Poulan PPR1742STC User Manual

Poulan PPR1742STC Manual

Get Poulan PPR1742STC PDF manuals and user guides View all Poulan PPR1742STC manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PPR1742STC manual content summary:

  • Poulan PPR1742STC | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL: PPR1742STC LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. Always Wear Eye Protection During Operation 173282 11.29.99 JH Printed in U.S.A.
  • Poulan PPR1742STC | User Manual - Page 2
    and follow all instructions in the • Do not turn on slopes unless necessary, and then, turn manual and on the riding mowerrelated injuries. These operators should evaluate their ability to operate the riding mower safely enough to protect themselves and others from serious injury. IV. SERVICE
  • Poulan PPR1742STC | User Manual - Page 3
    Practices for Ride-On Mowers • Be with the ground and cause you to lose control of your tractor. CAUTION: In order to prevent accidental starting when setting up, 13 MAINTENANCE SCHEDULE 14 SERVICE AND ADJUSTMENTS 18 - 23 STORAGE 24 TROUBLESHOOTING 25 - 26 REPAIR PARTS 28 - 43 WARRANTY
  • Poulan PPR1742STC | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service centre/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PPR1742STC | User Manual - Page 5
    CONTENTS OF HARDWARE PACK Steering Wheel Steering Extension Shaft Seat Steering Sleeve (1) Hex Bolt 3/8-16 x 1 Steering Wheel Insert (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob (1) Shoulder Bolt 5/16-18 (1) Lock washer 3/8 (1) Large Flat Washer (1) Locknut 5/16-18 (1) Hex Bolt 5/16-18 x
  • Poulan PPR1742STC | User Manual - Page 6
    hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 3/8 HEX BOLT 3/8 LOCK WASHER LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut, from
  • Poulan PPR1742STC | User Manual - Page 7
    location and function of controls) WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects. • Be sure all the above assembly
  • Poulan PPR1742STC | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PPR1742STC | User Manual - Page 9
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PPR1742STC | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PPR1742STC | User Manual - Page 11
    to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, remove key. TO OPERATE MOWER (See Fig. 7) Always remove key when leaving tractor to prevent unauthorized use. Your tractor is equipped with an operator
  • Poulan PPR1742STC | User Manual - Page 12
    tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in storage. To avoid engine problems, the fuel system should be . season. See Storage Instructions for additional information.
  • Poulan PPR1742STC | User Manual - Page 13
    Service and Adjustments section of this manual. MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower fall onto the lawn they will disperse into the grass
  • Poulan PPR1742STC | User Manual - Page 14
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PPR1742STC | User Manual - Page 15
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PPR1742STC | User Manual - Page 16
    capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/ change. All oil must meet API service classification SF, SG or SH. • Be sure tractor is on level surface. • Oil fill cap/dipstick. • Remove hex bolts from blower housing and lift housing off engine. • Cover oil
  • Poulan PPR1742STC | User Manual - Page 17
    cover and secure with knob(s). TO SERVICE CARTRIDGE • Remove cartridge nut. • setting is shown in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See Fig. 17) The not recommend using a garden hose to clean your tractor unless the electrical system, muffler, air filter and
  • Poulan PPR1742STC | User Manual - Page 18
    side of tractor. • Lower lift lever to its lowest position. • Install mower in reverse order of removal instructions. SMALL RETAINER SPRING CLUTCH SPRING RETAINER SPRING ANTI-SWAY BAR COLLAR SUSPENSION ARMS SQUARE HOLE ENGINE PULLEY FRONT LINK RETAINER SPRINGS (BOTH SIDES) HOUSING GUIDE LARGE
  • Poulan PPR1742STC | User Manual - Page 19
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PPR1742STC | User Manual - Page 20
    removal. • Make sure belt is in all pulley grooves and inside all belt guides. • Install mower in reverse order of removal instructions. IDLER PULLEYS MANDREL PULLEYS FIG. 23 TO ADJUST BRAKE (See Fig. 24) Your tractor is equipped with an adjustable brake system which is mounted on the right side
  • Poulan PPR1742STC | User Manual - Page 21
    when wheels are positioned straight forward, remove steering wheel and reassemble per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor. If damage has occurred to affect the front wheel toein or camber
  • Poulan PPR1742STC | User Manual - Page 22
    SERVICE AND ADJUSTMENTS POSITIVE TERMINAL NEGATIVE TERMINAL KEPS NUT HEX BOLT RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO REPLACE FUSE Replace with 15
  • Poulan PPR1742STC | User Manual - Page 23
    THE FACTORY HIGH SPEED SETTING CAN BE DANGEROUS. IF YOU THINK THE ENGINE-GOVERNED HIGH SPEED NEEDS ADJUSTING, CONTACT YOUR NEAREST AUTHORIZED SERVICE CENTER/ DEPARTMENT, WHICH HAS PROPER EQUIPMENT AND EXPERIENCE TO MAKE ANY NECESSARY ADJUSTMENTS. IDLE SPEED SCREW THROTTLE LEVER IDLE MIXTURE VALVE
  • Poulan PPR1742STC | User Manual - Page 24
    TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PPR1742STC | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PPR1742STC | User Manual - Page 26
    PROBLEM TROUBLESHOOTING POINTS CAUSE CORRECTION Engine continues to run 1. Faulty operator-safety presence control system. when operator leaves seat with attachment clutch engaged 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PPR1742STC | User Manual - Page 27
    B+A1 RUN B+A1 START B + S + A1 NONE A2+L NONE NONE NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 27
  • Poulan PPR1742STC | User Manual - Page 28
    REPAIR PARTS ELECTRICAL TRACTOR - - MODEL NUMBER PPR1742STC 21 22 42 24 41 43 27 27 26 27 27 25 33 30 70 40 16 16 8 2 1 27 D.C. AMPERES 45 52 28 29 28
  • Poulan PPR1742STC | User Manual - Page 29
    REPAIR PARTS ELECTRICAL TRACTOR - - MODEL NUMBER PPR1742STC KEY PART NO. NO. DESCRIPTION 1 144925 2 74760412 8 156417 16 153664 21 166181 22 4152J 24 4799J 25 146147 26 166180 27 73510400 28 4207J 29 121305X 30
  • Poulan PPR1742STC | User Manual - Page 30
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC CHASSIS AND ENCLOSURES 17 30 24 29 18 24 12 28 25 26 31 3 208 25 26 5 5 53 51 58 52 55
  • Poulan PPR1742STC | User Manual - Page 31
    PARTS TRACTOR - - MODEL NUMBER PPR1742STC CHASSIS AND ENCLOSURES KEY PART 169468X428 Fender Footrest STLT Pnt 31 136619 Bracket Support Fender 33 145244X428 Footrest Pnt Lh 34 145243X428 16-18 x 1/2 TYT 38 169834 Bracket Asm. Pivot Mower Rear 51 73800400 Nut Lock Hex W/Ins 1/4-20 52 19091416
  • Poulan PPR1742STC | User Manual - Page 32
    REPAIR PARTS DRIVE TRACTOR - - MODEL NUMBER PPR1742STC 57 51 89 51 69 197 81 59 84 85 13 14 112 80 85 11 21 10 8 16 52 30 204
  • Poulan PPR1742STC | User Manual - Page 33
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC DRIVE KEY PART NO. NO. 1 ------ 2 146682 3 123666X 4 66 154778 Keeper Belt Engine Foolproof 69 142432 Screw Hex Wsh Hi-Lo 1/4-1/2 Unc 70 134683 Guide Belt Mower Drive RH 72 19132012 Washer 13/32 X 1-1/4 X 12 Ga 74 137057 Spacer Axle 75
  • Poulan PPR1742STC | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC STEERING ASSEMBLY 38 63 11 39 1 37 62 44 51 41 42 37 36 54 27 17 8 23 18 19 22 11 66 40 29 79 80 25 68 29 29 15 15 15 82 29 29 46 8 6 9 2 7 9 5 3 40 68 67 67 47 13 65 85 85 32 11 26 67 46 8 6 9 47 7 9 5 4 43 28 10 30 43 6 8 34
  • Poulan PPR1742STC | User Manual - Page 35
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 121472X Wheel Steering 2 154427 Axle 17 156546 Shaft Asm Strg 18 57079 Washer Thrust 515x 750x 033 19 160395 Support Shaft 22 165857 Screw Hex Wsh Hd Torx 23 165851 Shaft Asm Pittman 25
  • Poulan PPR1742STC | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 2 5 6 22 21 16 25 15 11 4 13 17 12 3 KEY PART NO. NO. 1 140117 2 140551 3 71110616 4 19131610 5 145006 6 73800600 7 124181 8 17000616 9 19131614 10 155925 11 166369 DESCRIPTION Seat Bracket Pivot
  • Poulan PPR1742STC | User Manual - Page 37
    Handle Lft Height Adjust Manual Owner's (English) Manual Owner's (French) WHEELS AND TIRES 1 2 5,8 4,10 7 6 KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 106222X Tire F Ts 15 X 6 0 - 6 Service 3,9 4 59904 Tube Front (Service Item Only) 5 106732X427 Rim
  • Poulan PPR1742STC | User Manual - Page 38
    REPAIR PARTS ENGINE TRACTOR - - MODEL NUMBER PPR1742STC 2 3 72 1 62 81 13 4 78 14 32 15 16 44 38 78 46 33 31 37 40 33 45 29 23 OPTIONAL EQUIPMENT Spark Arrester 38
  • Poulan PPR1742STC | User Manual - Page 39
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC ENGINE KEY PART NO. NO. DESCRIPTION 1 148875 Control Th/ch 36 Lh Flag 2 17720410 Screw Hex Thd Cut 1/4-20x5/8 T 3 Engine, Briggs Model 311777 (Order Parts From Engine Manufacturer) 4 137352 Muffler Exhaust 13 165291 Gasket Muffler 14
  • Poulan PPR1742STC | User Manual - Page 40
    REPAIR PARTS TRACTOR - - MODEL NUMBER PPR1742STC MOWER DECK 67 157 158 156 151 153 155 152 153 154 159 46 68 40 37 36 40 143 144 45 150 40 37 145
  • Poulan PPR1742STC | User Manual - Page 41
    REPAIR PARTS MOWER DECK TRACTOR - - MODEL NUMBER PPR1742STC KEY PART NO. NO. DESCRIPTION 1 165892 Mower Deck Assembly, 42" 2 72140506 Bolt 3 141043 Guard TUV Idler 67 106932X Knob 68 144959 V-Belt, 42" Mower KEY PART NO. NO. DESCRIPTION 90 74760616 91 132274 92 73800600 93 19171416
  • Poulan PPR1742STC | User Manual - Page 42
    REPAIR PARTS TRACTOR - MODEL NUMBER PPR1742STC MOWER LIFT 29 28 27 25 24 23 7 41 8 37 38 40 11 19 13 31 32 13 5 49 36 13 4 6 2 12 13 30 50 3 26 6 19 31 32 20 15 42 1 5 4 17 18 20 16 20 20 15
  • Poulan PPR1742STC | User Manual - Page 43
    REPAIR PARTS TRACTOR - MODEL NUMBER PPR1742STC MOWER LIFT KEY PART NO. NO. DESCRIPTION 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 125631X 8 124526X 11 139865 12 139866 13 4939M 15 167253 16 73350800 17 130171 18 73680800
  • Poulan PPR1742STC | User Manual - Page 44
    NOTES 44
  • Poulan PPR1742STC | User Manual - Page 45
    option, without charge for parts or labor incurred in replacing parts, any part which we find to be . Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used the product to an authorized service dealer. Should you have any unanswered
  • Poulan PPR1742STC | User Manual - Page 46
    instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural
  • Poulan PPR1742STC | User Manual - Page 47
    FOR SIGHTING SLOPES FOR SAFE OPERATION SIGHTING GUIDE CUT THIS IOSUAT1O5°NSDLOOTPTEED LINES ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. 15° MAX. 47 Operate your Tractor up and down the face of slopes (not greater than 15°), never across the
  • Poulan PPR1742STC | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under “saws” for Chain Saws or under “lawn mowers” for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PPR1742STC
LAWN TRACTOR
Always Wear Eye Protection During Operation
WARNING:
Read this Owner's Manual and
follow all Warnings and Safety
Instructions.
Failure to do so can
result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
173282
11.29.99
JH
Printed in U.S.A.