Poulan PXT195G42 User Manual

Poulan PXT195G42 Manual

Get Poulan PXT195G42 PDF manuals and user guides View all Poulan PXT195G42 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PXT195G42 manual content summary:

  • Poulan PXT195G42 | User Manual - Page 1
    DO NOT THROW AWAY 03131 OPERATOR'S MANUAL MODEL: PXT195G42 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 532 43 91-59
  • Poulan PXT195G42 | User Manual - Page 2
    , and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under the machine exhaust / engine parts and burn. Do not allow the mower deck to plow leaves or other debris which can cause build-up to occur. Clean any oil or fuel
  • Poulan PXT195G42 | User Manual - Page 3
    remove gas cap or add fuel with the engine running. Allow engine parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction
  • Poulan PXT195G42 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PXT195G42 | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert Steering Wheel Adapter Steering Wheel (1) Large Flat Washer (1) Lock Washer (1) Hex Bolt Steering Boot Steering Extension Shaft Seat (1) Washer (1) Seat (1) Knob Slope Sheet Key(s) 5
  • Poulan PXT195G42 | User Manual - Page 6
    one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. TO INSTALL STEERING WHEEL (See Fig. 2) ASSEMBLE EXTENSION SHAFT AND
  • Poulan PXT195G42 | User Manual - Page 7
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
  • Poulan PXT195G42 | User Manual - Page 8
    OIL PRESSURE BATTERY REVERSE FORWARD MOWER HEIGHT 15 MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions
  • Poulan PXT195G42 | User Manual - Page 9
    Save this manual for future reference. H D E B G F A C J Fig. 4 Our tractors conform to mower blades, or other attachments mounted to your tractor. (F) IGNITION SWITCH - Used for starting and stopping the engine. (G) REVERSE OPERATION SYSTEM (ROS) "ON" POSITION - Allows operation of mower
  • Poulan PXT195G42 | User Manual - Page 10
    : LEAVING THE IGNITION SWITCH IN ANY POSITION OTHER THAN "OFF" WILL CAUSE THE BATTERY TO BE DISCHARGED (DEAD). NOTE: Under certain conditions when tractor is standing idle with the engine running, hot engine exhaust gases may cause "browning" of grass. To eliminate this possibility, always stop
  • Poulan PXT195G42 | User Manual - Page 11
    When use of the ROS is no longer needed, turn the ignition key clockwise to engine "ON" position. ROS "ON" POSITION 02828 ENGINE "ON" POSITION (NORMAL OPERATING) TO OPERATE ON HILLS TO OPERATE MOWER Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to
  • Poulan PXT195G42 | User Manual - Page 12
    engine problems, the fuel system should be emptied before storage of 30 days or longer. Drain the gas tank, start the engine and let it run until the fuel lines and carburetor are empty. Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or carburetor
  • Poulan PXT195G42 | User Manual - Page 13
    cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are
  • Poulan PXT195G42 | User Manual - Page 14
    described in the Service and Adjustments section of this manual. ➁ SPINDLE ZERK ➁ FRONT WHEEL BEARING ZERK ➁ SPINDLE ZERK ➁ FRONT WHEEL BEARING ZERK ➂ ENGINE • At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for wear. A new
  • Poulan PXT195G42 | User Manual - Page 15
    the operator to shift into reverse should NOT shut off the engine. BLADE CARE For best results mower blades must be kept sharp. Replace bent or damaged blades. CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your
  • Poulan PXT195G42 | User Manual - Page 16
    cap is tightened securely for accurate reading. Keep oil at "FULL" line on dipstick. Tighten cap onto the tube securely when finished. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. See engine manual
  • Poulan PXT195G42 | User Manual - Page 17
    , causing belt slip and loss of drive. CAUTION: Avoid all pinch points and movable parts (See Fig. 17) CLUTCH/BRAKE PEDAL CLEAN TOP SIDE STEERING PLATE CAUTION: PINCH POINTS STEERING SYSTEM, DASH, FENDER AND MOWER NOT SHOWN Fig. 17 • Keep finished surfaces and wheels free of all gasoline, oil, etc
  • Poulan PXT195G42 | User Manual - Page 18
    its lowest position. • Roll belt off engine pulley (M) and belt keepers (G). • Remove retainer spring (K), slide collar (L) off and push housing guide (P) out of bracket. • Remove clutch cable spring (Q) from idler arm (R). • Disconnect front link (E) from mower - remove retainer spring and washer
  • Poulan PXT195G42 | User Manual - Page 19
    front hole in tractor front suspension bracket (F). R Q Fig. 22 IMPORTANT: CHECK BELT FOR PROPER ROUTING IN ALL MOWER PULLEY GROOVES. • Raise attachment lift lever to highest position. • If necessary, adjust gauge wheels before operating mower as shown in the Operation section of this manual
  • Poulan PXT195G42 | User Manual - Page 20
    , see step in Visual Adjustment instructions above. • Recheck measurements, adjust if necessary until both sides are equal. FRONT-TO-BACK ADJUSTMENT (See Figs. 26 & 27) IMPORTANT: Deck must be level side-to-side. To obtain the best cutting results, the mower blades should be adjusted so the front
  • Poulan PXT195G42 | User Manual - Page 21
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 28) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off both
  • Poulan PXT195G42 | User Manual - Page 22
    Your new tractor front wheel toe-in and camber is set at the factory and is normal. The front wheel toe-in and camber are not adjustable. If damage has occurred to affect the factory set front wheel toe-in or camber, contact a qualified service center. TO START ENGINE WITH A WEAK BATTERY (See Fig
  • Poulan PXT195G42 | User Manual - Page 23
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 23
  • Poulan PXT195G42 | User Manual - Page 24
    contact with battery terminals. • If battery is removed from tractor for storage, do not store battery directly on concrete or damp surfaces. ENGINE FUEL SYSTEM IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE
  • Poulan PXT195G42 | User Manual - Page 25
    service center/department. 1. Recharge or replace battery. 2. Clean battery terminals. 3. Check all wiring. 4. Check/replace solenoid or starter. 1. Raise cutting height/reduce speed. 2. Adjust throttle control. 3. Clean underside of mower housing. 4. Clean/replace air filter. 5. Check oil
  • Poulan PXT195G42 | User Manual - Page 26
    and trash under mower. 7. Clean underside of mower housing. 8. Mower drive belt worn. 8. Replace mower drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes
  • Poulan PXT195G42 | User Manual - Page 27
    FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees. Make
  • Poulan PXT195G42 | User Manual - Page 28
    with the instructions furnished. This Warranty does not apply to any product which has been subjected to alteration, misuse, abuse, improper assembly or installation, delivery damage, or to normal wear of the product. 6. Exclusions: Excluded from this Warranty are belts, blades, blade adapters
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
OPERATOR'S MANUAL
MODEL:
PXT195G42
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions.
Failure to do so can
result in serious
injury.
IMPORTANT MANUAL
DO NOT THROW AWAY
532 43 91-59
03131