Samsung SMH1622W Installation Instructions
Samsung SMH1622W Manual
 |
View all Samsung SMH1622W manuals
Add to My Manuals
Save this manual to your list of manuals |
Samsung SMH1622W manual content summary:
- Samsung SMH1622W | Installation Instructions - Page 1
Installation Instructions Over the Range Microwave Oven BEFORE YOU BEGIN (Read these instructions completely and carefully.) IMPORTANT Save these instructions for local inspector's use. IMPORTANT Observe all governing codes and ordinances. • Note to Installer - Be sure to leave these - Samsung SMH1622W | Installation Instructions - Page 2
information Important safety instructions 3 Electrical requirements 3 Hood exhaust 4 Damage - Shipment/Installation 6 Parts included 6 Tools you will need 7 Mounting space 7 Step-by-step installation guide 1. Placement of the mounting plate 8 A. Removing the microwave oven from the carton - Samsung SMH1622W | Installation Instructions - Page 3
prong wall receptacle, installed by a qualified 3 CAUTION: For personal safety, the mounting electrician. 3 surface must be capable of supporting the cabinet load in the cabinet above the microwave oven. The outlet box and supply circuit should be installed by a qualified electrician and - Samsung SMH1622W | Installation Instructions - Page 4
example of one possible ductwork installation. DUCT PIECES EQUIVALENT LENGTH* x NUMBER USED = EQUIVALENT LENGTH Wall Cap 40 ft. x (1) = 40 ft. 3 ft. Straight Duct (3 ¼˝ x 10˝ Rectangular) 3 ft. x (1) = 3 ft. 90 ° Elbow 10 ft. x (2) = 20 ft. Equivalent lengths of duct pieces - Samsung SMH1622W | Installation Instructions - Page 5
venting be installed using the ft. x ( ) = ft. e 90 ° Elbow 10 ft. x ( ) = ft. 45 ° Elbow 5 ft. x ( ) = ft. 90 ° Elbow 25 ft. x ( ) = ft. 45 ° Elbow 5 ft. x ( ) = ft. Roof Cap 24 ft. x ( ) = ft. Straight Duct 6˝ Round or 3 ¼˝ x 10˝ Rectangular 1 ft. x ( ) = ft - Samsung SMH1622W | Installation Instructions - Page 6
. Check to make sure you have all these parts. NOTE: Some extra parts are included. ADDITIONAL PARTS PART TOP CABINET TEMPLATE Top Cabinet Template REAR WALL TEMPLATE Rear Wall Template QUANTITY 1 1 Installation Instructions 1 Separately Packed Grease Filters 2 Exhaust adaptor 1 Tools - Samsung SMH1622W | Installation Instructions - Page 7
. • This microwave oven is for installation over ranges up to 36˝ wide. • If you are going to vent your microwave oven to the outside, see Hood Exhaust Section for exhaust duct preparation. • When installing the microwave oven beneath smooth flat cabinets be careful to follow the instructions on the - Samsung SMH1622W | Installation Instructions - Page 8
Step-by-step installation guide 1. Placement of the mounting plate C A. Removing the B. Finding the wall studs P microwave oven from the carton/removing the mounting plate 1. Remove the installation instructions, Exhaust adaptor, filters, glass tray and the small hardware bag. Do not - Samsung SMH1622W | Installation Instructions - Page 9
Step-by-step installation guide C. Determining wall plate location under your cabinet Plate may have decorative trim that interferes with the microwave installation. Remove the decorative trim to install the microwave properly and to make it level. THE MICROWAVE MUST BE LEVEL. Use a level to - Samsung SMH1622W | Installation Instructions - Page 10
Step-by-step installation guide D. Aligning the wall plate 2. T fo A Hole A Centerline notches Draw a important to use at least one wood screw mounted firmly in a stud to support the weight of the microwave. Set the mounting plate aside. 10 SMH8165_XAA DE68-03587A-04-EN_120725.indd 10 2012-07- - Samsung SMH1622W | Installation Instructions - Page 11
-step installation guide 2. Ventilation types (choose a, b or c) This microwave oven is microwave is shipped assembled for Outside Top Exhaust (except for non-vented models). And exhaust adaptor is shipped assembled to the filler-upper. Select the type of ventilation required for your installation - Samsung SMH1622W | Installation Instructions - Page 12
to the B for exhaust adaptor and exhaust adaptor after installation completion. proper damper operation House Duct check 1. Exhaust Adaptor and Damper is shipped assembled to the filler-upper. 1. Slide exhaust adaptor following the instructions N show in diagram. ne 2. Make sure tape - Samsung SMH1622W | Installation Instructions - Page 13
holds blower plate to microwave. Back of Microwave NOTE: The exhaust adaptor with damper is not needed for recirculating models. You may want to to microwave with the screw. B2. Installing the charcoal filter 1. Remove screws on top of grille using a #1 Phillips screwdriver. 2. Open the door. - Samsung SMH1622W | Installation Instructions - Page 14
top center of the back of the oven. Push in securely until it is in the lower locking tabs. Take care to assure that the damper hinge is installed so that it is at the top and that the damper swings freely. Adaptor Guide Back of Microwave Guide blower plate screw From Blower motor screw - Samsung SMH1622W | Installation Instructions - Page 15
installation guide 3. Installation INSTALLATION OVERVIEW A. Prepare Rear Wall (only horizontal duct) B. Attach Mounting Plate to Wall C. Prepare Top Cabinet D. Mount the Microwave Oven instructions on the REAR WALL TEMPLATE. • Tape it to the rear wall. • Cut the opening, following the instructions - Samsung SMH1622W | Installation Instructions - Page 16
Step-by-step installation guide B. ATTACH THE MOUNTING D. Mount the microwave D PLATE TO THE WALL (cont.) oven To use toggle bolts: Spacing for Toggles More Than Wall Thickness Mounting Plate Toggle Wings Toggle Bolt FOR EASIER INSTALLATION AND PERSONAL SAFETY, WE RECOMMEND THAT TWO - Samsung SMH1622W | Installation Instructions - Page 17
Step-by-step installation guide D. MOUNT THE MICROWAVE OVEN (cont.) Cabinet Front Cabinet Bottom Shelf Filler Block E. Connecting ductwork for outside top exhaust House Duct Equivalent to Depth of Cabinet Recess Self-Aligning Screw Microwave Oven Top 4. Attach the microwave oven to the top - Samsung SMH1622W | Installation Instructions - Page 18
Before You Use Your Microwave Before you use your microwave 1. Make sure the microwave oven has been installed according to instructions. 6. Read the Owner's Manual. 2. Remove all packing material from the microwave oven. 3. Install turntable and ring in cavity. 4. Replace house fuse or turn - Samsung SMH1622W | Installation Instructions - Page 19
Note 19 SMH8165_XAA DE68-03587A-04-EN_120725.indd 19 2012-07-25 �� 8:05:33 - Samsung SMH1622W | Installation Instructions - Page 20
SMH8165_XAA DE68-03587A-04-EN_120725.indd 20 Code No.: DE68-03587A-04 2012-07-25 �� 8:05:33
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
 |
 |
Installation Instructions
Over the Range Microwave Oven
BEFORE YOU BEGIN
(Read these instructions completely and carefully.)
IMPORTANT
Save these instructions for local inspector’s use.
IMPORTANT
Observe all governing codes and ordinances.
•
Note to Installer
-
Be sure to leave these instructions with the Consumer.
•
Note to Consumer
-
Keep these instructions for future reference.
•
Skill level
-
Installation of this appliance requires basic mechanical and electrical skills.
•
Proper installation is the responsibility of the installer.
•
Product failure due to improper installation is not covered under the Warranty.
READ CAREFULLY. KEEP THESE INSTRUCTIONS.
SMH8165_XAA DE68-03587A-04-EN_120725.indd
1
2012-07-25
�� 8:05:23