Poulan PR25PH48STA User Manual

Poulan PR25PH48STA Manual

Get Poulan PR25PH48STA PDF manuals and user guides View all Poulan PR25PH48STA manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PR25PH48STA manual content summary:

  • Poulan PR25PH48STA | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL: WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. PR25PH48STA LAWN TRACTOR Always Wear Eye Protection During Operation 180278 Rev. 3 6.20.02 RD Printed in
  • Poulan PR25PH48STA | User Manual - Page 2
    riding mower safely enough to protect themselves and others from serious injury. IV. SERVICE • Use extra care in handling gasoline and other fuels. They are flammable and vapors are explosive. - Use only an approved container. - Never remove gas cap or add fuel with the engine running. Allow engine
  • Poulan PR25PH48STA | User Manual - Page 3
    with specifications of the manufacturer of your tractor. Use common sense when towing. Operate only at the lowest possible speed when on a slope. Too heavy of a load, while on a slope, is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine
  • Poulan PR25PH48STA | User Manual - Page 4
    (See REPAIR PARTS section of this manual). TABLE OF CONTENTS SAFETY RULES 2-3 PRODUCT SPECIFICATIONS 4 CUSTOMER RESPONSIBILITIES 4, 16-19 ASSEMBLY 6-9 OPERATION 10-15 MAINTENANCE SCHEDULE 16 SERVICE AND ADJUSTMENTS 20-25 STORAGE 26 TROUBLESHOOTING 27-28 REPAIR PARTS - TRACTOR 30-43
  • Poulan PR25PH48STA | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Steering Sleeve Gauge Wheels (4) Shoulder Bolts (4) Adjusting Bars (4) Wheels Nose Roller (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob (2) Flanged Pins Mower (1) Front Plate Assembly (2) Locknuts 5/16-18 Rod Retainer Spring Nose Roller Brackets (2) Hex
  • Poulan PR25PH48STA | User Manual - Page 6
    all four corners of carton, and lay panels flat. • Remove mower and packing materials. • Check for any additional loose parts or cartons and remove. STEERING WHEEL EXTENTION STEERING SHAFT STEERING SLEEVE TABS BEFORE REMOVING TRACTOR FROM SKID ATTACH STEERING WHEEL (See Fig. 1) • Remove locknut
  • Poulan PR25PH48STA | User Manual - Page 7
    all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear 3/8-16 center locknuts and tighten securely. • For ease of mower to tractor assembly, raise gauge wheels to highest position and retain with clevis
  • Poulan PR25PH48STA | User Manual - Page 8
    of mower deck. • Slide mower under tractor with deflector shield to right side of tractor. IMPORTANT: Check belt for proper routing in all mower pulley mower suspension. • Raise deck to highest position. • Adjust gauge wheels before operating mower as shown in the Operation section of this manual
  • Poulan PR25PH48STA | User Manual - Page 9
    • Reduce tire pressure to PSI shown in "PRODUCT SPECIFICATIONS" section of this manual. CHECK MOWER LEVELNESS For best cutting results, mower should be properly leveled. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. CHECK FOR PROPER POSITION OF ALL BELTS See the
  • Poulan PR25PH48STA | User Manual - Page 10
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PR25PH48STA | User Manual - Page 11
    WHEEL CONTROL - Disengages transmission for pushing or slowly towing the tractor with the engine off. BRAKE PEDAL - Used for braking the tractor and starting the engine. HEIGHT ADJUSTMENT KNOB - Used to adjust the mower cutting height. HOURMETER - Indicates hours of operation. AMMETER - Indicates
  • Poulan PR25PH48STA | User Manual - Page 12
    be used for forward travel only. FIG. 8 STOPPING (See Fig. 8) MOWER BLADES - • With forward drive pedal depressed to desired speed, move cruise control To eliminate this possibility, always stop engine when stopping tractor on grass areas. 12 The average lawn should be cut to approximately 2-1/2
  • Poulan PR25PH48STA | User Manual - Page 13
    tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual attachments that are recommended by and comply with specifications of the manufacturer of your tractor. Use common sense when towing. Too heavy
  • Poulan PR25PH48STA | User Manual - Page 14
    while in storage. To avoid engine problems, the fuel system should be emptied before storage of 30 days or longer. Drain the gas tank, start the engine and let it run until the fuel lines and carburetor are empty. Use fresh fuel next season. See Storage Instructions for additional information. Never
  • Poulan PR25PH48STA | User Manual - Page 15
    procedure three times. • Your tractor is now purged and now ready for normal operation. MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for
  • Poulan PR25PH48STA | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PR25PH48STA | User Manual - Page 17
    tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). TIRES • Maintain proper air pressure in all tires (See "PRODUCT SPECIFICATIONS" section of this manual
  • Poulan PR25PH48STA | User Manual - Page 18
    oil has drained completely, replace oil drain plug and tighten securely. • Refill engine with oil through oil fill dipstick tube. Pour slowly. Do not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level. Be
  • Poulan PR25PH48STA | User Manual - Page 19
    engine oil. Wrap it in clean, absorbent cloth and squeeze to remove excess oil. • If very dirty or damaged, replace pre-cleaner. TO SERVICE CARTRIDGE PRODUCT SPECIFICATIONS" section of this manual. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor
  • Poulan PR25PH48STA | User Manual - Page 20
    "OFF" and remove key. • Make sure the blades and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 19) • Place attachment clutch in "DISENGAGED" position. • If equipped
  • Poulan PR25PH48STA | User Manual - Page 21
    suspension. • Raise deck to highest position. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust
  • Poulan PR25PH48STA | User Manual - Page 22
    SERVICE AND ADJUSTMENTS • To raise front of blade, loosen nut "D" from trunnion the tractor on level surface. Engage parking brake. • Remove mower drive belt (See "TO REPLACE MOWER DRIVE BELT" in this section of this manual). • Remove mower (See "TO REMOVE MOWER" in this section of this manual). •
  • Poulan PR25PH48STA | User Manual - Page 23
    SERVICE CENTER/DEPARTMENT FIG. 26 TO REPLACE MOTION DRIVE BELT (See Fig. 27) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. • Remove mower (See "TO REMOVE MOWER" in this section of this manual parts
  • Poulan PR25PH48STA | User Manual - Page 24
    Repair Parts section. TO REPLACE FUSE Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash. TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 31) • Raise hood. • Unsnap headlight wire connector. • Stand in front of tractor. Grasp hood at sides, tilt toward engine
  • Poulan PR25PH48STA | User Manual - Page 25
    cover assembly and tighten knob. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust
  • Poulan PR25PH48STA | User Manual - Page 26
    etc. Store in a clean, dry area. • Clean entire tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt replacement instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Customer
  • Poulan PR25PH48STA | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wiring. 9. Carburetor out of adjustment. 10. Engine valves out of adjustment.
  • Poulan PR25PH48STA | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM Engine continues to run when operator leaves seat with attachment clutch engaged CAUSE 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department. Poor
  • Poulan PR25PH48STA | User Manual - Page 29
    TRACTOR - MODEL NUMBER PR25PH48STA PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) FUEL SHUT-OFF SOLENOID CHARGING SYSTEM OUTPUT 16 BROWN BLACK WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. HEADLIGHTS
  • Poulan PR25PH48STA | User Manual - Page 30
    REPAIR PARTS ELECTRICAL TRACTOR - MODEL NUMBER PR25PH48STA 22 21 79 42 24 41 43 40 26 27 27 81 25 16 33 30 50 10 11 27 D.C. AMPERES 45 89 46 29 55 28 12 2 1 8 12 30
  • Poulan PR25PH48STA | User Manual - Page 31
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA ELECTRICAL KEY PART NO. NO. 1 144927 2 74760412 8 7603J 10 145211 11 150109 12 145769 16 176138 21 175688 24 8860R 25 146148 26 175158 27 73510400 28 145491
  • Poulan PR25PH48STA | User Manual - Page 32
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA CHASSIS AND ENCLOSURES 17 159 10 161 10 30 29 166 166 28 31 9 3 209 155 166 11 209 156 157 209 166 54 58
  • Poulan PR25PH48STA | User Manual - Page 33
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 174619 Chassis 2 176554 Drawbar 37 17490508 Screw Thdrol 6/16-18 x 1/2 TYT 38 175710 Bracket, Asm. Pivot Mower Rear 54 161464 Screw Hex Wshd 8-18 x 7/8 58 175351 Duct Hood 59 177579
  • Poulan PR25PH48STA | User Manual - Page 34
    REPAIR PARTS DRIVE TRACTOR - MODEL NUMBER PR25PH48STA 57 51 89 243 116 212 63 254 240 16 90 221 219 19 59 19 221 56 214 254 222 215 224 61 51
  • Poulan PR25PH48STA | User Manual - Page 35
    PARTS TRACTOR - MODEL NUMBER PR25PH48STA DRIVE KEY NO. 1 6 9 15 16 17 19 20 21 22 24 25 26 27 28 29 30 32 33 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 59 61 62 63 65 66 74 75 76 PART 18 Unc x 3/4 Shaft, Foot Pedal Bearing, Pedal Pulley, Engine Washer Keeper Belt Engine Spacer, Axle Washer
  • Poulan PR25PH48STA | User Manual - Page 36
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA STEERING ASSEMBLY 38 12 72 1 37 91 43 68 29 15 73 41 42 37 36 88 71 29 17 46 8 6 2 87 5 68 67 13 65 46 8 6 67 67 82 29 3 32 11 40 33 10 34 35 87 5 4 43 43 6 8 36
  • Poulan PR25PH48STA | User Manual - Page 37
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 159944X428 Wheel Steering 20 UNF 13 136518 Spacer Brg Axle Front 15 145212 Nut Hex Flange Lock 17 177883 Shaft Asm Strg 29 17060612 Screw 3/8-16x3/4 32 170162 Rod Tie 33 19111216 Washer 11/32
  • Poulan PR25PH48STA | User Manual - Page 38
    PARTS TRACTOR - MODEL NUMBER PR25PH48STA ENGINE 2 8 1 15 38 25 14 26 17 32 34 31 33 3 13 81 5 17 62 16 72 10 6 37 39 33 45 23 29 4 OPTIONAL EQUIPMENT Spark Arrester KEY PART Choke Control KEY PART NO. NO. DESCRIPTION 26 73920600 29 137180 31 157103 32 140527 33 123487X
  • Poulan PR25PH48STA | User Manual - Page 39
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 2 5 6 22 21 16 25 15 11 13 17 12 KEY PART NO. NO. 1 171684 2 140551 3 71110616 4 19131610 5 145006 6 73800600 7 124181X 8 17000616 9 19131614 10 174894 11 166369 12 121246X DESCRIPTION Seat Bracket Pivot
  • Poulan PR25PH48STA | User Manual - Page 40
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA DECALS 11 2 12 16 4 4 3 10 2 9 1 8 20 6 5 KEY PART NO. NO. 1 164097 2 176303 3 176273 4 181085 5 180975 6 173587 7 173589 8 170563 9 172740 10 157140 11 172743 14 7 DESCRIPTION 13 15 KEY PART NO. NO. DESCRIPTION Decal Dash Decal Fender
  • Poulan PR25PH48STA | User Manual - Page 41
    PARTS TRACTOR - MODEL NUMBER PR25PH48STA MOWER LIFT 29 28 27 25 24 23 7 41 8 KEY NO. 1 2 3 4 5 6 7 8 11 12 13 15 16 17 18 20 23 24 25 26 PART 13 32 51 13 32 53 49 20 54 13 DESCRIPTION Wire Asm Inner/Sprg W/plunger Shaft Asm Lift RH w/Inf Pin Groove E Ring #5133-62 Washer 21/32 X 1 X
  • Poulan PR25PH48STA | User Manual - Page 42
    REPAIR PARTS TRACTOR - MODEL NUMBER PR25PH48STA MOWER DECK 46 45 33 49 36 130 52 49 36 37 32 42 112 31 49 36 99 33 43 30 121 126 49 42
  • Poulan PR25PH48STA | User Manual - Page 43
    PARTS TRACTOR - MODEL NUMBER PR25PH48STA MOWER DECK KEY PART NO. NO. DESCRIPTION 1 180358X421 Deck Weldment Mower 48 3 138017 Bracket Asm., Sway Bar 5 4939M Retainer Spring 6 178024 Arm, Suspension, Rear Sway Bar Deck 8 174365 Bolt 7/16 Asm. Blade 11 180054 Blade 13 174360 Shaft
  • Poulan PR25PH48STA | User Manual - Page 44
    engine, other than EHP manufactured transaxle/transmission components, battery (except as noted below) or components parts in accordance with the instructions furnished. 4. The authorized service dealer. giving the model number, serial This Warranty gives you specific legal rights, and you
  • Poulan PR25PH48STA | User Manual - Page 45
    45 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PR25PH48STA | User Manual - Page 46
    SERVICE NOTES 46
  • Poulan PR25PH48STA | User Manual - Page 47
    SERVICE NOTES 47
  • Poulan PR25PH48STA | User Manual - Page 48
    ” for Chain Saws or under “lawn mowers” for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number. b. Description of part. NOTE: Electrolux Home Products provides parts and service through its authorized
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S MANUAL
MODEL:
PR25PH48STA
LAWN TRACTOR
Always Wear Eye Protection During Operation
WARNING:
Read this Owner's Manual and
follow all Warnings and Safety
Instructions.
Failure to do so
can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
180278
Rev. 3
6.20.02
RD
Printed in U.S.A.