Poulan PRGT2046A User Manual

Poulan PRGT2046A Manual

Get Poulan PRGT2046A PDF manuals and user guides View all Poulan PRGT2046A manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PRGT2046A manual content summary:

  • Poulan PRGT2046A | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL: PRGT2046A LAWN TRACTOR WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. Always Wear Eye Protection During Operation 1 177271 Rev. 2 8.24.01 TR Printed in
  • Poulan PRGT2046A | User Manual - Page 2
    RIDE-ON MOWERS IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION DO NOT: • Read, understand, and follow all instructions in the manual
  • Poulan PRGT2046A | User Manual - Page 3
    RULES Safe Operation Practices for Ride-On Mowers • Check brake operation frequently. Adjust and service as required. • Be can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or
  • Poulan PRGT2046A | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PRGT2046A | User Manual - Page 5
    Retainer Springs (double loop) (4) Wheels (4) Clevis Pins (4) Locknut 3/8-16 (4) Washers 3/8 x 3/4 x 14 Ga. (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Mower (2) Front Link Assemblies Keys Slope Sheet (2) Keys Slope Sheet (1) Oil Drain Tube For Future Use (3) Retainer Springs (double loop
  • Poulan PRGT2046A | User Manual - Page 6
    ratchet When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut, from top to bottom, along lines
  • Poulan PRGT2046A | User Manual - Page 7
    tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. 7 WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor . • For ease of mower to tractor assembly, raise gauge wheels to
  • Poulan PRGT2046A | User Manual - Page 8
    section of this manual) • Store mulcher blades and mulcher plate in a safe place. Your mower is now ready for discharging or installation of optional grass catcher accessory. INSTALL MOWER AND DRIVE BELT (See Fig. 7) Be sure tractor is on level surface and mower suspension arms are raised
  • Poulan PRGT2046A | User Manual - Page 9
    See the figures that are shown for replacing motion, mower drive, and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly
  • Poulan PRGT2046A | User Manual - Page 10
    TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST:  All assembly instructions have been completed.  No remaining loose parts properly inflated for leveling).  Check mower and drive belts. Be sure they
  • Poulan PRGT2046A | User Manual - Page 11
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PRGT2046A | User Manual - Page 12
    American National Standards Institute. ATTACHMENT CLUTCH SWITCH - Used to engage mower blades or other attachments mounted to your tractor. LIFT LEVER - Used to raise and lower mower deck or other attachments mounted to your tractor. LIFT LEVER PLUNGER - Used to release attachment lift lever when
  • Poulan PRGT2046A | User Manual - Page 13
    being mowed. • Move throttle control to slow position. • The average lawn should be cut to approximately 2-1/2 NOTE: Failure to move throttle control engine when stopping tractor on grass areas. • Be sure tractor is on a flat level surface. • Lower mower and adjust mower to desired cutting
  • Poulan PRGT2046A | User Manual - Page 14
    tractor. Use an appropriate means of tying hood to tractor (rope, cord, etc.). TO OPERATE MOWER (See Fig. 11) TOWING CARTS AND OTHER ATTACHMENTS Your tractor manual). • To change engine oil, see the Customer Responsibilities section in this manual avoid engine problems, the with Instructions for
  • Poulan PRGT2046A | User Manual - Page 15
    in the Service and Adjustments section of this manual. MOWING TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be reduce them in size so that as they fall onto the lawn they will disperse into the grass and not be noticed. Also, the mulched grass
  • Poulan PRGT2046A | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PRGT2046A | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PRGT2046A | User Manual - Page 18
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PRGT2046A | User Manual - Page 19
    dirty conditions), remove the blower housing and other cooling shrouds. damaged, replace pre-cleaner. TO SERVICE CARTRIDGE • Clean cartridge by tapping other oil change if the tractor is used more than 100 hours in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See Fig
  • Poulan PRGT2046A | User Manual - Page 20
    adjusting. BOTTOM EDGE OF MOWER TO GROUND BOTTOM EDGE OF MOWER TO GROUND TO INSTALL MOWER Follow procedure described in "INSTALL MOWER AND A A DRIVE BELT" in the Assembly section of this manual. GROUND LINE TO LEVEL MOWER HOUSING FIG. 21 Adjust the mower while tractor is parked on level
  • Poulan PRGT2046A | User Manual - Page 21
    DRIVE BELT (See Fig. 25) Park the tractor on level surface. Engage parking brake. • Remove mower drive belt (See "TO REPLACE MOWER DRIVE BELT" in this section of this manual). • Remove mower (See "TO REMOVE MOWER" in this section of this manual). • Remove screws from R.H. mandrel cover and remove
  • Poulan PRGT2046A | User Manual - Page 22
    SERVICE AND ADJUSTMENTS • Reinstall mower to tractor (See "INSTALL MOWER AND DRIVE BELT" in the Assembly section of this manual). • Reassemble mower drive belt (See "TO REPLACE MOWER DRIVE BELT" in this section of this manual). L.H. MANDREL MOWER BLADE DRIVE BELT CENTER MANDREL IDLER PULLEY R.H.
  • Poulan PRGT2046A | User Manual - Page 23
    steering wheel and reassemble per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN your tractor. If damage has occurred to affect the front wheel camber, contact your nearest authorized service center/department your local parts dealer. Tire sealant also prevents tire dry rot and
  • Poulan PRGT2046A | User Manual - Page 24
    SERVICE manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts ATTACHMENTS SUCH AS A MOWER. ADJUST LIFT LEVER SPRING
  • Poulan PRGT2046A | User Manual - Page 25
    . TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PRGT2046A | User Manual - Page 26
    TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PRGT2046A | User Manual - Page 27
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PRGT2046A | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Engine continues to run 1. when operator leaves seat with attachment clutch engaged Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PRGT2046A | User Manual - Page 29
    SCHEMATIC TRACTOR - - MODEL NUMBER PRGT2046A RED BLACK BATTERY SOLENOID A AMMETER ( + A1 NONE L + A2 NONE NONE WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 87 86 87A 85 30 RELAY PTO SWITCH
  • Poulan PRGT2046A | User Manual - Page 30
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A ELECTRICAL 22 21 79 41 24 43 42 27 25 40 81 27 33 30 11 12 2 1 8 10 27 D.C. AMPERES 45 26 12 29 52 50 16 28 30
  • Poulan PRGT2046A | User Manual - Page 31
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A ELECTRICAL KEY PART NO. NO. 1 144926 2 74760412 8 7603J 10 145211 11 150109 12 145769 16 153664 21 166184 22 4152J 24 4206J 25 146149 26 108824X 27 73510400
  • Poulan PRGT2046A | User Manual - Page 32
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A CHASSIS AND ENCLOSURES 157 14 153 130 138 5 158 37 141 140 148 36 31 68 35 152 36 130 18 130
  • Poulan PRGT2046A | User Manual - Page 33
    Thdrol 3/8-16 x 1-1/4 63 19131614 Washer 13/32 x 1 x 14 Ga. 67 156973 Guide Belt Gear Dr. 68 17490508 Screw, Thd 5/16-18 x 1/2 70 137159 Guide, Belt Mid Span 84 142992 Stop, Over Center Mower 85 144911 Bracket Support Transaxle 86 74760716 Bolt, Fin Hex 7/16-14 Unc x 1 88 10040700 Washer
  • Poulan PRGT2046A | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A GROUND DRIVE 39 42 40 41 38 37 6 30 29 36 6 46 68 30 17 51 28 9 21 8 13 7 69 64 35
  • Poulan PRGT2046A | User Manual - Page 35
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A GROUND DRIVE KEY PART NO. NO. 1 9858M1 3 7563R 4 x 3/4 Spring Lever, Brake Cam, Brake Disc Screw, Flat Head 1/4-28 x 3/4 Gearshift, Lever Assembly Knob Support, Puck Brake Puck, Brake Top Spring, Return Screw, Hex Wsh Thd. 5/16-18 x 1-3/4 Nut, Hex
  • Poulan PRGT2046A | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A STEERING ASSEMBLY 26 25 14 45 9 8 7 2 1 6 6 4 44 21 14 20 15 23 3 12 11 10 15 14 14 9 87 3 6 6 5 34 33 32 6 27 14 22 31 8 41 6 29 14 15 13 13 36 37,39 38,40 17 14 78 42 28 19 27 6 16 15 14 35 14 18 36
  • Poulan PRGT2046A | User Manual - Page 37
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 159944X428 Wheel, Steering 2 137094 Shaft Asm., Steering 17 137347 Rod Tie Service 18 137155 Draglink, Ball Joint Solid Vgt 19 156011 Support Asm., Steering Vgt 20 163887X428 Boot Steering
  • Poulan PRGT2046A | User Manual - Page 38
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A ENGINE 22 25 21 1 20 18 15 17 10 37 16 26 28 37 27 31 39 83 69 62 45 84 74 24 84 82 71 70 35 79 12 11 81 2 41 42 43 47 9 29 8 SPARK ARRESTER KIT 40 38
  • Poulan PRGT2046A | User Manual - Page 39
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A ENGINE KEY PART NO. NO. 1 ------2 149723 8 121361X 9 150828 10 175287 11 170056 12 143996 15 151346 16 109227X 17 106082X 18 140527 20 164067 21 164863 22 164068
  • Poulan PRGT2046A | User Manual - Page 40
    PARTS TRACTOR - - MODEL NUMBER PRGT2046A SEAT ASSEMBLY 1 20 14 20 8 10 8 7 7 16 5 15 4 18 6 13 19 17 12 2 5 22 21 3 KEY PART UNC x 3/4 w/Sems Pan, Seat Bracket, Mounting Switch Bushing, Snap KEY PART NO. NO. DESCRIPTION 14 72050412 15 121249X 16 123740X 17 123976X 18 19171912
  • Poulan PRGT2046A | User Manual - Page 41
    Mower, Warning Decal, Battery Reflector, Taillight Decal, Fender Decal, Replacement Parts Decal, Handle Lift (Lift Handle) Pad Footrest Manual, Owner's (English) Manual ) 9 9 105588X Tire, Rear 8 10 7154J Tube, Rear (Service Item Only) 11 106277X427 Rim Assembly, Rear 12 6856M Fitting, Grease
  • Poulan PRGT2046A | User Manual - Page 42
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A LIFT ASSEMBLY 40 42 43 39 38 4 5 54 35 73 34 31 32 30 7 8 9 10 70 3 29 72 33 11 13 23 14 41 23 14 41 23 11 12 23 13 12 22 12 2 78 26 24 12 21 6 73 20 19 18 15 1 16 42
  • Poulan PRGT2046A | User Manual - Page 43
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A LIFT ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 121006X 2 159187 3 159189 4 12000022 5 19292016 6 71110624 7 125631X 8 170770 9 122364X 10 2876H 11 146704 12 163552 13 139868 14 169865 15 73680600 16
  • Poulan PRGT2046A | User Manual - Page 44
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A MOWER DECK 46 45 49 36 41 127 41 126 42 42 44 50 49 36 46 37 43 40 33 39 32 35 50 72
  • Poulan PRGT2046A | User Manual - Page 45
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A MOWER DECK KEY PART NO. NO. DESCRIPTION 1 156833 Deck Weldment 2 138457 Bracket Asm., Sway Bar 5 4939M components Key Nos. 101-106 and 116-118) Mandrel Asm. 44"/50" service (Includes Key Nos. 8-10, 13-15, 31 and 33) NOTE: All component dimensions given in U.S.
  • Poulan PRGT2046A | User Manual - Page 46
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A TRANSAXLE 46
  • Poulan PRGT2046A | User Manual - Page 47
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT2046A TRANSAXLE KEY PART NO. NO. 1 65 4204R Reverse Gear 66 2898J Key, Hi-Pro 1/8 x 17/32 67 12000033 Klip Ring 68 4205R 86 633A85 Gearshift Ball Cover and Pin 87 8739H1 Shift Lever Guide Ball, Keyed 88 4924H Spring 89 19151516 Washer 15/32
  • Poulan PRGT2046A | User Manual - Page 48
    48
  • Poulan PRGT2046A | User Manual - Page 49
    49
  • Poulan PRGT2046A | User Manual - Page 50
    , without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PRGT2046A | User Manual - Page 51
    FOR SIGHTING SLOPES FOR SAFE OPERATION SIGHTING GUIDE CUT THIS IOSUAT1O5NSDLOOTPTEED LINES ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. 15 MAX. 51 Operate your Tractor up and down the face of slopes (not greater than 15 ), never across the
  • Poulan PRGT2046A | User Manual - Page 52
    pages of your phone directory for the name of the nearest service dealer (under “saws” for Chain Saws or under “lawn mowers” for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
OWNER'S MANUAL
MODEL:
PRGT2046A
LAWN TRACTOR
Always Wear Eye Protection During Operation
WARNING:
Read this Owner's Manual and
follow all Warnings and Safety
Instructions.
Failure to do so can
result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
177271
Rev. 2
8.24.01
TR
Printed in U.S.A.