Poulan XT24H42LT User Manual

Poulan XT24H42LT Manual

Get Poulan XT24H42LT PDF manuals and user guides View all Poulan XT24H42LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan XT24H42LT manual content summary:

  • Poulan XT24H42LT | User Manual - Page 1
    Do Not Throw Away 02478 OPERATOR'S MANUAL MODEL: XT24H42LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 197498 02.07.05 TR
  • Poulan XT24H42LT | User Manual - Page 2
    cause you to lose control of your tractor. WARNING • Do not operate machine without riding mower-related injuries. These operators should evaluate their ability to operate the riding mower instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan XT24H42LT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan XT24H42LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan XT24H42LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Gauge Wheels (4) Adjusting Bar Steering Wheel Adapter Steering Wheel Insert (4) Clevis Pins (4) Wheels (4) Retainer Springs (double loop) Steering Boot (4) Washers 3/8 x 3/4 x 14 Ga. (1) Large
  • Poulan XT24H42LT | User Manual - Page 6
    in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON panels flat. • Check for any additional loose parts or cartons and remove. BEFORE REMOVING TRACTOR FROM SKID ADAPTER LOWER STEERING SHAFT TABS EXTENSION SHAFT
  • Poulan XT24H42LT | User Manual - Page 7
    is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). LABEL 02173 NOTE: You may now roll or drive your tractor off the skid
  • Poulan XT24H42LT | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan XT24H42LT | User Manual - Page 9
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan XT24H42LT | User Manual - Page 10
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual tractor with the engine off. HEIGHT ADJUSTMENT KNOB - Used to adjust the mower
  • Poulan XT24H42LT | User Manual - Page 11
    , height of grass and types of grass being mowed. • The average lawn should be cut to approximately 2-1/2 inches during the cool season and to key when leaving tractor to prevent Gauge wheels are properly adjusted when they are slightly unauthorized use. off the ground when mower is at the
  • Poulan XT24H42LT | User Manual - Page 12
    cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis "ON" POSITION ENGINE "ON" POSITION (NORMAL OPERATING) TO OPERATE MOWER (See Fig. 8) Your tractor is equipped with an operator presence sensing switch. Any attempt by
  • Poulan XT24H42LT | User Manual - Page 13
    in storage. To avoid engine problems, the fuel system should be next season. See Storage Instructions for additional information. Never specifications of the manufacturer of your tractor. Use common sense when towing. this manual). • To change engine oil, see the Maintenance section in this manual.
  • Poulan XT24H42LT | User Manual - Page 14
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan XT24H42LT | User Manual - Page 15
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan XT24H42LT | User Manual - Page 16
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual purchased from your local parts dealer. Tire sealant also
  • Poulan XT24H42LT | User Manual - Page 17
    battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts for deterioration and wear range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely when
  • Poulan XT24H42LT | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan XT24H42LT | User Manual - Page 19
    small retainer spring. • Install belt onto engine pulley. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly
  • Poulan XT24H42LT | User Manual - Page 20
    EQUALLY SO MOWER WILL STAY LEVEL SIDE-TO-SIDE. • Remove mower from tractor (See "TO REMOVE MOWER" in this section of this manual). • Work Make sure belt is in all pulley grooves and inside all belt guides. • Install mower in reverse order of removal instruc- tions. MANDREL PULLEY IDLER PULLEYS
  • Poulan XT24H42LT | User Manual - Page 21
    MOTION DRIVE BELT (See Fig. 23) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and
  • Poulan XT24H42LT | User Manual - Page 22
    due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. WASHERS RETAINING instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor
  • Poulan XT24H42LT | User Manual - Page 23
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 23
  • Poulan XT24H42LT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan XT24H42LT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan XT24H42LT | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual shipment or servicing. 1.
  • Poulan XT24H42LT | User Manual - Page 27
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan XT24H42LT | User Manual - Page 28
    SERVICE NOTES 28
  • Poulan XT24H42LT | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan XT24H42LT | User Manual - Page 30
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
XT24H42LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
197498
02.07.05
TR
Printed in U.S.A.
02478