual. Some adjustments will in this manual. NOTE: Use only Original Equipment Manufacturer (OEM) parts to service this unit manual). NOTE: To seal tire punctures and prevent flat tires due to slow leaks, tire sealant may be purchased from your local parts dealer
  • Poulan PP5524ESC | User Manual - Page 15
    manual). TheV-belts on your snow thrower are of special construction and should be replaced by original equipment manufacturer (OEM) belts available from your nearest dealer . (See "TO REMOVE WHEELS" in the Service and Adjustments section of this manual). 1. Disconnect spark plug wire from spark plug
  • Poulan PP5524ESC | User Manual - Page 16
    service or adjustments: 1. Be sure throttle is in STOP position. 2. Remove safety ignition key. 3. Make sure the augers and all moving parts is discharged, see "TO CONTROL SNOW DISCHARGE" in the Operation section of this manual. SHEAR BOLTS (See Fig. 19) AUGER SHEAR BOLTS Both right and left-hand
  • Poulan PP5524ESC | User Manual - Page 17
    recommended that the belt(s) be replaced by a qualified service center. NOTE: It is recommended that both the auger OEM) belts available from your nearest dealer.Using other than OEM belts can TO REMOVE BELT COVER" in this section of this manual. 4. REMOVE ENGINE PULLEY - Remove bolt, lockwasher and
  • Poulan PP5524ESC | User Manual - Page 18
    punctures or prevent flat tires due to slow leaks, tire sealant may be purchased from your local parts dealer.Tire sealant also prevents tire dry rot and corrosion. ENGINE See engine manual. CARBURETOR Your carburetor is not adjustable. Engine performance should not be affected at altitudes up to
  • Poulan PP5524ESC | User Manual - Page 19
    TROUBLESHOOTING See appropriate section in manual unless directed to a qualified service centre. PROBLEM CAUSE CORRECTION Does not to FAST position. 5. Move to FULL position. 6. Prime as instructed in the Operation section of this manual. 7. Wait a few minutes before restarting, DO NOT prime.
  • Poulan PP5524ESC | User Manual - Page 20
    our option, without charge for parts or labor incurred in replacing parts, any part which we find to be , and maintained in accordance with the instructions furnished. This Warranty does not apply must return the product to an authorized service dealer. Should you have any unanswered questions
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
OWNER'S MANUAL
MODEL NUMBER:
PP5524ESC
SNOW THROWER
Always Wear Eye Protection During Operation
IMPORTANT MANUAL
Do Not Throw Away
WARNING:
Read the Owner's Manual and
follow all Warnings and Safety
Instructions.
Failure to do so
can result in serious injury.
192030
07.29.04
BY
Printed in U.S.A.