Home » Poulan Manuals » Lawn & Garden » Poulan PXT12530 » Manual Viewer

Poulan PXT12530 User Manual

Poulan PXT12530 Manual

Get Poulan PXT12530 PDF manuals and user guides

View all Poulan PXT12530 manuals

Add to My Manuals
Save this manual to your list of manuals

Poulan PXT12530 manual content summary:

Poulan PXT12530 | User Manual - Page 1
DO NOT THROW AWAY OPERATOR'S MANUAL MODEL: PXT12530 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 431832 11.03.09 CL
Poulan PXT12530 | User Manual - Page 2
the tires lose traction, disengage the blades and proceed slowly straight down the slope. • Keep all movement on the slopes slow and gradual. Do not make sudden changes in speed or direction, which could cause the machine to roll over. • Use extra care while operating machine with grass catchers or
Poulan PXT12530 | User Manual - Page 3
Check grass catcher components and the discharge chute frequently and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required
Poulan PXT12530 | User Manual - Page 4
. Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
Poulan PXT12530 | User Manual - Page 5
UNASSEMBLED PARTS 3TEERINGª7HEEL 3TEERINGª 7HEELª)NSERT 3TEERINGª7HEEL !DAPTER 3TEERING 7HEEL ª,ARGEª &LATª7ASHER ª,OCKª 7ASHERª ª(EXª"OLTªª 3TEERINGª"OOT 3TEERING %XTENSION 3HAFT 3EAT ª7ASHERªª ª3EAT +
Poulan PXT12530 | User Manual - Page 6
hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). BOLT LOCK WASHER LARGE FLAT WASHER • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. STEERING BOOT STEERING WHEEL LABEL
Poulan PXT12530 | User Manual - Page 7
See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
Poulan PXT12530 | User Manual - Page 8
FUEL BATTERY REVERSE FORWARD CRUISE CONTROL CLUTCH/BRAKE PEDAL 15 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions could
Poulan PXT12530 | User Manual - Page 9
the brake position. (D) THROTTLE/CHOKE CONTROL - Used for starting and controlling engine speed. (E) ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. (F) IGNITION SWITCH - Used for starting and stopping the engine. (G) REVERSE OPERATION SYSTEM
Poulan PXT12530 | User Manual - Page 10
position. Make sure parking brake will hold tractor secure. C B Fig. 5 STOPPING (See Fig. 6) MOWER BLADES • To stop mower blades, place attachment clutch control in the "DISENGAGED" position ( ). ENGINE - • Move throttle control (D) between half and full speed (fast) position. NOTE: Failure to move
Poulan PXT12530 | User Manual - Page 11
and speed of movement is controlled by the gearshift lever (J). J Fig. 8 1. Start tractor with and better looking lawns, mow often and after moderate growth. • For best cutting performance, grass over 6" in ADJUST MOWER CUTTING HEIGHT") • Start mower blades by engaging attachment clutch control. 11
Poulan PXT12530 | User Manual - Page 12
without either the entire grass catcher, on mowers so equipped, or the deflector shield (S) in place (See Fig. 10). S Fig. 11 TO OPERATE ON HILLS CAUTION: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope. • Choose the slowest speed before starting up or
Poulan PXT12530 | User Manual - Page 13
CARBURETOR" in the Service and Adjustments section of this manual. MOWING TIPS • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive
Poulan PXT12530 | User Manual - Page 14
properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for wear
Poulan PXT12530 | User Manual - Page 15
. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual). TIRES • Maintain proper air
Poulan PXT12530 | User Manual - Page 16
belts are not adjustable. Replace belts All oil must meet API service classification C. • Be sure tractor is on level surface. • . • Position a container to catch oil directly under front end of oil drain extension. • Slide a 1/2" "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil
Poulan PXT12530 | User Manual - Page 17
. 18 00667 CLEANING • Clean engine, battery, seat, finish, etc. of all foreign matter. • Clean debris from steering plate. Debris can restrict clutch/brake pedal shaft movement, causing belt slip and loss of drive. CAUTION: Avoid all pinch points and movable parts (See Fig. 19) CLUTCH/BRAKE PEDAL
Poulan PXT12530 | User Manual - Page 18
: IF AN ATTACHMENT OTHER THAN THE MOWER IS TO BE MOUNTED ON THE TRACTOR, REMOVE THE FRONT LINK (E) AND REAR LIFT LINKS (C) FROM TRACTOR AND HOOK THE CLUTCH SPRING (Q) INTO THE CABLE GUIDE ON FRONT EDGE OF LOWER DASH. TO INSTALL MOWER (See Fig. 20-25) Be sure tractor is on level surface and engage
Poulan PXT12530 | User Manual - Page 19
SERVICE AND ADJUSTMENTS • ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring. • Repeat on opposite side of tractor. A • Insert end of link (E) into hole in front mower bracket and secure with washer and
Poulan PXT12530 | User Manual - Page 20
step in Visual Adjustment instructions above. • Recheck measurements, adjust if necessary until both sides are equal. FRONT-TO-BACK ADJUSTMENT (See Figs. 28 & 29) IMPORTANT: Deck must be level side-to-side. To obtain the best cutting results, the mower blades should be adjusted so the front tip is
Poulan PXT12530 | User Manual - Page 21
SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 30) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off
Poulan PXT12530 | User Manual - Page 22
forward, remove steering wheel and reassemble per instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER Your new tractor front wheel toe-in and camber is set at the factory and is normal. The front wheel toe-in and camber are not adjustable. If damage has occurred to affect
Poulan PXT12530 | User Manual - Page 23
at the factory and adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and
Poulan PXT12530 | User Manual - Page 24
. Store in a clean, dry area. • Clean entire tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Maintenance section of
Poulan PXT12530 | User Manual - Page 25
. 9. Contact an authorized service center/department. 1. Recharge or replace battery. 2. Clean battery terminals. 3. Check all wiring. 4. Check/replace solenoid or starter. 1. Raise cutting height/reduce speed. 2. Adjust throttle control. 3. Clean underside of mower housing. 4. Clean/replace air
Poulan PXT12530 | User Manual - Page 26
of grass, leaves and trash under mower. 7. Clean underside of mower housing. 8. Mower drive belt worn. 8. Replace mower drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower
Poulan PXT12530 | User Manual - Page 27
27 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
Poulan PXT12530 | User Manual - Page 28
ownership. After ninety (90) days, we will exchange the Battery, charging you 1/12 of the price of a new Battery for each full month from the date of the original sale. Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used for rental