Sony HCD-D690 Service Manual
Sony HCD-D690 - Compact Disk Deck Receiver Manual
 |
View all Sony HCD-D690 manuals
Add to My Manuals
Save this manual to your list of manuals |
Sony HCD-D690 manual content summary:
- Sony HCD-D690 | Service Manual - Page 1
HCD-D690/XB6/XB600 SERVICE MANUAL HCD-D690, HCD-XB6, HCD-XB600 are the tuner, deck, CD and amplifier section in LBT-D690, LBT-XB6, LBT-XB600. Photo: HCD-XB6 US Model Canadian Model HCD-D690 AEP Model UK Model E Model Australian Model HCD-XB6 Mexican Model HCD Outputs PHONES (stereo phone jack): - Sony HCD-D690 | Service Manual - Page 2
More than 90 dB More than 90 dB Tape player section Recording system 4-track 2-channel stereo Frequency response (DOLBY NR OFF) 60 - 13,000 Hz (±3 dB), using a Sony TYPE I cassette 60 - 14,000 Hz (±3 dB), using a Sony TYPE II cassette Wow and flutter ±0.15% W. Peak (IEC) 0.1% W. RMS (NAB - Sony HCD-D690 | Service Manual - Page 3
SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before or RCA WT-540A. Follow the manufacturers' instructions to use these instruments. 2. A battery- SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY - Sony HCD-D690 | Service Manual - Page 4
ELECTRICAL ADJUSTMENTS DECK Section 32 TUNER Section 35 CD Section 37 SERVICING NOTES NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE Australian model XB6: AEP, UK models XB6: East European, CIS models D690: US model D690: Canadian model XB6: Mexican model XB600: Mexican model PARTS No. 4- - Sony HCD-D690 | Service Manual - Page 5
SECTION 1 GENERAL This section is extracted from instruction manual. - 5 - - Sony HCD-D690 | Service Manual - Page 6
- 6 - - Sony HCD-D690 | Service Manual - Page 7
- 7 - - Sony HCD-D690 | Service Manual - Page 8
- 8 - - Sony HCD-D690 | Service Manual - Page 9
- 9 - - Sony HCD-D690 | Service Manual - Page 10
- 10 - - Sony HCD-D690 | Service Manual - Page 11
- 11 - - Sony HCD-D690 | Service Manual - Page 12
- 12 - - Sony HCD-D690 | Service Manual - Page 13
- 13 - - Sony HCD-D690 | Service Manual - Page 14
- 14 - - Sony HCD-D690 | Service Manual - Page 15
- 15 - - Sony HCD-D690 | Service Manual - Page 16
- 16 - - Sony HCD-D690 | Service Manual - Page 17
- 17 - - Sony HCD-D690 | Service Manual - Page 18
- 18 - - Sony HCD-D690 | Service Manual - Page 19
- 19 - - Sony HCD-D690 | Service Manual - Page 20
- 20 - - Sony HCD-D690 | Service Manual - Page 21
- 21 - - Sony HCD-D690 | Service Manual - Page 22
SECTION 2 DISASSEMBLY • This set can be disassembled in the order shown below. CASE (Page 22) FRONT PANEL SECTION (Page 23) MAIN SECTION (Page 24) CD MECHANISM DECK SECTION (Page 24) BASE UNIT (Page 27) DISC TABLE (Page 27) BD BOARD (Page 28) TAPE MECHANISM DECK SECTION (Page 25) CD LID ASS - Sony HCD-D690 | Service Manual - Page 23
FRONT PANEL SECTION 1 three frat wires (CN102, 205, 206) 3 front panel section MAIN BOARD 3 connector (CN901) 2 four screws (BVTP 3 × 8) 5 power cord 6 back panel 4 ereven screws (BVTP 3 × 8) 1 two flat wires (CN1, 202) 2 connector (CN203) - 23 - 9 MAIN board IC201 8 connector (CN101) 7 two - Sony HCD-D690 | Service Manual - Page 24
MAIN SECTION 2 connector (CN203) 3 two screws (BVTP 3 × 8) 1 flat wire (CN202) 4 main section 3 screw (BVTP 3 × 8) 3 two screws (BVTP 3 × 8) CD MECHANISM DECK SECTION 3 five screws (BVTP 3 × 8) 4 CD mechanism deck section 2 flat wire and lead wire - 24 - 1 Open the clamp. - Sony HCD-D690 | Service Manual - Page 25
TAPE MECHANISM DECK SECTION 4 three screws (BVTP 2.6 × 8) 3 two flat wires (CN601, 1001) 4 three screws (BVTP 2.6 × 8) 5 Remove the tape mechanism deck section to direction of the arrow A. A 2 Open the cassette lids. CASSETTE LID ASS'Y 1 two springs 1 Push the two buttons. 3 two bracket 2 two - Sony HCD-D690 | Service Manual - Page 26
CD LID ASS'Y SECTION 5 connector (CN671) 6 four screws (BVTP 2.6 × 8) 7 CD lid ass'y 4 connector (CN661) PANEL (A) / (B) SUB ASS'Y 1 connector (CN642) 2 four screws (BVTP 2.6 × 8) 3 CD-B1 SW board 3 two claws 4 panel (A) sub ass'y 5 two claws 6 panel (B) sub ass'y - 26 - 1 connector (CN612) - Sony HCD-D690 | Service Manual - Page 27
BASE UNIT 3 base unit DISC TABLE Note: When the disc table is installed, adjust the positions of roller cam and mark z as shown in the figure, then set to the groove of disc table. 2 boss 1 yoke bracket A 1 screw (BVTP 3 × 8) 3 step screw 2 bracket (BU) 1 screw (BVTP 3 × 8) 4 disc table A - Sony HCD-D690 | Service Manual - Page 28
BD BOARD 1 two screws (PTPWH M2.6 × 6) 3 two springs 5 screw (BVTP 2.6 × 8) 6 Removal the four solders. OPTICAL PICK-UP, SLED MOTOR 3 optical pick-up 1 two screws (PTPWH M2.6 × 6) 2 optical pick-up section 3 two springs 4 flat wire (CN101) 7 BD board limit switch 2 sled shaft 1 claw 4 two screws - Sony HCD-D690 | Service Manual - Page 29
AUDIO BOARD 1 connector (CN651) 4 four screws (BTP 2.6 × 4) 5 MD board 2 two rivets 3 Break the soldering of two flexible flat cables. CAPSTAN MOTOR 4 Removal the capstan motor to direction of the arrow. 1 Break the soldering of motor lead. 3 claw - 29 - 2 two screws (BTP 2.6 × 8) 5 Hang the - Sony HCD-D690 | Service Manual - Page 30
SECTION 3 TEST MODE [MC Cold Reset] • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press three buttons GROOVE , ENTER/NEXT , and DISC 1 simultaneously. 2. The fluorescent - Sony HCD-D690 | Service Manual - Page 31
[Aging Mode] This mode can be used for operation check of CD section and tape deck section. • If an error occurred: The aging operation stops. • If no error occurs: The aging operation continues repeatedly. 1. Aging Mode in CD Section 1-1. Operating Method of Aging Mode 1. Set discs in DISC 1 and - Sony HCD-D690 | Service Manual - Page 32
with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed - Sony HCD-D690 | Service Manual - Page 33
1. Mode: Playback (FWD) 2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak. L-CH peak within 1dB output level within 1dB Screw position R-CH peak L-CH R-CH peak peak Screw - Sony HCD-D690 | Service Manual - Page 34
Record bias Current Adjustment Procedure: 1. Mode: record DECK B Pin 6 (L-CH) of IC1501 on the main board. Pin #¶ (R-CH) of IC1501 on the main board. AF OSC 1) 2) 315 Hz 10 kHz 50 mV (-23.8 dB) blank tape 600 Ω attenuator CN-123 set Pin 2 (GND) of ICN207 on the main board. 2. - Sony HCD-D690 | Service Manual - Page 35
Adjustment Note: This adjustment should be performed after the AM Tuned Level Adjustment due to the same adjustment element. Setting: FM RF stereo signal generator 75 Ω coaxial RV42 TM1 FE1 set Carrier frequency : 98 MHz Modulation : AUDIO 1 kH, 75 kHz deviation (100%) FM ANTENNA terminal - Sony HCD-D690 | Service Manual - Page 36
FM Polar Adjustment (EE, CIS models only) Connection 1: FM RF SSG 75 Ω coaxial set FM ANTENNA terminal (75 Ω) Carrier frequency : 69 MHz Output level : 1mV (60dBµ) (at 75 open) Modulation : AUDIO 1 kHZ, 10kHz deviation Connection 2: AF OSC FM RF SSG 75 Ω coaxial Audio 31.25 kHz - Sony HCD-D690 | Service Manual - Page 37
CD SECTION Note: 1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10M impedance. 4. Clean the object lens by an applicator with neutral - Sony HCD-D690 | Service Manual - Page 38
E-F Balance (1 Track Jump) check (Without remote commander) BD board oscilloscope TP (TEO) + TP (VC) - Procedure: 1. Connect oscilloscope to test point TP (TEO) on BD board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in to play the number five track. 4. Press the "P (Pause)" button. ( - Sony HCD-D690 | Service Manual - Page 39
• Circuit Board Location SECTION 6 DIAGRAMS TRANS board PANEL board TCB board HEADPHONE-MIC board TC-A SW board LED board CD-A SW board DOOR SW board CD-B2 SW board MAIN board POWERAMP board TC-B SW board CD-B1 SW board MOTOR board CD MOTOR board LEAF SWITCH board BD board AUDIO board TABLE - Sony HCD-D690 | Service Manual - Page 40
• Waveforms - BD Section- 1 IC101 #£ pin (PLAY MODE) 6 IC103 ^™ pin (RFCK) !¡ IC301 !£ pin (XT2) Approx. 1.3 Vp-p 5.6 V 4.6 Vp-p 2 IC101 2 pin (FEI) (PLAY MODE) 135.5 µsec 7 IC103 &¢ pin (WFCK) Approx. 0.1 V 31.3 µsec - TUNER Section- !™ IC1 @¢ pin (XOUT) (EXCEPT AEP, UK,EE, CIS) IC21 @¢ - Sony HCD-D690 | Service Manual - Page 41
HCD-D690/XB6/XB600 6-1. BLOCK DIAGRAMS - TUNER SECTION - (US, CND, E, AR, MX, AUS MODELS) TM1 VCO STOP IF BUFF MUTE OUT R 21 RCH FM / AM MPX AM IC2 A MAIN SECTION (page 47) 4 REG ST LED 8 STEREO 70 TUNED 7 TUNED 69 FE2 AM FRONTEND 3 ANT IN 7 B+ F OUT 9 RF OUT 13 VT 14 29 AM OSC AM MIX - Sony HCD-D690 | Service Manual - Page 42
HCD-D690/XB6/XB600 - TUNER SECTION - (AEP, UK MODELS) TM1 ANTENNA FM 75Ω COAXIAL AM ST +10V Q5 FE1 FM / AM MPX IC41 A MAIN SECTION (page 47) 12 LW SW Q9 13 14 15 16 17 Q11 MW SW 4 REG STEREO STEREO 8 70 TUNED 7 TUNED 69 29 AM OSC AM MIX 2 5 AM IF AM IF IFT41 AM SD 12 RV41 AM TUNED - Sony HCD-D690 | Service Manual - Page 43
AM MPX IC41 9 11 12 LW SW Q9 13 14 15 16 17 Q11 MW SW 4 REG STEREO 8 TUNED 7 29 AM OSC AM MIX 2 5 AM IF AM IF IFT41 AM SD 12 RV41 IN 30 14 15 11 X41 10.7MHz 9 DET AM SD 13 X42 450KHz 23 VCO X43 456KHz STEREO 70 TUNED 69 Q1702 SW AMP OUT L 16 LPF 18 AMP IN L A MAIN SECTION (page - Sony HCD-D690 | Service Manual - Page 44
- 45 - - CD SECTION - OPTICAL PICK-UP BLOCK DETECTOR K B+ E A A D D B C C B F LASER DIODE FOCUS COIL 1 4 2 5 10 6 TRACKING COIL 2-AXIS DEVICE IC101(1/2) FOCUS/TRACKING /SLED/SERVO RF AMP 38 PD1 39 PD2 41 F 42 E RFO 33 C,OUT 24 SENS1 25 FOK 27 DATA 22 XLT 21 CLK 20 LOCK 19 FE-O 6 FE - Sony HCD-D690 | Service Manual - Page 45
65 66 67 68 69 70 72 55 56 100 6 1 AC CUT TA MUTE STK MUTE F-RELAY 11C-CLK XT2 11C-DATA ST MUTE 72 STEREO 70 TUNED 69 ST-CE 68 ST-DOUT 67 CD-POWER ST-DIN 66 ST-CLK 65 COM DOUT COM CLK 427LAT REALY TC-MUTE - Sony HCD-D690 | Service Manual - Page 46
- Sony HCD-D690 | Service Manual - Page 47
- Sony HCD-D690 | Service Manual - Page 48
- Sony HCD-D690 | Service Manual - Page 49
- Sony HCD-D690 | Service Manual - Page 50
- Sony HCD-D690 | Service Manual - Page 51
- Sony HCD-D690 | Service Manual - Page 52
- Sony HCD-D690 | Service Manual - Page 53
- Sony HCD-D690 | Service Manual - Page 54
- Sony HCD-D690 | Service Manual - Page 55
- Sony HCD-D690 | Service Manual - Page 56
- Sony HCD-D690 | Service Manual - Page 57
- Sony HCD-D690 | Service Manual - Page 58
- Sony HCD-D690 | Service Manual - Page 59
- Sony HCD-D690 | Service Manual - Page 60
- Sony HCD-D690 | Service Manual - Page 61
- Sony HCD-D690 | Service Manual - Page 62
- Sony HCD-D690 | Service Manual - Page 63
• IC Block Diagrams -BD Section - IC101 CXA1992AR PD2 PD1 PD LD RFTC RF_M RF_O RF_I CP CB CC1 CC2 FOK - + + - - + - + - + FE_BIAS 40 F 41 39 38 37 36 35 34 33 32 31 30 29 28 27 VEE - + PD2 IV AMP PD1 IV AMP + - - + - + RF SUMMING AMP - + + - + - + - - + F IV AMP VCC APC - Sony HCD-D690 | Service Manual - Page 64
IC102 BA5941FP IN4B IN4A IN3B IN3A OP OUT OP IN (-) OP IN (+) GND NC VCC OUT3A OUT3B OUT4A OUT4B 28 27 26 25 24 23 22 21 20 19 18 17 16 15 NC Vcc +- +- +- +- - + - + + - + - +- LEVEL SHIFT LEVEL SHIFT LEVEL SHIFT LEVEL SHIFT +- +- +- +- Vcc MUTE Vcc 1 2 3 4 5 6 - Sony HCD-D690 | Service Manual - Page 65
- CD MOTOR Section - IC201 TA8409S STANDBY BLOCK VREF BLOCK HEAT CUT OFF BLOCK 1 2 3 4 5 6 7 8 9 IN2 VCC OUT2 NC GND VS OUT1 VREF IN1 - TUNER Section - IC1 LC72130 (Except AEP, UK, East European, CIS models) IC21 LC72130 (AEP, UK, East European, CIS models) IO2 AMIN VDD AOUT1 - Sony HCD-D690 | Service Manual - Page 66
DET FM IF S-CURVE AM/FM IF BUFF FM DET REG COMP TUNING DRIVE AM FM GND 1 23 4 5 6 AM/FM SW DECODER ANTI BIRDIE STEREO DRIVE STEREO SW TRIG FF FF FF VCO PHASE DET PILOT DET MUTE 78 VCC 9 10 11 12 13 14 15 FM-IN AM-MIX IF REG - Sony HCD-D690 | Service Manual - Page 67
- DECK Section - IC602 µPC1330HA INVERTER COMPARATER 1 2 3 4 5 6 7 8 9 SW R1 GND SW P1 CONT GND VCC SW P2 GND SW R2 IC502 LB1641 T.S.D MOTOR DRIVE O.C.P MOTOR DRIVE FWD/REV/STOP CONTROL LOGIC 1 2 3 4 5 6 7 8 9 10 GND MOTOR DRIVE NOISE FILTER CLAMP FWD.IN REV.IN VCC 1 VCC 2 - Sony HCD-D690 | Service Manual - Page 68
IC201 M6247FP KEY OUT2 NC7 REC 2A REC 2B REC 2C NC6 F1 F2 F1 O2 F1 IN2 F2 F2 F2 O2 F2 IN2 F3 F2 F3 O2 F3 IN2 F4 F2 F4 O2 F4 IN2 F5 F2 F OUT2 VOL IN2 VOL OUT2 BBIN2 BB12 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 KEY IN2 65 BPF OUT 66 BPF IN 67 NC8 68 IN 2B 69 NC9 70 - Sony HCD-D690 | Service Manual - Page 69
6-20. IC PIN FUNCTION DESCRIPTION MAIN BOARD IC301 µPD780018Y (MAIN CONTROL) Pin No. Pin Name I/O 1 TA-MUTE O 2 DBFB-H/L O 3 427-LT O 4 KCON-LT O 5 KCON-ON/OFF O 6 F-RELAY O 7 R-RELAY O 8 PL-RELAY O 9 TEST I 10 X2 O 11 X1 I 12 VDD - 13 XT2 O 14 XT1 I 15 RESET I 16 - Sony HCD-D690 | Service Manual - Page 70
CD tray LED ON/OFF output Not used Tuner clock output Tuner data input Tuner data output Tuner chip enable output Tuned detection for tuner Stereo detection for tuner Ground Tuner mute signal output BD Condition signal input Not used CD table detection signal input Up SW (S201) signal input Not - Sony HCD-D690 | Service Manual - Page 71
Pin No. Pin Name I/O 88 EQ-H/N O 89 BIAS O 90 REC-MUTE O 91 NR-ON/OFF O 92 R/P-PASS I 93 TC-MUTE O 94 A-PLAY-SW I 95 B-PLAY-SW I 96 TC-RELAY O 97 A-HALF I 98 POWER O 99 SW-F-CHG O 100 STK-MUTE O Equalizer H/N select output Bias ON/OFF signal output REC mute ON/OFF selection - Sony HCD-D690 | Service Manual - Page 72
PANEL BOARD IC601 TMP87CM75 (DISPLAY CONTROL) Pin No. Pin Name I/O 1 SEG-35 O 2 V-LOAD - 3-10 LED1-LED8 O 11 Vss - 12 X-OUT O 13 X-IN I 14 RESET I 15.16 LED9•10 O 17 TEST I 18-23 LED11-16 O 24 VOL-A I 25 LED17 O 26 JOG-A I 27 CLOCK I 28 DATA I 29 LED SELECT O - Sony HCD-D690 | Service Manual - Page 73
: Australian MX: Mexican CND: Canadian (1) CASE, REAR PANEL SECTION 2 • Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not - Sony HCD-D690 | Service Manual - Page 74
BUTTON (EJECT CD) 1-664-019-11 CD-A SW BOARD X-4948-295-1 PANEL (A) SUB ASSY (D690) X-4948-348-1 PANEL (A) SUB ASSY (XB6/XB600) 1-664-012-11 TC-A SW BOARD 4-986 TYPE) (21 CORE) 1-769-949-11 WIRE (FLAT TYPE) (11 CORE) 3-354-963-01 DAMPER 1-664-017-11 LED BOARD Ref. No. 62 * 63 * 64 65 * 66 * 67 - Sony HCD-D690 | Service Manual - Page 75
110 * 111 112 113 Part No. Description A-4384-402-A PANEL ASSY, FRONT (D690) A-4384-403-A PANEL ASSY, FRONT (XB6) A-4384-480-A PANEL ASSY, FRONT -01 INDICATOR (TC A) 4-986-997-01 BUTTON (DECK.A) 4-963-404-21 EMBLEM (5-A), SONY 4-973-644-01 KNOB (MIC) 4-951-620-01 SCREW (2.6X8), +BVTP A-4392-452 - Sony HCD-D690 | Service Manual - Page 76
(4) CHASSIS SECTION E, AR, MX #2 152 T901 #1 CDM37L-5BD29AL #1 not supplied 151 #1 #1 #1 153 #4 154 not supplied #1 #1 not supplied 159 155 #1 156 not supplied UK E, MX CNP901 AEP, EE, CIS, AR CNP901 AR 158 US, CND CNP901 AUS CNP901 CNP901 #1 not supplied 157 The components - Sony HCD-D690 | Service Manual - Page 77
, CASSETTE 4-959-231-11 SPRING (L), TORSION 4-959-232-11 SPRING (R), TORSION Remark Ref. No. 206 * 207 208 209 210 Part No. Description 3-354-963-01 DAMPER 4-980-439-01 FULCRUM, HOLDER 3-354-957-01 JOINT (LOCK LEVER) 3-354-953-01 LEVER (LOCK LEVER L) 3-354-954-01 LEVER (LOCK LEVER R) Remark - Sony HCD-D690 | Service Manual - Page 78
(6) TAPE MECHANISM DECK SECTION-2 (TCM-220WR2) 273 265 271 264 #6 270 269 (including r C) r A #6 not supplied HP101 272 266 (including r A) r A 257 262 263 269 r B 261 265 256 258 264 259 267 272 255 260 not supplied not supplied 266 269 r B 254 HRPE101 268 262 ( - Sony HCD-D690 | Service Manual - Page 79
(7) TAPE MECHANISM DECK SECTION-3 (TCM-220WR2) r C : MOTOR board (supplied with AUDIO board) M2 318 317 302 309 316 #7 313 315 r C 319 310 320 311 310 308 323 305 #10 307 306 #11 321 #10 321 325 319 322 307 314 313 312 304 #8 #9 #9 303 301 302 M1 not supplied Ref. No. 301 302 303 304 - Sony HCD-D690 | Service Manual - Page 80
(8) CD MECHANISM DECK SECTION (CDM37L-5BD29AL) 351 352 358 351 351 353 354 359 360 360 359 355 356 357 #1 361 373 362 372 352 M201 not supplied 363 368 367 368 369 365 #1 361 #1 #1 #1 366 364 359 360 375 374 368 BU-5BD29AL 369 370 371 Ref. No. 351 352 353 354 355 Part No. - Sony HCD-D690 | Service Manual - Page 81
(9) BASE UNIT SECTION (BU-5BD29AL) 401 #12 402 403 405 M101 404 M102 404 406 407 408 Ref. No. ! 401 402 403 404 405 Part No. Description 8-820-020-01 OPTICAL PICK-UP KSS-213D/Q-NP 1-769-069-11 WIRE (FLAT TYPE) (16 CORE) 4-917-567-21 GEAR (M) 4-951-940-01 INSULATOR (BU) 4-917-565-01 - Sony HCD-D690 | Service Manual - Page 82
resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable • Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB - Sony HCD-D690 | Service Manual - Page 83
AUDIO BD Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R608 R609 R611 1-249-409-11 CARBON 1-249-433-11 CARBON 1-249-409-11 CARBON 220 5% 1/4W 22K 5% 1/4W 220 5% 1/4W C124 C125 C126 1-126-607-11 ELECT CHIP 47uF 1-164-232-11 CERAMIC CHIP 0.01uF 1-163-038-91 - Sony HCD-D690 | Service Manual - Page 84
BD BD LED CD MOTOR CD-A SW Ref. No. Part No. Description < TRANSISTOR > Q101 8-729-010-08 TRANSISTOR MSB710-R < RESISTOR > R102 1-216-001-00 METAL CHIP 10 5% R104 1-216-093-00 METAL CHIP 68K 5% R105 1-216-088-00 METAL CHIP 43K 5% R106 1-216-088-00 METAL CHIP 43K 5% R107 1-216-088-00 - Sony HCD-D690 | Service Manual - Page 85
CD-A SW CD-B1 SW CD-B2 SW DOOR SW HEADPHONE-MIC Ref. No. Part No. Description < RESISTOR > R731 1-249-411-11 CARBON 330 R732 1-249-413-11 CARBON 470 R733 1-249-415-11 CARBON 680 R734 1-249-417-11 CARBON 1K R735 1-249-419-11 CARBON 1.5K Remark Ref. No. Part No. Description Remark 5% - Sony HCD-D690 | Service Manual - Page 86
HEADPHONE-MIC LEAF SWITCH LED MAIN Ref. No. R769 R770 Part No. Description 1-247-885-00 CARBON 1-247-807-31 CARBON 180K 100 Remark 5% 1/4W 5% 1/4W < VARIABLE RESISTOR > RV760 1-225-366-11 RES, VAR, CARBON 50K (MIC LEVEL * 1-650-669-11 LEAF SWITCH BOARD < CONNECTOR > Ref. No. C101 - Sony HCD-D690 | Service Manual - Page 87
Ref. No. C222 C223 C224 C226 Part No. Description 1-126-967-11 ELECT 1-126-964-11 ELECT 1-162-290-31 CERAMIC 1-126-964-11 ELECT C231 C251 C252 C253 C254 1-126-960-11 ELECT 1-136-167-00 FILM 1-136-167-00 FILM 1-130-493-00 MYLAR 1-130-493-00 MYLAR C255 C256 C257 C258 C259 1-130-486-00 MYLAR 1- - Sony HCD-D690 | Service Manual - Page 88
MAIN Ref. No. D951 D952 Part No. Description 8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M Remark < FERRITE BEAD > FB301 1-412-473-21 INDUCTOR 0UH < IC > IC101 IC102 IC201 IC231 IC281 8-759-634-50 IC M5218AL 8-759-000-48 IC MC14052BCP 8-759-460-02 IC M62427FP-A 8-759-634-50 IC - Sony HCD-D690 | Service Manual - Page 89
Ref. No. R207 Part No. Description 1-249-431-11 CARBON R209 R210 R211 R212 R213 1-249-441-11 CARBON 1-247-887-00 CARBON 1-247-891-00 CARBON 1-249-411-11 CARBON 1-249-429-11 CARBON R214 R215 R216 R217 R221 1-249-437-11 CARBON 1-247-903-00 CARBON 1-249-429-11 CARBON 1-249-437-11 CARBON 1-249- - Sony HCD-D690 | Service Manual - Page 90
MAIN PANEL Ref. No. R917 R918 R920 R921 R951 Part No. Description 1-247-815-91 CARBON 1-249-425-11 CARBON 1-249-417-11 CARBON 1-247-895-91 CARBON 1-249-425-11 CARBON 220 5% 4.7K 5% 1K 5% 470K 5% 4.7K 5% R952 R1501 R1502 R1503 R1504 1-249-425-11 CARBON 1-249-435-11 CARBON 1-249-417-11 - Sony HCD-D690 | Service Manual - Page 91
Ref. No. D606 D607 D611 D612 D613 D614 D615 D616 D617 D618 D619 D620 D621 D622 D623 D624 D625 Part No. Description Remark 8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M 8-719-057-29 DIODE SML78423C-TP15 (TUNER/BAND) 8-719-057-29 DIODE SML78423C-TP15 (TUNER/BAND) 8-719-058-04 DIODE - Sony HCD-D690 | Service Manual - Page 92
/BAND) 1-554-303-21 SWITCH, TACTILE (TUNING +) S606 S607 S609 S610 S611 1-554-303-21 SWITCH, TACTILE (TUNING -) 1-554-303-21 SWITCH, TACTILE (STEREO/MONO) 1-554-303-21 SWITCH, TACTILE (FUNCTION) 1-554-303-21 SWITCH, TACTILE (GROOVE) 1-554-303-21 SWITCH, TACTILE (GEQ ¢) S612 S613 S614 S615 S616 - Sony HCD-D690 | Service Manual - Page 93
POWERAMP TABLE SENSOR TC-A SW TC-B SW Ref. No. Part No. Description < TRANSISTOR > Q801 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA Q851 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA Remark Ref. No. * Part No. Description 1-659-058-13 TABLE SENSOR BOARD < IC > Remark < RESISTOR > IC202 8-749-924- - Sony HCD-D690 | Service Manual - Page 94
TC-B SW TCB Ref. No. Part No. Description Remark Ref. No. R717 1-249-413-11 CARBON 470 5% 1/4W C14 R718 1-249-415-11 CARBON 680 5% 1/4W R719 1-249-417-11 CARBON 1K 5% 1/4W C16 R720 1-249-419-11 CARBON 1.5K 5% 1/4W C19 R721 1-249-421-11 CARBON 2.2K 5% 1/4W R722 1-247-843-11 - Sony HCD-D690 | Service Manual - Page 95
TCB Ref. No. C42 C42 C43 C43 C44 C44 C45 C45 C46 C46 C47 C47 C48 C48 C49 C49 C49 C50 C50 C50 C51 C51 C52 C52 C53 C54 C54 C55 C55 C56 C56 C57 C57 Part No. Description Remark 1-162-306-11 CERAMIC 0.01uF 20% 16V (EXCEPT AEP,UK,EE,CIS) 1-163-038-91 CERAMIC (2012) 100000PF 25V (AEP,UK,EE,CIS) - Sony HCD-D690 | Service Manual - Page 96
TCB Ref. No. C1706 C1707 C1710 C1711 C1712 C1713 C1714 C1715 C1716 C1719 C1720 C1723 C1724 C1725 C1726 C1727 C1728 CF1 CF1 CF2 CF2 CF3 CF3 * CN1 * CN1 Part No. Description 1-126-960-11 ELECT 1.0uF 20% 1-163-129-00 CERAMIC CHIP 330P 5% 1-163-141-00 CERAMIC CHIP 0.001uF 5% Remark 50V (EE,CIS) - Sony HCD-D690 | Service Manual - Page 97
TCB Ref. No. Part No. Description LPF42 1-239-845-11 FILTER, LOW PASS Remark Ref. No. R10 < TRANSISTOR > R11 Q1 8-729-201-27 TRANSISTOR 2SC2715Y-TE85L R11 (AEP,UK,EE,CIS) Q1 8-729-230-99 TRANSISTOR 2SC2669OY-TPE4 R12 (EXCEPT AEP,UK,EE,CIS) Q2 8-729-201-27 TRANSISTOR 2SC2715Y-TE85L - Sony HCD-D690 | Service Manual - Page 98
TCB Ref. No. R29 R29 R30 R30 R31 R31 R32 R32 R33 R33 R34 R34 R35 R35 R36 R36 R37 R37 R38 R39 R41 R42 R43 R43 R44 R44 R45 R46 R46 R47 R47 R48 Part No. Description 1-216-061-00 METAL CHIP 3.3K Remark 5% 1/10W (AEP,UK,EE,CIS) 1-249-417-11 CARBON 1-216-186-00 CHIP (3216) 1-249-417-11 CARBON 1-216- - Sony HCD-D690 | Service Manual - Page 99
TCB TRANS Ref. No. Part No. Description R1721 1-216-073-00 METAL CHIP 10K Remark 5% 1/10W (EE,CIS) < VARIABLE RESISTOR > RV41 1-238-600-11 ADJ, CARBON 10K (EXCEPT AEP,UK,EE,CIS) RV41 1-238-601-11 ADJ, CARBON 22K (AEP,UK,EE,CIS) RV42 1-238-600-11 ADJ, CARBON 10K (AEP,UK,EE,CIS) RV42 1-238-601- - Sony HCD-D690 | Service Manual - Page 100
AEP,UK,EE,CIS) 1-501-804-11 ANTENNA (FM) (AEP,UK,EE,CIS) 3-859-536-11 MANUAL, INSTRUCTION (ENGLISH) (US,CND,E,AR,MX,AUS) 3-859-536-21 MANUAL, INSTRUCTION (FRENCH)(CND) 3-859-536-31 MANUAL, INSTRUCTION (FRENCH,SPANISH) (E,AR,MX) 3-859-537-11 MANUAL, INSTRUCTION (ENGLISH) (AEP,UK,EE,CIS) 3-859-537-21 - Sony HCD-D690 | Service Manual - Page 101
- Sony HCD-D690 | Service Manual - Page 102
- Sony HCD-D690 | Service Manual - Page 103
- Sony HCD-D690 | Service Manual - Page 104
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
 |
 |
MICROFILM
COMPACT DISC DECK RECEIVER
US Model
Canadian Model
HCD-D690
AEP Model
UK Model
E Model
Australian Model
HCD-XB6
Mexican Model
HCD-XB600
SERVICE MANUAL
HCD-D690, HCD-XB6, HCD-XB600 are
the tuner, deck, CD and amplifier section
in LBT-D690, LBT-XB6, LBT-XB600.
Model Name Using Similar Mechanism
HCD290/G330/XB3
CD Mechanism Type
CDM37L-5BD29AL
Base Unit Name
BU-5BD29AL
Optical Pick-up Name
KSS-213D/Q-NP
Model Name Using
Similar Mechanism
HCD-H881
Tape Transport Mechanism Type
TCM-220WR2
CD
Section
Tape deck
Section
SPECIFICATIONS
Photo: HCD-XB6
Peak music power output
Argentine, Australian, E, Mexican
models:
1400 watts
Music power output
AEP, UK, East European, CIS models:210+210 watts
Inputs
PHONO IN (phono jacks):
sensitivity 3 mV, impedance 47 kilohms
VIDEO (AUDIO) IN (phono jacks): sensitivity 250 mV, impedance 47 kilohms
MIX MIC (phono jack):
sensitivity 1 mV, impedance 10 kilohms
Outputs
PHONES (stereo phone jack):
accepts headphones of 8 ohms or more
SPEAKER:
accepts impedance of 8 to 16 ohms
SURROUND SPEAKER:
accepts impedance of 16 ohms
– Continued on next page –
HCD-D690/XB6/XB600
For the US model
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 8 ohm loads, both channels driven, from 70-20,000 Hz; rated 100 watts
per channel minimum RMS power, with no more than 0.9 % total harmonic
distortion from 250 milliwatts to rated output.
Amplifier section
DIN power output
AEP, UK, East European, CIS models:100+100 watts (6 ohms at 1 kHz, DIN)
Continuous RMS power output
Canadian model:
100+100 watts
(8 ohms at 1 kHz, 5%)
Argentine, Australian, E, Mexican
models:
100+100 watts
(8 ohms at 1kHz, 10% THD)
AEP, UK, East European, CIS models:120+120 watts
(6 ohms at 1kHz, 10% THD)