Poulan PR185H42STH User Manual

Poulan PR185H42STH Manual

Get Poulan PR185H42STH PDF manuals and user guides View all Poulan PR185H42STH manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PR185H42STH manual content summary:

  • Poulan PR185H42STH | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away 02478 OWNER'S MANUAL MODEL: PR185H42STH LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 183371 03.13.02 RH Printed in
  • Poulan PR185H42STH | User Manual - Page 2
    SAFETY RULES Safe Operation Practices for Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION • Read,understand,
  • Poulan PR185H42STH | User Manual - Page 3
    SAFETY RULES Safe Operation Practices for Ride-On Mowers • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan PR185H42STH | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to assemble
  • Poulan PR185H42STH | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve Steering Wheel Insert Steering Extension Shaft Steering Adapter (1) Large Flat Washer (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Slope Sheet (1)
  • Poulan PR185H42STH | User Manual - Page 6
    right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 1/2 HEX NUT LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut, from top to
  • Poulan PR185H42STH | User Manual - Page 7
    location and function of controls) WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects. • Be sure all the above assembly
  • Poulan PR185H42STH | User Manual - Page 8
    of this manual. 3CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton
  • Poulan PR185H42STH | User Manual - Page 9
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PR185H42STH | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PR185H42STH | User Manual - Page 11
    glasses or eye shields while operating your tractor or performing any adjustments or repairs. We rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig. OFF" position and remove key. • The average lawn should be cut to approximately 2-1/2 inches during
  • Poulan PR185H42STH | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired height of cut position, gauge wheels should be
  • Poulan PR185H42STH | User Manual - Page 13
    of the manufacturer of your tractor. Use common sense when towing manual). • To change engine oil, see the Customer Responsibilities section in this manual in storage. To avoid engine problems, the fuel system should be next season. See Storage Instructions for additional information. Never use
  • Poulan PR185H42STH | User Manual - Page 14
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan PR185H42STH | User Manual - Page 15
    MOWING TIPS IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the grass and not
  • Poulan PR185H42STH | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PR185H42STH | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PR185H42STH | User Manual - Page 18
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PR185H42STH | User Manual - Page 19
    dirty conditions), remove the blower housing and other cooling shrouds damaged, replace pre-cleaner. TO SERVICE CARTRIDGE • Clean cartridge by tapping or every other oil change if the tractor is used more than 100 hours in in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See
  • Poulan PR185H42STH | User Manual - Page 20
    , BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 18) Mower cable housing guide into bracket, slide collar onto guide and secure
  • Poulan PR185H42STH | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan PR185H42STH | User Manual - Page 22
    . • Make sure belt is in all pulley grooves and inside all belt guides. • Install mower (See "To Install Mower" in this section of manual). IDLER PULLEYS MANDREL PULLEYS FIG. 23 TO ADJUST BRAKE (See Fig. 24) Your tractor is equipped with an adjustable brake system which is mounted on the side of
  • Poulan PR185H42STH | User Manual - Page 23
    mower deck height to the lowest position. After above adjustment is made, if the tractor instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor purchased from your local parts dealer. Tire sealant also
  • Poulan PR185H42STH | User Manual - Page 24
    SERVICE AND ADJUSTMENTS TO START ENGINE WITH A WEAK BATTERY (See Fig. 28) (See "BATTERY" in the CUSTOMER RESPONSIBILITIES section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT SYSTEM. THE OTHER VEHICLE
  • Poulan PR185H42STH | User Manual - Page 25
    . TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PR185H42STH | User Manual - Page 26
    TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PR185H42STH | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PR185H42STH | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run 1. when operator leaves seat with attachment clutch engaged Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PR185H42STH | User Manual - Page 29
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 SCHEMATIC RED BATTERY BLACK BLACK A AMMETER (OPTIONAL) RED REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan PR185H42STH | User Manual - Page 30
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 ELECTRICAL 42 24 41 43 27 27 26 27 27 22 21 40 25 33 30 16 16 8 2 1 D.C. AMPERES 45 52 28 29 27 90 30
  • Poulan PR185H42STH | User Manual - Page 31
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 ELECTRICAL KEY PART NO. NO. 1 144927 2 74760412 8 176689 16 176138 21 175685 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan PR185H42STH | User Manual - Page 32
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 CHASSIS 17 159 30 24 212 29 25 26 31 3 208 18 25 26 5 5 12 28 24 53 51
  • Poulan PR185H42STH | User Manual - Page 33
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 CHASSIS KEY PART NO. NO. DESCRIPTION 1 174619 Chassis 2 176554 Drawbar x 3/4 37 17490508 Screw Thdrol 6/16-18 x 1/2 TYT 38 175710 Bracket Asm Pivot Mower Rear 51 73800400 Nut Lock Hex W/Ins 1/4-20 52 19091416 Washer 9/32 x 7/8
  • Poulan PR185H42STH | User Manual - Page 34
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 DRIVE 51 57 89 69 197 81 32 30 52 16 95 77 15 96 1 26 63 161 159
  • Poulan PR185H42STH | User Manual - Page 35
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 DRIVE KEY PART NO. NO. 1 ------ 8 165619 10 , Pedal Pulley, Engine Bolt, Hex Washer KEY PART NO. NO. DESCRIPTION 66 154778 Keeper Belt Engine 69 142432 Screw 70 134683 Guide Belt 71 169183 Strap Torque Lh Hydro 73 169182
  • Poulan PR185H42STH | User Manual - Page 36
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 STEERING ASSEMBLY 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 17 68 29 15 15 15 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 32 11 40 33 34 10 35 87 5 4 43 43 6 8 36
  • Poulan PR185H42STH | User Manual - Page 37
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 180656 Wheel Steering 2 172393 Axle Asm Cast Iron LT 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6
  • Poulan PR185H42STH | User Manual - Page 38
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 KEY PART 32 X 1 X 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 121248X 14 72050412 15 134300 16 121250X 17 123976X 21 171852
  • Poulan PR185H42STH | User Manual - Page 39
    Lft Height Adjust - - 183371 Manual Owner's (English) - - 183372 Manual Owner's (French) WHEELS AND TIRES 1 2 5,8 4,10 7 6 3,9 11 KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 170455 Tire F T 15 X 6 0 - 6 Service 4 59904 Tube Front (Service Item Only
  • Poulan PR185H42STH | User Manual - Page 40
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 ENGINE 2 1 14 25 38 26 17 32 44 46 31 112 33 37 40 33 41 23 29 OPTIONAL EQUIPMENT Spark Arrester 8 3 13 10 81 17 16 6 5 62 72 45 4 40
  • Poulan PR185H42STH | User Manual - Page 41
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 ENGINE KEY PART NO. NO. 1 170771 2 17720408 3 ------- 4 149723 Control, Throttle Screw Hex Thd Cut 1/4-20 x 1/2 Engine Briggs Model 445777 (Order Parts from Engine Mfg.) Muffler, Asm. Twin Lo-Tone Pipe Exhaust Intek 20 RH Pipe Exhaust
  • Poulan PR185H42STH | User Manual - Page 42
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 MOWER DECK 158 151 152 67 157 156 153 155 159 153 154 46 68 40 37 36 40 143 144 45 150 40 37 145
  • Poulan PR185H42STH | User Manual - Page 43
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 MOWER DECK KEY NO. 1 2 3 4 5 6 8 9 10 11 13 149 150 151 152 153 154 155 156 157 158 159 182 183 - - - - PART NO. 180532 132264 180533 136420 71081010 19061216 10071000 160793 2029J 179292X421 179293X421 17060510 73510500 72110505 4898H
  • Poulan PR185H42STH | User Manual - Page 44
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 MOWER LIFT 29 28 27 25 24 23 7 41 8 37 5 49 38 30 40 36 13 1 50 3 4 26 6 2 6 11 5 12 4 19 13 31 32 13 31 32 13 19 20 15 17 18 20 16 20 20 15 44
  • Poulan PR185H42STH | User Manual - Page 45
    TRACTOR - - MODEL NUMBER PR185H42STH PRODUCT NO. 954 56 67-82 MOWER LIFT KEY PART NO. NO. DESCRIPTION 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 125631X 8 170770 11 139865 12 139866 13 4939M 15 173288 16 73350800 17 175689 18 73800800
  • Poulan PR185H42STH | User Manual - Page 46
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PR185H42STH | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PR185H42STH | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under “saws” for Chain Saws or under “lawn mowers” for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PR185H42STH
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow
all Warnings and Safety Instructions.
Failure to do so can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
183371
03.13.02
RH
Printed in U.S.A.
02478