Poulan XT18542LT User Manual

Poulan XT18542LT Manual

Get Poulan XT18542LT PDF manuals and user guides View all Poulan XT18542LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan XT18542LT manual content summary:

  • Poulan XT18542LT | User Manual - Page 1
    Do Not Throw Away OPERATOR'S MANUAL MODEL: XT18542LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com 433507 01.05.10 SR Printed
  • Poulan XT18542LT | User Manual - Page 2
    and cause you to lose control of your tractor. WARNING Engine exhaust, some of its instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts riding mowerrelated injuries. These operators should evaluate their ability to operate the riding mower
  • Poulan XT18542LT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan XT18542LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan XT18542LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert (1) Large Flat Washer (1) Hex Bolt 5/16-18 x 4 (1) 5/16 Lock Washer Steering Wheel Adapter Steering Boot Seat (1) Seat Steering Extension Shaft (1) Washer (1) Knob Keys Slope Sheet (2) Keys 5
  • Poulan XT18542LT | User Manual - Page 6
    INSERT When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton . • Cut along dotted lines on all four
  • Poulan XT18542LT | User Manual - Page 7
    see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. SEAT LABEL 02602 FIG. 3 NOTE: You may now roll your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. TO ROLL TRACTOR OFF SKID (See Operation section for
  • Poulan XT18542LT | User Manual - Page 8
    TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts inflated for leveling). ✓ Check mower and drive belts. Be sure manual). 8
  • Poulan XT18542LT | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED BRAKE/CLUTCH PEDAL KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) LIGHTS ON FREE WHEEL (Automatic Models only) DANGER, KEEP HANDS AND FEET AWAY Failure to follow instructions in damage to the tractor and/or engine.
  • Poulan XT18542LT | User Manual - Page 10
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise, lower, and adjust the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking
  • Poulan XT18542LT | User Manual - Page 11
    position and remove key. Always remove key when leaving tractor to prevent unauthorized use. TO ADJUST MOWER CUTTING HEIGHT (See Fig. 5) The position of the and to over 3" during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance,
  • Poulan XT18542LT | User Manual - Page 12
    needed, turn the ignition key clockwise to engine "ON" position. ROS "ON" POSITION ENGINE "ON" POSITION (NORMAL OPERATING) 02828 TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running
  • Poulan XT18542LT | User Manual - Page 13
    • Check engine oil with tractor on level ground. • Remove engine while in storage. To avoid engine problems, the fuel system should be emptied before Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or Service and Adjustments section of this manual. 13
  • Poulan XT18542LT | User Manual - Page 14
    should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are discharged onto the area that has been cut. Have the cut area to the
  • Poulan XT18542LT | User Manual - Page 15
    as instructed in this manual. dSPINDLE ZERK dSPINDLE ZERK Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. dFRONT
  • Poulan XT18542LT | User Manual - Page 16
    local parts dealer. Tire problem immediately. CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor and void your warranty. BLADE REMOVAL (See Fig. 9) • Raise mower
  • Poulan XT18542LT | User Manual - Page 17
    oil change. All oil must meet API service classification C. • Be sure tractor is on level surface. • Oil will capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick the engine's air cooling system. Remove blower housing and clean the area shown to prevent
  • Poulan XT18542LT | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan XT18542LT | User Manual - Page 19
    BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 14) Mower clutch cable housing guide into bracket, slide collar onto guide and secure
  • Poulan XT18542LT | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE
  • Poulan XT18542LT | User Manual - Page 21
    qualified service center. TO REPLACE MOTION DRIVE BELT (See Fig. 20) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE
  • Poulan XT18542LT | User Manual - Page 22
    bolt, move mower deck height to instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER TO ATTACH JUMPER CABLES • Connect one end of the RED cable to the POSITIVE (+) terminal of each battery(A-B), taking care not to short against tractor parts dealer. Tire sealant also
  • Poulan XT18542LT | User Manual - Page 23
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 23
  • Poulan XT18542LT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan XT18542LT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE in "CHOKE" position. 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/dirty oil. 6. Faulty To Adjust Carburetor" in Service Adjustments section. 10. Contact an authorized service center/department. 1. Clean
  • Poulan XT18542LT | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM Excessive vibration CAUSE 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part(s). CORRECTION 1. Replace blade. Tighten blade bolt. 2. Replace blade mandrel. 3. Tighten loose part(s). Replace damaged parts parts manual. 11. Clogged mower Service
  • Poulan XT18542LT | User Manual - Page 27
    charge for parts or labor incurred in replacing parts, any part which be maintained in accordance with the instructions furnished. 4. The Warranty period for service dealer. Should you have any unanswered questions concerning this Warranty, please contact: HOP Outdoor Products Customer Service
  • Poulan XT18542LT | User Manual - Page 28
    SERVICE NOTES 28
  • Poulan XT18542LT | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan XT18542LT | User Manual - Page 30
    : call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan.com/support.asp NOTE: HOP provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local dealer(s). The philosophy of HOP is to
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
XT18542LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions.
Failure to do so can
result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
433507
01.05.10 SR
Printed in U.S.A.