Poulan PPCRT55 User Manual

Poulan PPCRT55 Manual

Get Poulan PPCRT55 PDF manuals and user guides View all Poulan PPCRT55 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PPCRT55 manual content summary:

  • Poulan PPCRT55 | User Manual - Page 1
    Throw Away side_views_126 OWNER'S MANUAL MODEL: PPCRT55 REAR TINE TILLER WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 403701 Rev. 1 02
  • Poulan PPCRT55 | User Manual - Page 2
    trouble. moving parts have the operator's guide instructions for important MANUAL. IMPORTANT: USED TO ALERT YOU THAT THERE IS A POSSIBILITY OF DAMAGING THIS EQUIPMENT. NOTE: Gives essential information that will aid you to better understand, incorporate, or execute a particular set of instructions
  • Poulan PPCRT55 | User Manual - Page 3
    . Should you experience any problems you cannot easily remedy, please contact your nearest authorized service center. We have competent, well-trained technicians and the proper tools to service or repair this unit. Please read and retain this manual. The instructions will enable you to assemble
  • Poulan PPCRT55 | User Manual - Page 4
    with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tiller all parts and hardware you assemble (See Fig. 1) When right or left hand is mentioned in this manual, it means when you are in the operating position (standing behind tiller
  • Poulan PPCRT55 | User Manual - Page 5
    . Insert rear carriage bolt first, with head of bolt on L.H. side of tiller and loosely assemble locknut (See Fig. 5). • Insert pivot bolt in front part of plate and tighten. • Cut down remaining corners of carton and lay panels flat. • Lower the handle assembly. Tighten nut on carriage bolt so handle
  • Poulan PPCRT55 | User Manual - Page 6
    tire pressure to 20 PSI(1.4 kg/cm2) HANDLE HEIGHT • Handle height may be adjusted to better suit operator. (See "TO ADJUST HANDLE HEIGHT" in the Service and Adjustments section of this manual). 6
  • Poulan PPCRT55 | User Manual - Page 7
    OPERATING YOUR TILLER. Compare the illustrations with your tiller to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your Tiller or in literature supplied with the product. Learn and understand their
  • Poulan PPCRT55 | User Manual - Page 8
    OPERATION The operation of any tiller can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields before starting your tiller and while tilling. We recommend a wide vision safety mask for over spectacles or standard safety
  • Poulan PPCRT55 | User Manual - Page 9
    3 of this manual. All oil must meet A.P.I. Service Classification SF- problems, the fuel system should be emptied before storage of 30 days or longer. Drain the gas tank, start the engine and let it run until the fuel lines and carburetor are empty. Use fresh fuel next season. See Storage Instructions
  • Poulan PPCRT55 | User Manual - Page 10
    . See "TO ADJUST CARBURETOR" in the Service and Adjustments section of this manual. NOTE: If engine does not start, see troubleshooting points. CHOKE CONTROL RUN CHOKE • Soil break, replace only with those shown in the Repair Parts section of this manual. and you, toward the row next to it. 10
  • Poulan PPCRT55 | User Manual - Page 11
    full value from the warranty, the operator must maintain tiller as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tiller. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season. • Once
  • Poulan PPCRT55 | User Manual - Page 12
    burns. ENGINE LUBRICATION Use only high quality detergent oil rated with API service classification SG-SL. Select the oil's SAE viscosity grade according to with oil. See"CHECK ENGINE OIL LEVEL" in the Operation section of this manual. OIL DRAIN PLUG OIL FILLER OIL LEVEL PLUG FIG. 17 AIR FILTER
  • Poulan PPCRT55 | User Manual - Page 13
    brush. • Remove blower housing and clean as necessary. • Keep cylinder fins free of dirt and chaff. BLOWER HOUSING AIR SCREEN engine_art_61 and gap setting is shown in "PRODUCT SPECIFICATIONS" on page 3 of this manual. TRANSMISSION Once a season, lubricate the right hand side gear case grease fitting
  • Poulan PPCRT55 | User Manual - Page 14
    SERVICE AND ADJUSTMENTS CAUTION: Disconnect spark plug wire from spark plug and place wire where it cannot come into contact with plug. TILLER TO ADJUST HANDLE
  • Poulan PPCRT55 | User Manual - Page 15
    SERVICE AND ADJUSTMENTS TO REPLACE GROUND DRIVE BELT (See Figs. 22 and 23) • Remove and into engine pulley. BELT MUST BE IN GROOVE ON TOP OF IDLER PULLEY. NOTE POSITION OF BELT TO GUIDES. • Check belt adjustment as described below. • Replace belt guard. • Reposition wheel and replace clevis pin and
  • Poulan PPCRT55 | User Manual - Page 16
    SERVICE AND ADJUSTMENTS TINE REPLACEMENT (See Figs. 24, 25, and 26) CAUTION: Tines are sharp. Wear gloves or other protection when handling tines. A badly worn tine
  • Poulan PPCRT55 | User Manual - Page 17
    ABOVE THE FACTORY HIGH SPEED SETTING CAN BE DANGEROUS. IF YOU THINK THE ENGINE-GOVERNED HIGH SPEED NEEDS ADJUSTING, CONTACTYOUR NEAREST AUTHORIZED SERVICE CENTER/ DEPARTMENT, WHICH HAS THE PROPER EQUIPMENT AND EXPERIENCE TO MAKE ANY NECESSARY ADJUSTMENTS. CLAMP SCREW CASING AND WIRE engine_art_78
  • Poulan PPCRT55 | User Manual - Page 18
    instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Maintenance section of this manual. • Be sure that all nuts, bolts and screws are securely fastened. Inspect moving parts /or dirt in your gasoline will cause problems. • If possible, store your unit
  • Poulan PPCRT55 | User Manual - Page 19
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly air screen. 11. Clean/replace muffler. 12. Make necessary adjustments. 13. Contact an authorized service center/department. 1. Check oil level/change oil. 2. Clean engine air screen. 3. Clean cylinder
  • Poulan PPCRT55 | User Manual - Page 20
    3 5 26 3 12 13 10 2 2 14 11 27 25 15 26 24 23 22 20 KEY PART NO. NO. DESCRIPTION 1 532 18 94-82 Control, Throttle 2 532 14 14-06 Grip, Handle 3 Carriage 3/8-16 x 1 Gr. 5 21 16 19 18 17 31 11 Handle_assy_36 KEY PART NO. NO. DESCRIPTION 17 532 10 92-29 Lock, Handle 18 873 68 06-00
  • Poulan PPCRT55 | User Manual - Page 21
    29 22 27 19 30 66 28 3 40 26 40 44 15 23 24 mainframe_left_17 25 KEY PART NO. NO. DESCRIPTION 2 810 04 06-00 Washer, Lock 3/8 3 873 22 06-00 Nut Valve 24 532 12 68-75 Rivet, Drilled 25 532 12 47-88 Clip, Hairpin KEY PART NO. NO. DESCRIPTION 26 532 40 51-12 Guard, Belt 27 532 13 28-01
  • Poulan PPCRT55 | User Manual - Page 22
    960 91 00-12 MAINFRAME, RIGHT SIDE 15 2 13 12 5 7 10 8 11 9 10 KEY PART NO. NO. DESCRIPTION 2 873 97 05-00 Locknut, Hex, Flange 5/16-18 5 532 10 23- 11 532 12 47-88 Clip, Hairpin 12 532 12 68-75 Rivet, Drilled KEY PART NO. NO. DESCRIPTION 13 532 00 50-15 Tire 532 12 72-59 Rim 532 12
  • Poulan PPCRT55 | User Manual - Page 23
    REPAIR PARTS TILLER - - MODEL NUMBER PPCRT55 (96091001200), PRODUCT NUMBER 960 91 00-12 TRANSMISSION 12 9 37 39 53 49 35 36 50 24 52 25 53 44 transmission_19.5b 51 58 KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 1 532 18 85-54 Transmission Assembly (Includes 29 532 10 21
  • Poulan PPCRT55 | User Manual - Page 24
    24 11 22 29 21 20 19 15 16 14 11 12 11 12 11 1 tine_shield_16_in KEY PART NO. NO. DESCRIPTION 1 873 90 05-00 Nut, Lock Hex Flange 5/16-18 2 Gr. 5 19 532 10 27-01 Grip 20 873 22 06-00 Nut, Hex 3/8-16 KEY PART NO. NO. DESCRIPTION 21 532 10 21-56 Stake, Depth 22 874 93 06-32 Bolt,
  • Poulan PPCRT55 | User Manual - Page 25
    TINE ASSEMBLY 2 1 1 1 3 5 1 4 3 34 11 11 2 9 8 KEY PART NO. NO. DESCRIPTION 1 532 00 44-59 Tine, Outer, L.H. 2 532 13 26-73 3/8-24 x 1 9 532 00 44-60 Tine, Outer, R.H. 9 9 10 4 9 tine_ipb_1 KEY PART NO. NO. DESCRIPTION 10 532 13 27-28 Assembly, Hub and Plate, R.H. 11 532 00 65-
  • Poulan PPCRT55 | User Manual - Page 26
    NUMBER PPCRT55 (96091001200), PRODUCT NUMBER 960 91 00-12 DECALS 3 4 1 2 5 7 9 12 8 10 6 11 KEY PART NO. NO. DESCRIPTION 1 532 40 37-07 Decal, Belt Guard 2 532 15 78-01 Decal, Control Panel 3 532 40 , Engine 12 532 12 00-75 Decal, Warning, Rotating Tines - - 532 40 37-01 Manual, Owner's 26
  • Poulan PPCRT55 | User Manual - Page 27
    our option, without charge for parts or labor incurred in replacing parts, any part which we find to be , and maintained in accordance with the instructions furnished. This Warranty does not apply must return the product to an authorized service dealer. Should you have any unanswered questions
  • Poulan PPCRT55 | User Manual - Page 28
    Technical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
OWNER'S MANUAL
MODEL:
PPCRT55
REAR TINE TILLER
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
403701
Rev. 1
02.13.06
TR
Printed in U.S.A.
side_views_126