Poulan XT22H42YT User Manual

Poulan XT22H42YT Manual

Get Poulan XT22H42YT PDF manuals and user guides View all Poulan XT22H42YT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan XT22H42YT manual content summary:

  • Poulan XT22H42YT | User Manual - Page 1
    Do Not Throw Away 03076 OPERATOR'S MANUAL MODEL: XT22H42YT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 404378 Rev.2 03.16
  • Poulan XT22H42YT | User Manual - Page 2
    Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS your tractor. manual before starting. • Choose a low ground speed so that you will not have • Do not put hands or feet near rotating parts
  • Poulan XT22H42YT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan XT22H42YT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized servicecenter/ department We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan XT22H42YT | User Manual - Page 5
    loose parts and parts service after month and year indicated on label (L) (label is located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). FIG. 2 NOTE: You may now roll or drive your tractor
  • Poulan XT22H42YT | User Manual - Page 6
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
  • Poulan XT22H42YT | User Manual - Page 7
    tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER Failure to follow instructions could result
  • Poulan XT22H42YT | User Manual - Page 8
    the speed and direction of tractor. (M) FREEWHEEL CONTROL - Disengages transmission for pushing or slowly towing the tractor with the engine off. (N) CHOKE CONTROL - Used when starting a cold engine. (P) SERVICE REMINDER / HOUR METER - Indicates when service is required for the engine and mower. 8
  • Poulan XT22H42YT | User Manual - Page 9
    wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend tractor on grass areas. CAUTION: Always stop tractor completely, as described above, before leaving the operator's position. B C D STOPPING FIG. 4 MOWER BLADES • To stop mower
  • Poulan XT22H42YT | User Manual - Page 10
    tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in this section of manual). • With mower , height of grass and types of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches during the cool season and to
  • Poulan XT22H42YT | User Manual - Page 11
    mower needs servicing. When service is required, the service reminder will flash for two hours. To service engine and mower, see the Maintenance section of this manual. NOTE: Service by and comply with specifications of the manufacturer of your tractor. Use common sense when towing. Too heavy of a load
  • Poulan XT22H42YT | User Manual - Page 12
    while in storage. To avoid engine problems, the fuel system should be emptied fuel next season. See Storage Instructions for additional information. Never use engine in the Service and Adjustments section of this manual. PURGE TRANSMISSION this section of manual). • Sitting in the tractor seat, start
  • Poulan XT22H42YT | User Manual - Page 13
    (See "TO TRANSPORT" in this section of manual). • Sitting in the tractor seat, start engine. After the engine is running Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan XT22H42YT | User Manual - Page 14
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan XT22H42YT | User Manual - Page 15
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be serviced. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual from your local parts dealer. Tire sealant results mower blades must be
  • Poulan XT22H42YT | User Manual - Page 16
    range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely not overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan XT22H42YT | User Manual - Page 17
    " section of this manual. IN-LINE FUEL FILTER tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan XT22H42YT | User Manual - Page 18
    WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Depress clutch/brake pedal fully and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig
  • Poulan XT22H42YT | User Manual - Page 19
    SERVICE AND ADJUSTMENTS • Slide mower out from under right side of tractor. IMPORTANT: If an attachment other than the mower deck is to be mounted on the tractor, remove the front link (E) and rear lift liks (C) from tractor. TO INSTALL MOWER (See Figs. 18-21) Be sure tractor is on level surface
  • Poulan XT22H42YT | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower than the rear tip, go to the front of tractor. • With an 11/16" or adjustable wrench,
  • Poulan XT22H42YT | User Manual - Page 21
    clutching idler (B). • Make sure belt is in all pulley grooves and inside all belt guides and keepers. • Install mower (See "TO INSTALL MOWER" in this section of manual). R R FIG. 26 TO CHECK BRAKE If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level
  • Poulan XT22H42YT | User Manual - Page 22
    to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. WASHERS MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A
  • Poulan XT22H42YT | User Manual - Page 23
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 23
  • Poulan XT22H42YT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan XT22H42YT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan XT22H42YT | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual shipment or servicing. 1.
  • Poulan XT22H42YT | User Manual - Page 27
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan XT22H42YT | User Manual - Page 28
    28 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan XT22H42YT | User Manual - Page 29
    NOTES 29
  • Poulan XT22H42YT | User Manual - Page 30
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
XT22H42YT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
404378
Rev.2
03.16.06
VB
Printed in U.S.A.
03076