Poulan PRGT22H50B User Manual

Poulan PRGT22H50B Manual

Get Poulan PRGT22H50B PDF manuals and user guides View all Poulan PRGT22H50B manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PRGT22H50B manual content summary:

  • Poulan PRGT22H50B | User Manual - Page 1
    IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL: PRGT22H50B LAWN TRACTOR WARNING: Read the Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. Always Wear Eye Protection During Operation 177937 Rev. 4 06.28.01 RH Printed in
  • Poulan PRGT22H50B | User Manual - Page 2
    with the DO NOT: instructions, to operate the machine. SERVICE operate the riding mower safely enough to protect themselves and others from serious injury. • Keep machine free of grass , leaves or other debris buildup which can touch hot exhaust / engine parts and burn. Do not allow the mower
  • Poulan PRGT22H50B | User Manual - Page 3
    SAFETY RULES Safe Operation Practices for Ride-On Mowers • Be sure the area is clear of is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
  • Poulan PRGT22H50B | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PRGT22H50B | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Gauge Wheel (12) Crownlock Nuts 5/16-18 3/8 x 3/4 x 14 Ga. (4) Clevis Pins (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Mower (2) Front Link Assemblies (4) Locknut 3/8-16 (4) Shoulder Bolt Nose Roller Nose Roller Nose Roller Brackets (2) Hex Bolts 5/
  • Poulan PRGT22H50B | User Manual - Page 6
    top to bottom, along lines on all four corners of carton, and lay panels flat. • Remove mower and packing materials. • Check for any additional loose parts or cartons and remove. BEFORE REMOVING TRACTOR FROM SKID ATTACH STEERING WHEEL (See Fig. 1) • Remove hex bolt, lock washer and large flat washer
  • Poulan PRGT22H50B | User Manual - Page 7
    rear gauge wheel brackets marked rear left (R L), rear right (RR) to mower deck using (3) carriage bolts and (3) locknuts. For ease of installation do all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is
  • Poulan PRGT22H50B | User Manual - Page 8
    knob clockwise to remove slack Be sure tractor is on level surface and mower suspension from mower suspension. arms are raised with attachment lift of mower deck. • Raise deck to highest position. • Adjust gauge wheels before operating mower as shown in the Operation section of this manual.
  • Poulan PRGT22H50B | User Manual - Page 9
    See the figures that are shown for replacing motion, mower drive, and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. 3CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST
  • Poulan PRGT22H50B | User Manual - Page 10
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PRGT22H50B | User Manual - Page 11
    . FREEWHEEL CONTROL - Disengages transmission for LIFT LEVER - Used to raise and lower mower deck or other pushing or slowly towing the tractor with the engine off. attachments mounted to your tractor. IGNITION SWITCH - Used to start and stop the engine. BRAKE PEDAL - Used for braking the
  • Poulan PRGT22H50B | User Manual - Page 12
    motion control lever. FIG. 8 MOWER BLADES • To stop mower blades,move attachment clutch switch to and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches during
  • Poulan PRGT22H50B | User Manual - Page 13
    prevent scalping in most terrain conditions. NOTE: Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan PRGT22H50B | User Manual - Page 14
    while in storage. To avoid engine problems, the fuel system should be emptied before fresh fuel next season. See Storage Instructions for additional information. Never use engine or as follows: • Be sure the tractor is on level ground. • Place the Service and Adjustments section of this manual. 14
  • Poulan PRGT22H50B | User Manual - Page 15
    TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
  • Poulan PRGT22H50B | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PRGT22H50B | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PRGT22H50B | User Manual - Page 18
    manual). TO CHANGE ENGINE OIL (See Figs. 15 and 16) Determine temperature range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor often under extremely dusty, dirty conditions), remove the blower housing and other cooling shrouds. Clean the cooling
  • Poulan PRGT22H50B | User Manual - Page 19
    oil. • If very dirty or damaged, replace pre-cleaner. TO SERVICE CARTRIDGE • Clean cartridge by tapping gently on flat surface. If very SPECIFICATIONS" section of this manual. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than
  • Poulan PRGT22H50B | User Manual - Page 20
    : IF AN ATTACHMENT OTHER THAN THE MOWER DECK IS TO BE MOUNTED ON THE TRACTOR, REMOVE THE FRONT LINKS. TO INSTALL MOWER Follow procedure described in "INSTALL MOWER AND DRIVE BELT" in the Assembly section of this manual. UCT SPECIFICATIONS" section of this manual). If tires are over or underinflated
  • Poulan PRGT22H50B | User Manual - Page 21
    DRIVE BELT (See Fig. 24) Park the tractor on level surface. Engage parking brake. • Remove mower drive belt (See "TO REPLACE MOWER DRIVE BELT" in this section of this manual). • Remove mower (See "TO REMOVE MOWER" in this section of this manual). • • • • 21 Remove screws from R.H. mandrel cover
  • Poulan PRGT22H50B | User Manual - Page 22
    MOTION DRIVE BELT (See Fig. 26) Park the tractor on level surface. Engage parking brake. For ease of service there is a belt installation guide decal on bottom of left footrest. • Remove mower (See "TO REMOVE MOWER" in this section of this manual.) BELT REMOVAL • Create slack in belt by removing
  • Poulan PRGT22H50B | User Manual - Page 23
    service or replacement, it should be purged after reinstallation and before operating the tractor. See "PURGE TRANSMISSION" in the Operation section of this manual , remove steering wheel and reassemble per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN ADJUSTMENT Front wheel
  • Poulan PRGT22H50B | User Manual - Page 24
    SERVICE AND due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. TO REMOVE of this manual). If "jumper cables" are used for emergency starting, follow • this procedure: • IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH
  • Poulan PRGT22H50B | User Manual - Page 25
    SERVICE AND cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO FOR MAXIMUM SPRING TENSION WHEN USING LIGHT ATTACHMENTS SUCH AS A MOWER. ADJUST LIFT LEVER SPRING TO AID IN LIFTING ATTACHMENT. DO
  • Poulan PRGT22H50B | User Manual - Page 26
    . TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. High speed stop is factory adjusted. Do not adjust - damage may result. IMPORTANT
  • Poulan PRGT22H50B | User Manual - Page 27
    TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PRGT22H50B | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PRGT22H50B | User Manual - Page 29
    TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Engine continues to run 1. when operator leaves seat with attachment clutch engaged Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PRGT22H50B | User Manual - Page 30
    SERVICE NOTES 30
  • Poulan PRGT22H50B | User Manual - Page 31
    SCHEMATIC TRACTOR - - MODEL NUMBER PRGT22H50B RED BLACK BATTERY SOLENOID A AMMETER (OPTIONAL) RED A1 NONE L + A2 NONE NONE WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 87 86 87A 85 30 RELAY
  • Poulan PRGT22H50B | User Manual - Page 32
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B ELECTRICAL 22 21 79 41 24 43 42 27 25 40 81 27 33 30 11 12 2 1 8 10 27 D.C. AMPERES 45 26 12 29 52 50 16 28 32
  • Poulan PRGT22H50B | User Manual - Page 33
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B ELECTRICAL KEY PART NO. NO. 1 144926 2 74760412 8 7603J 10 145211 11 150109 12 145769 16 153664 21 166184 22 4152J 24 4206J 25 146149 26 108824X 27 73510400
  • Poulan PRGT22H50B | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B CHASSIS AND ENCLOSURES 14 153 130 138 47 141 5 148 140 37 130 17 58 28 21 17 17 68 35 17 90 7 144 7 130
  • Poulan PRGT22H50B | User Manual - Page 35
    PARTS TRACTOR - - MODEL NUMBER PRGT22H50B CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 175465 Rail, Frame RH 2 175282 Drawbar, Gt 4 73680700 Nut, Crownlock 7/16-14Unc 5 163976X428 Dash 6 157882 Dash Asm., Lower 7 17720408 Screw, Thd Cut 1/4-20 x 1/2 8 145166 Support Mower 86
  • Poulan PRGT22H50B | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B GROUND DRIVE 42 39 40 70 41 89 6 132 38 37 46 68 36 77 74 35 71 65 64 37 56 38 117 127
  • Poulan PRGT22H50B | User Manual - Page 37
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B GROUND DRIVE KEY PART NO. NO. DESCRIPTION 1 Transaxle Hydro Gear 331-3000 (Order Parts From Transaxle Manufacturer) 2 9396E Key Sq. 1/4 x 1/4 x 2 6 76020412 Pin, Cotter 7 140507 Wheel, Hub Assembly 9 140080 Bolt, Hub 20 73940800 Nut
  • Poulan PRGT22H50B | User Manual - Page 38
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B STEERING ASSEMBLY 26 9 8 25 7 3 14 45 2 1 6 6 4 34 33 32 6 27 44 21 20 23 22 31 41 12 15 14 14 15 14 14 8 6 29
  • Poulan PRGT22H50B | User Manual - Page 39
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B STEERING ASSEMBLY KEY PART NO. 137155 Draglink, Ball Joint Solid Vgt 19 156011 Support Asm., Steering Vgt 20 163887X428 Boot Steering Ball RH Service 39 73700600 Nut Hex Jam 3/8-24 Unf LH 40 109851X Joint Asm. Ball LH Service 41 155246
  • Poulan PRGT22H50B | User Manual - Page 40
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B ENGINE 22 25 21 1 20 18 15 17 10 37 16 26 28 37 27 31 39 83 69 62 45 84 74 24 84 82 71 70 35 79 12 11 81 2 41 42 43 47 9 29 8 SPARK ARRESTER KIT 40 40
  • Poulan PRGT22H50B | User Manual - Page 41
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B ENGINE KEY PART NO. NO. DESCRIPTION 1 Engine Briggs, Model No. 407777 (Order parts from engine manuf.) 2 149723 Muffler Side 8 121361X Pulley V-Idler 9 177748 Keeper Asm. Belt Engine VGT 10 175287 Bushing 11 170056 Clutch Electric 12
  • Poulan PRGT22H50B | User Manual - Page 42
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B SEAT ASSEMBLY 1 20 14 20 8 10 8 7 7 16 5 15 4 18 6 13 19 17 12 2 5 22 21 3 KEY PART NO. NO. 1 173818 2 140551 3 140675 4 127018X 5 145006 6 73800600 7 124181X 8 171877 10 174894 12 121246X 13 121248X 14 72050412 DESCRIPTION Seat
  • Poulan PRGT22H50B | User Manual - Page 43
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B LIFT ASSEMBLY 40 42 43 38 35 73 34 31 32 30 7 8 9 10 39 70 1 4 5 54 3 29 72 33 11 13 23 14 41 23 KEY PART NO. NO. 1 121006X 2 159187 3 159189 4 12000022 5 19292016 6 71110624 7 125631X 8 170770 9 122364X 10 2876H 11 146704 12 163552 13
  • Poulan PRGT22H50B | User Manual - Page 44
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B MOWER DECK 55 45 45 48 53 52 44 46 43 38 45 27 48 50 44 56 39 48 45 49 63 62 51 45
  • Poulan PRGT22H50B | User Manual - Page 45
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B MOWER DECK KEY PART NO. NO. DESCRIPTION 1 156990X421 Deck Weldment 50" Torison Delector 21 137607 Bracket, Deflector 22 110452X Nut, Push 23 110509X428 Shield, Deflector Mower 26 72110606 Bolt RdHd Sht Sqnk 27 19131316 Washer 13/32 x 13/16 x
  • Poulan PRGT22H50B | User Manual - Page 46
    REPAIR PARTS TRACTOR - - MODEL NUMBER PRGT22H50B DECALS 9 3 15 4 10 29 29 2 11 14 KEY NO. 1 2 3 4 6 9 10 11 14 15 PART NO. 164095 170852 176272 176273 170563 172740 157140 101892X 160397 172743 DESCRIPTION Decal, Dash Decal, Engine Decal, Hood, RH Decal, Hood, LH Decal, Warning Decal
  • Poulan PRGT22H50B | User Manual - Page 47
    SERVICE NOTES 47
  • Poulan PRGT22H50B | User Manual - Page 48
    SERVICE NOTES 48
  • Poulan PRGT22H50B | User Manual - Page 49
    SERVICE NOTES 49
  • Poulan PRGT22H50B | User Manual - Page 50
    , without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products return the product to an authorized service dealer. Should you have any unanswered
  • Poulan PRGT22H50B | User Manual - Page 51
    FOR SIGHTING SLOPES FOR SAFE OPERATION SIGHTING GUIDE CUT THIS IOSUAT1O5NSDLOOTPTEED LINES ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. 15 MAX. 51 Operate your Tractor up and down the face of slopes (not greater than 15 ), never across the
  • Poulan PRGT22H50B | User Manual - Page 52
    pages of your phone directory for the name of the nearest service dealer (under “saws” for Chain Saws or under “lawn mowers” for Trimmers, Brushcutters, and Blowers). 3. For replacement parts, have available the following information: a. Model Number/Manufacturer's I.D. Number b. Description of
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
177937
Rev. 4
06.28.01
RH
Printed in U.S.A.
OWNER'S MANUAL
MODEL:
PRGT22H50B
LAWN TRACTOR
Always Wear Eye Protection During Operation
WARNING:
Read the Owner's Manual and follow
all Warnings and Safety Instructions.
Failure to do so can result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away