Poulan PR20H42STD User Manual

Poulan PR20H42STD Manual

Get Poulan PR20H42STD PDF manuals and user guides View all Poulan PR20H42STD manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PR20H42STD manual content summary:

  • Poulan PR20H42STD | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL: PR20H42STD LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION 180002 6.27.01 RD Printed in U.S.A.
  • Poulan PR20H42STD | User Manual - Page 2
    SAFETY RULES SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION • Read,understand,
  • Poulan PR20H42STD | User Manual - Page 3
    SAFETY RULES Safe Operation Practices for Ride-On Mowers • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan PR20H42STD | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to assemble
  • Poulan PR20H42STD | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Sleeve Steering Wheel Insert Steering Extension Shaft (1) Hex Bolt 3/8-16 x 1 Steering Adapter (1) Large Flat Washer (1) Washer 17/32 x 1-3/16 x 12 Gauge (1)
  • Poulan PR20H42STD | User Manual - Page 6
    hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 3/8 HEX BOLT 3/8 LOCK WASHER LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut, from
  • Poulan PR20H42STD | User Manual - Page 7
    follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear USE YOUR MOWER WITH THE HIGH PERFORMANCE BLADES THE MULCHER PLATE MUST BE REMOVED FROM THE MOWER (SEE FIG. 4). TO SET UP YOUR MOWER FOR MULCHING
  • Poulan PR20H42STD | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PR20H42STD | User Manual - Page 9
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PR20H42STD | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual engage the mower blades, or other attachments mounted to your tractor. LIGHT
  • Poulan PR20H42STD | User Manual - Page 11
    reduces the battery charging rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig. 6) Use choke remove key. Always remove key when leaving tractor to prevent unauthorized use. 11 The average lawn should be cut to approximately 2-1/2 inches during
  • Poulan PR20H42STD | User Manual - Page 12
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired height of cut position, gauge wheels should be
  • Poulan PR20H42STD | User Manual - Page 13
    of the manufacturer of your tractor. Use common sense when towing manual). • To change engine oil, see the Customer Responsibilities section in this manual in storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use
  • Poulan PR20H42STD | User Manual - Page 14
    lever three (3) times. • Your tractor is now purged and now ready for normal operation. MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for
  • Poulan PR20H42STD | User Manual - Page 15
    MOWING TIPS IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the grass and not
  • Poulan PR20H42STD | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PR20H42STD | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PR20H42STD | User Manual - Page 18
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PR20H42STD | User Manual - Page 19
    dirty conditions), remove the blower housing and other cooling shrouds. damaged, replace pre-cleaner. TO SERVICE CARTRIDGE • Clean cartridge by tapping other oil change if the tractor is used more than 100 hours in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See Fig
  • Poulan PR20H42STD | User Manual - Page 20
    lift lever to its lowest position. • Install mower in reverse order of removal instructions. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or
  • Poulan PR20H42STD | User Manual - Page 21
    front is approximately 1/8" to 1/2" lower than the rear when the mower is in its highest position. Check adjustment on right side of tractor. Measure distance "D" directly in front and behind the mandrel at bottom edge of mower housing as shown. • Before making any necessary adjustments, check that
  • Poulan PR20H42STD | User Manual - Page 22
    SERVICE CENTER/DEPARTMENT FIG. 24 TO REPLACE MOTION DRIVE BELT (See Fig. 25) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. • Remove mower (See "TO REMOVE MOWER" in this section of this manual
  • Poulan PR20H42STD | User Manual - Page 23
    mower deck height to the lowest position. After above adjustment is made, if the tractor instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor purchased from your local parts dealer. Tire sealant also
  • Poulan PR20H42STD | User Manual - Page 24
    SERVICE AND ADJUSTMENTS TO START ENGINE WITH A WEAK BATTERY (See Fig. 28) See "BATTERY" in the CUSTOMER RESPONSIBILITIES section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT NEGATIVE GROUNDED SYSTEM.
  • Poulan PR20H42STD | User Manual - Page 25
    . TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PR20H42STD | User Manual - Page 26
    TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PR20H42STD | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PR20H42STD | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PR20H42STD | User Manual - Page 29
    SCHEMATIC TRACTOR - - MODEL NUMBER PR20H42STD BLACK RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED S BM G REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan PR20H42STD | User Manual - Page 30
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD ELECTRICAL 21 22 42 24 41 43 27 27 26 40 27 27 25 33 30 16 16 8 2 1 D.C. AMPERES 45 52 28 29 27 30
  • Poulan PR20H42STD | User Manual - Page 31
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 163465 2 74760412 8 156417 16 153664 21 166181 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30
  • Poulan PR20H42STD | User Manual - Page 32
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD CHASSIS 17 159 30 24 212 29 18 24 12 28 25 26 31 3 208 25 26 5 5 53 51 58 52 55 57 208 11 9 207 208 207 54 20 23 26 64 3 35 3 33 3 10 3 142 207 1 13 2 206 37 145 37 3 3 142 3 3 208 14 35 3 14 38 34 26 32
  • Poulan PR20H42STD | User Manual - Page 33
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD CHASSIS KEY PART NO. NO. DESCRIPTION 1 174619 Chassis 2 176554 Drawbar 3 x 3/4 37 17490508 Screw Thdrol 6/16-18 x 1/2 TYT 38 175710 Bracket Asm Pivot Mower Rear 51 73800400 Nut Lock Hex W/Ins 1/4-20 52 19091416 Washer 9/32 x 7/8 x
  • Poulan PR20H42STD | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD DRIVE 51 57 89 69 197 81 32 30 52 16 95 77 15 96 1 26 63 169 198 161 159 158
  • Poulan PR20H42STD | User Manual - Page 35
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD DRIVE KEY PART NO. NO. 1 ------ 8 165619 10 76020416 Cover, Pedal Pulley, Engine Bolt, Hex Washer KEY PART NO. NO. DESCRIPTION 66 154778 Keeper Belt Engine 69 142432 Screw 70 134683 Guide Belt 71 169183 Strap Torque Lh Hydro 73 169182
  • Poulan PR20H42STD | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD STEERING ASSEMBLY 38 63 11 39 1 37 44 51 91 43 41 42 37 36 54 88 71 29 29 17 68 29 15 15 15 82 29 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 3 32 11 40 33 34 10 35 87 5 4 43 43 6 8 36
  • Poulan PR20H42STD | User Manual - Page 37
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 159944X428 Wheel Steering 2 172393 Axle Asm Cast Iron LT 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6
  • Poulan PR20H42STD | User Manual - Page 38
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 2 21 16 25 15 11 4 13 17 12 3 KEY PART NO. 13/32 X 1 X 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 121248X 14 72050412 15 134300 16 121250X 17 123976X 21 171852 22
  • Poulan PR20H42STD | User Manual - Page 39
    Reflector Rh Decal Fend Reflector Lh Manual Owner's (English) Manual Owner's (French) KEY PART NO. NO. DESCRIPTION 1 2 3 4 5 6 11 7 8 9 10 11 - - 59192 Cap Valve Tire 65139 Stem Valve 170455 Tire F T 15 X 6 0 - 6 Service 59904 Tube Front (Service Item Only) 106732X421 Rim Asm 6"front
  • Poulan PR20H42STD | User Manual - Page 40
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD ENGINE 2 1 32 31 14 38 25 81 26 17 44 46 33 37 33 23 29 OPTIONAL EQUIPMENT Spark Arrester 3 13 8 10 17 16 6 5 11 12 45 4 40
  • Poulan PR20H42STD | User Manual - Page 41
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD ENGINE KEY PART NO. NO. DESCRIPTION 1 170771 Control Throt 2 17720410 Screw Hex Thd Cut 1/4-20x5/8 T 3 Engine B&S Model No. 445777 (Order parts from engine manufacturer) 4 149723 Muffler Exhaust 5 159955 Exhaust Asm. Lh 6 160589
  • Poulan PR20H42STD | User Manual - Page 42
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD MOWER DECK 158 151 152 67 157 156 153 155 159 153 154 46 68 40 37 36 40 143 144 45 150 40 37 145
  • Poulan PR20H42STD | User Manual - Page 43
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD MOWER DECK KEY PART NO. NO. DESCRIPTION 1 165892X421 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460X431 Bracket Asm Deck 42" Sway Bar 5 4939M Retainer Spring 6 130832 Arm, Suspension,
  • Poulan PR20H42STD | User Manual - Page 44
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD MOWER LIFT 41 37 38 40 11 19 13 36 5 13 4 6 12 13 31 32 19 13 31 32 7 8 3 1 2 6 5 4 20 15 17 18 20 16 20 20 15 44
  • Poulan PR20H42STD | User Manual - Page 45
    REPAIR PARTS TRACTOR - - MODEL NUMBER PR20H42STD MOWER LIFT KEY PART NO. NO. DESCRIPTION 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 125631X 8 170770 11 139865 12 139866 13 4939M 15 173288 16 73350800 17 175689 18 73800800
  • Poulan PR20H42STD | User Manual - Page 46
    , without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PR20H42STD | User Manual - Page 47
    FOR SIGHTING SLOPES FOR SAFE OPERATION SIGHTING GUIDE CUT THIS IOSUAT1O5NSDLOOTPTEED LINES ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. 15 MAX. 47 Operate your Tractor up and down the face of slopes (not greater than 15 ), never across the
  • Poulan PR20H42STD | User Manual - Page 48
    pages of your phone directory for the name of the nearest service dealer (under “saws” for Chain Saws or under “lawn mowers” for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PR20H42STD
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
WARNING:
Read this Owner's Manual and follow
all Warnings and Safety Instructions±
Failure to do so can result in serious
injury±
IMPORTANT MANUAL
Do Not Throw Away
180002
6.27.01
RD
Printed in U.S.A.