Poulan XT24H48YT User Manual

Poulan XT24H48YT Manual

Get Poulan XT24H48YT PDF manuals and user guides View all Poulan XT24H48YT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan XT24H48YT manual content summary:

  • Poulan XT24H48YT | User Manual - Page 1
    Do Not Throw Away 02153 OPERATOR'S MANUAL MODEL: XT24H48YT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 196712 Rev. 1 02.14
  • Poulan XT24H48YT | User Manual - Page 2
    Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS your tractor. manual before starting. • Choose a low ground speed so that you will not have • Do not put hands or feet near rotating parts
  • Poulan XT24H48YT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan XT24H48YT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan XT24H48YT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Mower (2) Retainer Springs (single loop) (5) Retainer Springs (double loop) Steering Wheel Adapter (1) Large Flat Washer Steering Wheel Insert Steering Sleeve (1) Hex nut 1/2-20 (1)Front Plate Assembly (2)
  • Poulan XT24H48YT | User Manual - Page 6
    lines on all four panels of carton. Remove end panels and lay side panels flat. • Remove mower and packing materials. • Check for any additional loose parts or cartons and remove. BEFORE REMOVING TRACTOR FROM SKID ATTACH STEERING WHEEL (See Fig. 1) • Remove locknut and large flat washer from steering
  • Poulan XT24H48YT | User Manual - Page 7
    put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). LABEL 02173 FIG. 3 NOTE: You may now roll or drive your tractor off the
  • Poulan XT24H48YT | User Manual - Page 8
    WHEELS" in the Operation section of this manual. RETAINER SPRING PIN SHOULDER BOLT ADJUSTING BAR GAUGE WHEEL 3/8 WASHER 3/8-16 CENTER LOCKNUT FIG. 4 INSTALL MOWER AND DRIVE BELT (See Figs. 5 and 6) Be sure tractor is on level surface and mower suspension arms are raised with attachment lift
  • Poulan XT24H48YT | User Manual - Page 9
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan XT24H48YT | User Manual - Page 10
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan XT24H48YT | User Manual - Page 11
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual tractor with the engine off. HEIGHT ADJUSTMENT KNOB - Used to adjust the mower
  • Poulan XT24H48YT | User Manual - Page 12
    and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig during hot months. For healthier and better looking lawns, mow often and after moderate growth. •
  • Poulan XT24H48YT | User Manual - Page 13
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan XT24H48YT | User Manual - Page 14
    this manual). • To change engine oil, see the Maintenance section in this manual. in storage. To avoid engine problems, the fuel system should be next season. See Storage Instructions for additional information. Never specifications of the manufacturer of your tractor. Use common sense when towing. Too
  • Poulan XT24H48YT | User Manual - Page 15
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan XT24H48YT | User Manual - Page 16
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan XT24H48YT | User Manual - Page 17
    Service and Adjustments section of this manual). CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor purchased from your local parts dealer. Tire sealant also
  • Poulan XT24H48YT | User Manual - Page 18
    battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts for deterioration and wear range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely when
  • Poulan XT24H48YT | User Manual - Page 19
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 19
  • Poulan XT24H48YT | User Manual - Page 20
    WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Depress clutch/brake pedal fully and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig
  • Poulan XT24H48YT | User Manual - Page 21
    suspension. • Raise deck to highest position. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your
  • Poulan XT24H48YT | User Manual - Page 22
    SERVICE AND ADJUSTMENTS BOTH FRONT PLATE LINKS MUST BE EQUAL IN LENGTH 02516 NUT "D" 02517 FRONT PLATE ASSEMBLY NUT "C" TRUNNION FIG. 21 TO REPLACE MOWER DRIVE BELT MOWER DRIVE BELT REMOVAL (See Fig. 22) • Park tractor on a level surface. Engage parking brake. • Lower mower arm. MOWER DRIVE BELT
  • Poulan XT24H48YT | User Manual - Page 23
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE (SECONDARY) DRIVE BELT (See Fig. 23) Park the tractor on level surface. Engage parking brake. • Remove mower (See "TO REMOVE MOWER" in this section of manual). • Remove screws from R.H. and L.H. mandrel covers and remove covers. REMOVE MOWER DRIVE BELT
  • Poulan XT24H48YT | User Manual - Page 24
    MOTION DRIVE BELT (See Fig. 25) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and
  • Poulan XT24H48YT | User Manual - Page 25
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. TO START ENGINE
  • Poulan XT24H48YT | User Manual - Page 26
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 26
  • Poulan XT24H48YT | User Manual - Page 27
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan XT24H48YT | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan XT24H48YT | User Manual - Page 29
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual shipment or servicing. 1.
  • Poulan XT24H48YT | User Manual - Page 30
    option, without charge for parts or labor incurred in replacing parts, any part which we find to Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used return the product to an authorized service dealer. Should you have any unanswered
  • Poulan XT24H48YT | User Manual - Page 31
    31 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan XT24H48YT | User Manual - Page 32
    Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
OPERATOR'S MANUAL
MODEL:
XT24H48YT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
196712
Rev. 1
02.14.05
TR
Printed in U.S.A.
02153