Sony HCD-SH2000 Service Manual
Sony HCD-SH2000 Manual
 |
View all Sony HCD-SH2000 manuals
Add to My Manuals
Save this manual to your list of manuals |
Sony HCD-SH2000 manual content summary:
- Sony HCD-SH2000 | Service Manual - Page 1
HCD-SH2000 SERVICE MANUAL E Model Ver. 1.1 2011.09 • HCD-SH2000 is the tuner, USB, CD and amplifier section in FST-SH2000/LBT-SH2000. • "WALKMAN" and "WALKMAN" logo are registered trademarks of Sony Corporation. • MPEG Layer-3 audio coding technology and patents licensed from Fraunhofer IIS and - Sony HCD-SH2000 | Service Manual - Page 2
HCD-SH2000 SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described - Sony HCD-SH2000 | Service Manual - Page 3
HCD-SH2000 TABLE OF CONTENTS 1. SERVICING NOTES 4 2. DISASSEMBLY 2-1. Side Panel A, Side Panel B and Top Panel (Suffix 12) - .. 31 5-17. Printed Wiring Board - DMB21 Board (Component Side 32 5-18. Printed Wiring Board - DMB21 Board (Conductor Side 33 5-19 Section 69 7. ELECTRICAL PARTS LIST 70 3 - Sony HCD-SH2000 | Service Manual - Page 4
HCD-SH2000 Ver. 1.1 SECTION 1 SERVICING NOTES Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. MODEL board cannot exchange with single. When these parts on the DMB21 board are damaged, - Sony HCD-SH2000 | Service Manual - Page 5
type set to doing the repair referring to the following. - MAIN Board (Component Side) - SUFFIX-11 : 1-883-863-11 SUFFIX-12 : 1-883 B) on the MAIN board (Suffix-12) cannot exchange with single. When these parts on the MAIN board (Suffix-12) are damaged, remove IC103 and C242 (Combination HCD-SH2000 5 - Sony HCD-SH2000 | Service Manual - Page 6
HCD-SH2000 SECTION 2 DISASSEMBLY Note: Disassemble the unit in the order as shown below. SET 2-1. SIDE PANEL A,SIDE PANEL B AND TOP PANEL SECTION (Page 6) 2-2. BACK PANEL SECTION ( - Sony HCD-SH2000 | Service Manual - Page 7
2-2. BACK PANEL SECTION 4 CN1404 (3P) HCD-SH2000 Ver. 1.1 3 CN1405 (3P) 1 twelve screws (+BVTP 3 x 10) 6 back panel section 5 2 wire (flat type) (7 core) (CN703) 2-3. FRONT PANEL SECTION 1 two screws (+BVTP 3 x10) (for SAF, EA - Sony HCD-SH2000 | Service Manual - Page 8
HCD-SH2000 Ver. 1.1 2-4. DMB21 BOARD (for SAF, EA only) 8 wire (flat type) (7P core) (CN202/CN203) 7 wire (flat type) (24 core) (CN101) qd shield plate bottom DMB21 - Sony HCD-SH2000 | Service Manual - Page 9
HCD-SH2000 2-6. CD MECHANISM DECK BLOCK (1) Note 1 : Before disconnecting the wire (flat type) (24 core) of optical pick-up block, solder the short-land. 2 two claws 4 FFC - Sony HCD-SH2000 | Service Manual - Page 10
HCD-SH2000 Ver. 1.1 2-8. DAMP BOARD, MAIN BOARD 1 two screws (+BVTP 3 x 10) 3 three screws (+BVTT 3 x 12 (S)) (for SAF, EA only) 6 CN2 (9P) qa one screw (+BVTP 3 x 10) qsstopper - Sony HCD-SH2000 | Service Manual - Page 11
MODE HCD-SH2000 PANEL TEST MODE This mode is used to check the fluorescent indicator tube, LEDs, keys, [MASTER VOLUME] jog, model, destination for Saudi Arabian, European and Russian models. Procedure: 1. Press @/1 button to turn on the system. 2. Press [FUNCTION] button repeatedly to select the "AM - Sony HCD-SH2000 | Service Manual - Page 12
only applied when there is disc. Procedure: 1. Press @/1 button to turn on the system. 2. Select CD function. 3. Press [PLAY/PAUSE] button and [EJECT] button simultaneously for 3 seconds. The message "LOCKED" or "UNLOCKED" displayed on the fluorescent indicator tube. FACTORY PRESET This mode is use - Sony HCD-SH2000 | Service Manual - Page 13
Generator to FM antenna input directly. Carrier function and scan the input FM signal with automatic scanning. 4. Confirm that input Frequency of A, B and C detected and automatic scanning stops. The stop of automatic scanning means "The station signal is received in good condition". HCD-SH2000 - Sony HCD-SH2000 | Service Manual - Page 14
HCD-SH2000 • Circuit Boards Location SECTION 5 DIAGRAMS DAMP board MS-214 board TUNER MAIN board DMB21 board SWITCHING REGULATOR DISPLAY board BUTTON board MIC board BUTTON LED board VOLUME LED board USB board VOLUME board AUDIO-IN board 14 - Sony HCD-SH2000 | Service Manual - Page 15
27 /HUB-OC2 28 BA0 BA1 CLK LDQM UDQM RAS CAS WE 20 21 38 15 39 18 17 16 SYSTEM CONTROLLER IC100 (1/4) 45 - 49, 51 - 53, 64 - 61, 56 - 59 RD0 - RD15 82, IC301 7 5 VBUS +5V R-ch is omitted due to same as L-ch. SIGNAL PATH : AUDIO (DIGITAL) : AUDIO : USB HCD-SH2000 15 15 HCD-SH2000 - Sony HCD-SH2000 | Service Manual - Page 16
MIC 39 GAME_L 43 TV IN-L 45 PC IN-L 40 GAME IN-L 42 DVD/SAT IN-L ANTENNA FM/AM IC1602 TUNER (FM/AM) 4 FM ANT LOUT 15 ROUT 14 6 AM ANT R-CH 13 CK 10 RDSI 8 24 ST-DATA 22 ST-CLK 20 ST-RDS SYSTEM CONTROLLER IC100 (2/4) INGAIN OUTL 38 OUTL 26 SWOUT 25 BB1L 28 BB2L AM) : MIC HCD-SH2000 16 16 - Sony HCD-SH2000 | Service Manual - Page 17
-IN 2 DC PROTECTION Q1449 DC PROTECTION Q1448 13V M101 DC FAN G (Page 18) 26 70 69 71 SYSTEM CONTROLLER IC100 (3/4) E (Page 16) FAN MOTOR DRIVE Q1451, Q1441, Q1439, Q1458, Q1453, Q1476 DAMP FAN M102 DC FAN 75 FAN LOCK DETECT Q1447 SMPS FAN FAN-EN 60 /FAN-LOCK 61 HCD-SH2000 17 17 - Sony HCD-SH2000 | Service Manual - Page 18
HCD-SH2000 5-4. BLOCK DIAGRAM - PANEL, POWER SUPPLY Section - FL9001 FLUORESCENT INDICATOR TUBE GRIDS 1-16 SEGMENTS 1-24 FLUORESCENT INDICATOR TUBE DRIVER IC901 GR1 GR16 SG4/KS4 1 SG3/KS3 2 SG2/KS2 3 SG1/KS1 SG24/KS24 2 FL-DRIVER-CLK 1 FL-DRIVER-DATA 21 /FL-DRIVER-CS SYSTEM CONTROLLER IC100 - Sony HCD-SH2000 | Service Manual - Page 19
pattern face are indicated. Parts face side: Parts on the parts face side seen from (Component Side) the parts face are indicated. t E model E51 : Chilean and Peruvian models EA : Saudi Arabia model MX : Mexican model MY : Malaysia model SAF : South African model HCD-SH2000 19 19 HCD-SH2000 Ver. - Sony HCD-SH2000 | Service Manual - Page 20
- F -&% 41&",&3 3 G H I F700 3 1 3 1 J500 MAIN BOARD (Component side) DMB21 I BOARD CN4604 (Page 32) DMB21 F BOARD CN602 (Page 32) (CHASSIS Page 37) B DAMP BOARD CN1401 (Page 37) J HCD-SH2000 20 20 Note: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how - Sony HCD-SH2000 | Service Manual - Page 21
. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 A B MAIN BOARD (Conductor side) C D E F G H 11 1-883-863- (11) I J HCD-SH2000 21 21 Note: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. - Sony HCD-SH2000 | Service Manual - Page 22
(12) (CHASSIS) G DAMP BOARD CN1400 (Page 37) B DAMP BOARD CN1401 (Page 37) J HCD-SH2000 Note 1: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. Note 2: A part of circuit composition of MAIN board (Suffix-12) has been changed in - Sony HCD-SH2000 | Service Manual - Page 23
. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 A B MAIN BOARD (Conductor side) C D E F G H 12 1-883-863- (12) I J HCD-SH2000 23 23 Note: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. - Sony HCD-SH2000 | Service Manual - Page 24
HCD-SH2000 Ver. 1.1 5-9. SCHEMATIC DIAGRAM - MAIN BOARD (1/4) (Suffix 11) - • See page 53 for Waveforms. • See page 61 for IC Pin Function -LED-BLUE 99 AVCC JL200 1.3 100 IC100 SYSTEM CONTROL IC100 R5F3650KBDFA 12 0 JL150 50 0 ) AC-DET S/ D-FAST DBFB FAN-EN FAN-LOCK 49 26 71 47 69 70 45 75 44 - Sony HCD-SH2000 | Service Manual - Page 25
OCS1_N VDD18 VDD33CR PRTPWR2 OCS2_N NC 10 11 12 13 14 15 16 17 18 3.3 0 3.3 3.3 C311 10 C411 0.1 R327 R326 220 45 220 44 HCD-SH2000 25 25 HCD-SH2000 11 12 13 14 15 15 16 17 18 MAIN 4 BOARD 19 (3/4) (Page 26) 20 R263 470k R262 47k C250 2.2 R264 2.2k -3.0 3.2 Q207 - Sony HCD-SH2000 | Service Manual - Page 26
HCD-SH2000 5-11. SCHEMATIC DIAGRAM - MAIN BOARD (3/4) (Suffix 11) - • See page 54 for IC Block Diagrams. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 A MAIN BOARD (3/4) 23 24 25 MAIN 6 26 BOARD (4/4) 27 (Page 27) 28 29 30 MAIN 7 BOARD 31 (4/4) 32 (Page 27) HCD-SH2000 26 26 - Sony HCD-SH2000 | Service Manual - Page 27
5-12. SCHEMATIC DIAGRAM - MAIN BOARD (4/4) (Suffix 11) - • See page 54 for IC Block Diagrams. 1 2 3 4 5 6 7 8 HCD-SH2000 9 10 11 12 13 14 15 A MAIN BOARD (4/4) 29 R857 0 27 MAIN 26 6 BOARD 23 R856 0 B (3/4) 28 (Page 26) 24 C662 1016V R658 0 R662 0 R854 0 - Sony HCD-SH2000 | Service Manual - Page 28
HCD-SH2000 Ver. 1.1 5-13. SCHEMATIC DIAGRAM - MAIN BOARD (1/4) (Suffix 12) - • See page 53 for Waveforms. • See page 61 for IC Pin Function LED-BLUE 99 AVCC JL200 1.3 100 IC100 SYSTEM CONTROL IC100 R5F3650KBDFA 12 0 JL150 50 0 ) AC-DET S/ D-FAST DBFB FAN-EN FAN-LOCK 49 26 71 47 69 70 45 75 44 - Sony HCD-SH2000 | Service Manual - Page 29
OCS1_N VDD18 VDD33CR PRTPWR2 OCS2_N NC 10 11 12 13 14 15 16 17 18 3.3 0 3.3 3.3 C311 10 C411 0.1 R327 220 45 R326 220 44 HCD-SH2000 29 29 HCD-SH2000 11 12 13 14 15 15 16 17 18 MAIN 4 BOARD 19 (3/4) (Page 30) 20 R263 470k R262 47k C250 2.2 R264 2.2k -3.0 3.2 Q207 MUTING - Sony HCD-SH2000 | Service Manual - Page 30
27 (Page 31) 28 29 30 MAIN 7 BOARD 31 (4/4) 32 (Page 31) HCD-SH2000 Note 1: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. Note 2: A part of circuit composition of MAIN board (Suffix-12) has been changed in the midway of - Sony HCD-SH2000 | Service Manual - Page 31
5-16. SCHEMATIC DIAGRAM - MAIN BOARD (4/4) (Suffix 12) - • See page 54 for IC Block Diagrams. 1 2 3 4 5 6 7 8 HCD-SH2000 9 10 11 12 13 14 15 A MAIN BOARD (4/4) 29 R857 0 27 MAIN 26 6 BOARD 23 R856 0 B (3/4) 28 (Page 30) 24 C662 1016V R658 0 R662 0 R854 0 - Sony HCD-SH2000 | Service Manual - Page 32
8 9 10 11 12 13 14 15 A B C D E F G H I J HCD-SH2000 DMB21 BOARD (Component side) NC (CHASSIS) MAIN I BOARD CN702 (Page 20) (Suffix 11) (Page 22) ( IC4605 on the DMB21 board cannot exchange with single. When this part on the DMB21 board is damaged, exchange the entire mounted board. - Sony HCD-SH2000 | Service Manual - Page 33
C223 R237 C219 C226 R239 C222 C224 C221 I R115 R113 R112 R255 R2505 R238 R2502 C225 12 1-883-583- (12) 14 HCD-SH2000 15 J HCD-SH2000 33 33 Note: IC102 on the DMB21 board cannot exchange with single. When this part on the DMB21 board is damaged, exchange the entire mounted board. - Sony HCD-SH2000 | Service Manual - Page 34
(CHASSIS) C4622 100p C4623 100p R4833 0 R4834 0 R4867 47 L OUT R OUT C621 0.1 ET001 E (CHASSIS) RESET DATA CLK DATA-SEL HCD-SH2000 34 34 Note: IC4605 on the DMB21 board cannot exchange with single. When this part on the DMB21 board is damaged, exchange the entire mounted board. - Sony HCD-SH2000 | Service Manual - Page 35
HCD-SH2000 Ver. 1.1 5-20. SCHEMATIC DIAGRAM - DMB21 BOARD (2/3) - • See page 53 for Waveforms. • See page 54 for IC Block Diagrams. • See page 61 for IC Pin Function Descriptions. 1 2 3 4 5 exchange with single. When this part on the DMB21 board is damaged, exchange the entire mounted board. - Sony HCD-SH2000 | Service Manual - Page 36
HCD-SH2000 5-21. SCHEMATIC DIAGRAM - DMB21 BOARD (3/3) - • See page 54 for IC Block Diagrams. 1 2 3 4 5 6 7 8 9 A 1k TRG_SW R2502 1k J R254 C213 4.7k 0.01 C216 0.01 C217 100 16V C215 0.01 R256 10k HCD-SH2000 36 36 25 26 27 28 29 30 FIN 31 32 33 34 35 36 C223 0.1 10 11 - Sony HCD-SH2000 | Service Manual - Page 37
Side) - • See page 14 for Circuit Boards Location. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 A B C D E F G H I J HCD-SH2000 DAMP BOARD (Component side) LOW SPEAKER (CHASSIS) C1665 ET1400 L R ,0PE'A1&E 8SE 4Ÿ TB1400 Q1454 R1645 L1407 Q1443 R1668 R1644 - Sony HCD-SH2000 | Service Manual - Page 38
HCD-SH2000 5-23. PRINTED WIRING BOARDS - DAMP BOARD (Conductor Side) - • See page 14 for Circuit Boards Location. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 R1746 R1698 JL1496 R1807 R1806 R1808 R1661 R1660 R1745 R1744 D1412 JL1440 1-883-864- 12 (12) 14 15 HCD-SH2000 38 38 - Sony HCD-SH2000 | Service Manual - Page 39
CN1401 14P NC 1 RESONANCE 2 /AMP-RESET 3 /AMP-OTW 4 /AMP-SD-SLOW 5 AMP-CLK 6 D-GND 7 FAN-LOCK 8 FAN-DRIVE 9 DBFB 10 /AMP-SD-FAST 11 JL1426 JL1567 JL1407 JL1408 JL1409 JL1410 JL1411 JL1412 JL1413 JL1414 JL1415 AC-DET 12 10V 23 20 DAMP 14 BOARD 21 (2/4) (Page 40) 22 19 HCD-SH2000 39 39 - Sony HCD-SH2000 | Service Manual - Page 40
25. SCHEMATIC DIAGRAM - DAMP BOARD (2/4) - • See page 54 for IC Block Diagrams. A DAMP BOARD B (Page 42) C D E F G H I J DAMP HCD-SH2000 (4/4) BOARD (1/4) (Page 39) 1 15 25 14 21 24 19 20 22 23 2 3 DAMP BOARD (2/4) 2 353 455 521 444 -41 -43.2 -52.8 -47.4 IC B/D IC406 - Sony HCD-SH2000 | Service Manual - Page 41
68k R1621 68k R1681 10k R1683 68k HCD-SH2000 Ver. 1.1 8 9 10 11 12 13 14 15 LOW SPEAKER L R 4.7 330k C1582 R1645 SAF, EA E2, E51, MX, MY 100 100 100 100 Q1454 DC PROTECTION 2SC3052EF-T1-LEF 13.3 13.3 JL1471 0 Q1443 0 DC PROTECTION 2SC3052EF-T1-LEF 100k R1668 Q1455 DC - Sony HCD-SH2000 | Service Manual - Page 42
0 C1473 0.1 R1473 C1491 D1415 R1474 4.7k R1480 1k DBFB-FR D1430 MC2838-T112-1 FAN-LOCK FAN-DRIVE D1435 MC2838-T112-1 2.9 Q1451, Q1441, Q1439, Q1458, Q1453, Q1476 FAN MOTOR DRIVE 0.1 C1580 0.1 CN1404 3P 3 JL1484 2 JL1483 1 FAN+ FANFAN+ M891 DC FAN SMPS FAN HCD-SH2000 42 42 - Sony HCD-SH2000 | Service Manual - Page 43
HCD-SH2000 Ver. 1.1 5-28. PRINTED WIRING BOARDS - DISPLAY BOARD - • See page 14 for Circuit Boards Location. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 11 10 CN900 Q907 JR JR907 LP900 1-883-869- 13 (CHASSIS) (13) H K VOLUME BOARD NO1002 (Page 45) I J HCD-SH2000 43 43 - Sony HCD-SH2000 | Service Manual - Page 44
HCD-SH2000 5-29. SCHEMATIC DIAGRAM - DISPLAY BOARD - • See page 54 for IC Block Diagrams. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 A B C D E F G H I J DISPLAY BOARD FL901 FLUORESCENT INDICATOR TUBE E+3.3V SIRCS IC982 REMOTE CONTROL SIGNAL RECEIVER IC982 PNA4823M03S0 VCC OUT IR GND - Sony HCD-SH2000 | Service Manual - Page 45
HCD-SH2000 Ver. 1.1 5-30. PRINTED WIRING BOARDS - VOLUME BOARD - • See page 14 for Circuit Boards Location. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 11 12 DVD/SAT JL1094 S1012 GAME R1023 R1027 H 13 P 1-883-871- (13) VOLUME LED BOARD CN1290 (Page 49) I J HCD-SH2000 45 45 - Sony HCD-SH2000 | Service Manual - Page 46
HCD-SH2000 5-31. SCHEMATIC DIAGRAM - VOLUME BOARD - 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 A B C D E F G H I J VOLUME BOARD K DISPLAY BOARD CN900 (Page 44) O BUTTON Page 50) SIRCS +3.3V E+3.3V FL-DRIVER-CS FL-DRIVER-DATA FL-DRIVER-CLK LED GND -VG DGND LED+13.5V HCD-SH2000 46 46 - Sony HCD-SH2000 | Service Manual - Page 47
HCD-SH2000 Ver. 1.1 5-32. PRINTED WIRING BOARDS - BUTTON, USB BOARD - • See page 14 for Circuit Boards Location. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 JR1254 1 JL1289 JL1271 LP1250 3 N BUTTON LED BOARD CN1280 (Page 49) 14 31 O VOLUME BOARD NO1001 (Page 45) J HCD-SH2000 47 47 - Sony HCD-SH2000 | Service Manual - Page 48
USB B+5V 11 D-B 12 D+B 13 USB B GND MAIN C BOARD (2/4) CN300 (Page 25) (Suffix 11) (Page 29) (Suffix 12) 11 12 13 14 15 F G H I J HCD-SH2000 N BUTTON LED BOARD CN1280 (Page 50) BUTTON BOARD D1251 SLI-325URT31WR R1250 JL1250 1k S1251 S1253 SEARCH S1255 GROOVE S1257 PRESET EQ S1258 REC - Sony HCD-SH2000 | Service Manual - Page 49
HCD-SH2000 Ver. 1.1 5-34. PRINTED WIRING BOARDS - VOLUME LED, BUTTON LED AND TUNER BOARD - • See page 14 for Circuit Boards Location. • : Uses unleaded solder. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 A B TUNER BOARD (Component side) TUNER BOARD (Conductor side) ANTENNA FM/AM C 3 1 - Sony HCD-SH2000 | Service Manual - Page 50
R1605 0 N BUTTON BOARD NO1251 (Page 48) BUTTON LED BOARD CN1280 3P LED+13.5V 1 Q5 2 3 JL1299 JL1298 R1280 560 D1280 1L0352V22F3MIT02 JL1297 ANTENNA FM/AM D1603 MC2840-T112-1 D1602 MC2840-T112-1 D1601 MC2840-T112-1 I CN1602 3P JL1610 FM 1 JL1609 AM 2 JL1608 AM 3 J HCD-SH2000 50 50 - Sony HCD-SH2000 | Service Manual - Page 51
BOARDS - AUDIO-IN BOARD - • See page 14 for Circuit Boards Location. 5-37. SCHEMATIC DIAGRAM - AUDIO-IN BOARD - HCD-SH2000 Ver. 1.1 1 2 3 4 5 6 1 2 3 4 5 6 7 8 A A B B C D AUDIO-IN BOARD 1-883-868- 13 (13) JL1202 3 1 C1201 C1200 R1201 R1200 JL1205 E JL1200 H R1204 R1205 - Sony HCD-SH2000 | Service Manual - Page 52
HCD-SH2000 Ver. 1.1 5-38. PRINTED WIRING BOARDS - MIC BOARD - • See page 14 for Circuit Boards Location. • 1 2 3 4 5 6 7 : Uses unleaded solder. 8 D BOARD NO1250 MIC GND 2 A+9V 1 JL1303 C1322 C1323 (Page 48) D1302 0.1 1000p MC2840-T112-1 14 MIC IN E HCD-SH2000 52 52 15 15 - Sony HCD-SH2000 | Service Manual - Page 53
) 12.27 MHz 170 mV/DIV, 82 nsec/DIV 0.2 Vp-p - TUNER Board - 4 IC1602 qk (X1) 32.8 kHz 82 mVp-p 60 mV/DIV, 30 Pssec/DIV HCD-SH2000 - MAIN Board - 1 IC100 qa (XC-OUT) 87.41 kHz 98.7 mVp-p 34 mV/DIV, 30 Pssec/DIV 2 IC100 qd (X-OUT) 290 mVp-p 8 MHz 280 mV - Sony HCD-SH2000 | Service Manual - Page 54
HCD-SH2000 • IC Block Diagrams IC101 S-80829CNNB-B8OT2G (MAIN BOARD (3/4)) OUT 1 VDD 2 + - VREF 4 VSS 3 NC IC500 R2A15216FP (MAIN BOARD (4/4)) TV IN-R NO_USE PC IN-R DPLR/SURR DPLL/ - Sony HCD-SH2000 | Service Manual - Page 55
IC111 MM1661JHBE (DMB21 BOARD (2/3)) VO 1 NC 2 GND 3 CN 4 CURRENT LIMITTER DRIVER REFERENCE BIAS THERMAL SHUTDOWN 8 VIN 7 NC 6 NC 5 CONT HCD-SH2000 IN1+ OPIN1+ OPIN1OPOUT1 SVCC VREF OPIN2+ OPIN2OPOUT2 REGVCC PVCC1 DO1+ IC201 FAN8036L (DMB21 BOARD (3/3)) 48 47 46 45 44 43 FIN (GND) - Sony HCD-SH2000 | Service Manual - Page 56
HCD-SH2000 IC4601 PCM1808PWR (DMB21 BOARD (1/3)) BCK 8 SDO 9 MOD0 10 MOD1 11 FMT 12 Serial Interface Mode/ Format Control x1/64 Decimation Filter with High Pass Filter - Sony HCD-SH2000 | Service Manual - Page 57
(DMB21 BOARD (1/3)) SYSTEM CLOCK SYSTEM CLOCK MANAGER BCK 1 DATA 2 LRCK 3 DGND 4 NC 5 VCC (5V) 6 POWER SUPPLY AUDIO SERIAL PORT SERIAL CONTROL PORT 4x/8x OVERSAMPLING DIGITAL FILTER & FUNCTION CONTROL ENHANCED MULTILEVEL 21 DGND 20 TDMI 19 OFMT0 18 OFMT1 17 OWL0 16 OWL1 15 RDY HCD-SH2000 57 - Sony HCD-SH2000 | Service Manual - Page 58
HCD-SH2000 IC4608 TC7WH157FK (DMB21 BOARD (1/3)) A1 B2 Y3 GND 4 EN G A Y B Y 8 VCC 171 ST 161 SELECT 5Y VDD IC901 PT6324-LQ (DISPLAY BOARD) GND OSC K2 K1 - Sony HCD-SH2000 | Service Manual - Page 59
HCD-SH2000 IC1406, IC1407, IC1408, IC1409 IRS2092STRPBF (DAMP BOARD (2/4)) VAA 1 GND 2 IN- 3 COMP 4 6V UV DETECT 20.4V 16 CSH 15 VB 14 HO 13 VS 12 VCC CSD 5 CHARGE/ DISCHARGE VSS 6 PROTECTION CONTROL HV LEVEL SHIFT HV LEVEL SHIFT DEAD TIME SD DT 11 LO 20.4V LOW SIDE CS 10 COM 9 - Sony HCD-SH2000 | Service Manual - Page 60
HCD-SH2000 IC1602 RS5B800-0002E2 (TUNER BOARD) VDD X2 X1 CP1 GND 1 VDDRF 2 VDD CP2 3 FM Antenna FRF1 4 FM LNA GNDRF 5 ARF1 6 ARF2 7 AM Antenna AM LNA AM TUNE LOSC 20 19 18 17 VDD Filter AGC AMP ADC AGC AMP AMP ADC Digital Signal Process Digital Mixer FM Demodulator - Sony HCD-SH2000 | Service Manual - Page 61
HCD-SH2000 • IC Pin Function Descriptions MAIN BOARD (1/4) IC100 R5F3650KBDFA (SYSTEM CONTROL) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 Pin Name I/O Description FL-DATA O Serial data output signal to FL Driver, PT6324 FL-CLK O Serial data clock signal - Sony HCD-SH2000 | Service Manual - Page 62
HCD-SH2000 Pin No. 52 53 54 55 56 57 58 59 60 61 62 63 64 ) Unused Digital Amp Reset Pin Digital Amp Shutdown Protection Detect on Amplifier Pin. "L": Protect on' Protection Detect on power supply Pin. "L": Protect on' Unused Unused Resonance Protection Detection Pin Unused DSP IC: Data signal for - Sony HCD-SH2000 | Service Manual - Page 63
HCD-SH2000 DMB21 BOARD (2/3) IC101 CXD9968R (LE) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 signal output terminal Not used I/O Two-way serial data bus terminal Not used I Serial data input from the system controller O Chip select signal output to the flash ROM O Serial data output to the flash ROM I - Sony HCD-SH2000 | Service Manual - Page 64
HCD-SH2000 signal input from the system controller O Communication initialization request acknowledge signal output to the system controller - Not used 3V) O Component video (Y) signal output terminal Not used O Component video (Pb/Cb) signal output terminal Not used O Component video (Pr/ - Sony HCD-SH2000 | Service Manual - Page 65
parts list. • Abbreviation E2 : 120 V AC area in E model E51 : Chilean and Peruvian models EA : Saudi Arabia model MX : Mexican model MY : Malaysia model SAF : South African model 6-1. MAIN SECTION #1 10 HCD-SH2000 Ver. 1.1 The components -01 PLATE, SONY Remark Ref. No. 8 9 10 Part No. 4-275 - Sony HCD-SH2000 | Service Manual - Page 66
HCD-SH2000 6-2. FRONT PANEL SECTION (1) not supplied (DISPLAY board) not supplied 52 supplied (AUDIO-IN board) not supplied (VOLUME LED board) not supplied 56 Ref. No. 51 52 53 54 55 Part No. Description X-2581-185-1 3-087-053-01 1-829-021-51 2-895-507-01 A-1820-972-A KNOB VOLUME, ASSY - Sony HCD-SH2000 | Service Manual - Page 67
6-3. BACK PANEL SECTION HCD-SH2000 #1 101 #2 #1 #1 M891 M891 not supplied not supplied not supplied (TUNER board) Ref. No. 101 0 M891 #1 #2 Part No. 4-275-644-01 1-855-006-11 7-685-647-71 7-685-646-71 Description COVER, FAN FAN, DC SCREW +BVTP 3X10 TYPE2 IT-3 SCREW +BVTP - Sony HCD-SH2000 | Service Manual - Page 68
HCD-SH2000 Ver. 1.1 6-4. CHASSIS SECTION not supplied #3 not supplied 151 159 (SAF, EA) 153 #1 161 not supplied 159 not supplied not supplied #2 not supplied Ref. No. 151 152 153 154 155 Part No. Description A-1820-978-A 1-828-328-51 3-077-331-01 A-1820-980-A A-1820-965-A DAMP BOARD, - Sony HCD-SH2000 | Service Manual - Page 69
HCD-SH2000 6-5. CDM SECTION #1 not supplied #1 201 (including MS-214 board) not supplied (MS bending it in the same form as that before replacement. not supplied #1 Ref. No. 201 202 203 204 205 Part No. A-1114-646-A 4-245-653-01 1-828-252-51 3-087-599-01 2-634-618-31 Description Remark MD - Sony HCD-SH2000 | Service Manual - Page 70
HCD-SH2000 Ver. 1.1 AUDIO-IN BUTTON BUTTON LED SECTION 7 ELECTRICAL PARTS LIST Note: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some - Sony HCD-SH2000 | Service Manual - Page 71
HCD-SH2000 Ver. 1.1 BUTTON LED DAMP Ref. No. Part No. Description < RESISTOR > Remark R1280 1-257-173-91 METAL CHIP 560 5% 20% 16V 20% 16V C1482 1-164-933-11 CERAMIC CHIP 220PF 10% 50V Ref. No. Part No. Description C1483 1-164-933-11 CERAMIC CHIP 220PF 10% C1484 1-164-933-11 CERAMIC CHIP - Sony HCD-SH2000 | Service Manual - Page 72
HCD-SH2000 Ver. 1.1 DAMP Ref. No. C1543 C1544 C1545 C1546 Part No. 1-100-623-91 1-100-623-91 1-100- 50V 5% 250V (E2, E51, MX, MY) 20% 50V 5% 250V (E2, E51, MX, MY) Ref. No. Part No. Description Remark C1656 1-100-597-91 CERAMIC CHIP 0.1uF 10% 25V C1665 1-114-754-91 MYLAR 0.01uF 5% 250V C1666 - Sony HCD-SH2000 | Service Manual - Page 73
HCD-SH2000 Ver. 1.1 DAMP Ref. No. Part No. Description < IC > Remark IC1400 IC1401 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA2026 2SC3052EF-T1-LEF KTC3203Y-AT 2SC3052EF-T1-LEF Ref. No. Part No. Description Remark Q1444 8-729-620-07 TRANSISTOR 2SC3052EF-T1-LEF Q1445 Q1446 Q1447 Q1448 - Sony HCD-SH2000 | Service Manual - Page 74
HCD-SH2000 Ver. 1.1 DAMP Ref. No. Part No. Description R1476 1-216-833-11 METAL 1/16W 5% 1/16W 0.5% 1/16W 0.5% 1/16W 5% 1/16W 0.5% 1/10W 0.5% 1/16W 0.5% 1/10W 0.5% 1/16W Ref. No. Part No. Description R1538 1-218-869-11 METAL CHIP 8.2K R1539 1-208-695-11 METAL CHIP 3.3K R1540 1-218-869-11 METAL - Sony HCD-SH2000 | Service Manual - Page 75
HCD-SH2000 Ver. 1.1 DAMP DISPLAY Ref. No. Part No. Description R1608 1-216- 5% 1/10W 5% 1/10W 5% 1/2W 5% 1/2W 5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W Ref. No. Part No. Description R1710 1-216-837-11 METAL CHIP 22K R1711 1-216-847-11 METAL CHIP 150K R1715 1-216-833-11 METAL CHIP - Sony HCD-SH2000 | Service Manual - Page 76
HCD-SH2000 Ver. 1.1 DISPLAY DMB21 Ref. No. C902 C907 C908 C915 Part No. 1-114-868-11 1-100-597 SHORT CHIP 0 JR922 1-216-296-11 SHORT CHIP 0 JR923 1-216-864-11 SHORT CHIP 0 Ref. No. Part No. Description < COIL > Remark L900 1-412-541-41 INDUCTOR 220uH < TRANSISTOR > Q900 Q901 Q902 Q904 Q906 - Sony HCD-SH2000 | Service Manual - Page 77
HCD-SH2000 Ver. 1.1 DMB21 Ref. No. Part No. Description Remark C144 C145 C146 C149 1-100-567-81 10% 16V 10% 10V C620 1-107-820-81 CERAMIC CHIP 0.1uF 16V Ref. No. C621 C622 C623 C1504 Part No. 1-107-820-81 1-107-820-81 1-107-820-81 1-162-960-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC - Sony HCD-SH2000 | Service Manual - Page 78
HCD-SH2000 Ver. 1.1 DMB21 Ref. No. Part No. Description < FERRITE BEAD > Remark FB108 on the DMB21 board cannot exchange with single. When these parts on the DMB21 board are damaged, exchange the entire mounted board. 78 Ref. No. Part No. Description R155 1-216-295-91 SHORT CHIP 0 R156 - Sony HCD-SH2000 | Service Manual - Page 79
HCD-SH2000 Ver. 1.1 DMB21 MAIN Ref. No. Part No. Description R1192 1-218-990-81 SHORT CHIP 0 R1193 0.1uF 10% 25V Note 1: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. Note 2: A part of circuit composition of MAIN board (Suffix-12) - Sony HCD-SH2000 | Service Manual - Page 80
HCD-SH2000 Ver. 1.1 MAIN Ref. No. C237 C238 C239 Part No. 1-137-765-21 1-100-597-91 1-100-597 CHIP 22PF 5% 50V Note 1: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. Note 2: A part of circuit composition of MAIN board (Suffix-12) - Sony HCD-SH2000 | Service Manual - Page 81
HCD-SH2000 Ver. 1.1 MAIN Ref. No. C777 C778 C780 C782 C783 Part No. 1-124-779-00 1-124-779-00 1-162 IC BD00GC0WEFJ-SE2 Note 1: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. Note 2: A part of circuit composition of MAIN board (Suf - Sony HCD-SH2000 | Service Manual - Page 82
HCD-SH2000 Ver. 1.1 MAIN Ref. No. Part No. Description IC805 8-759-909-71 IC BA4558F Remark < JACK > J500 1-794-981-11 JACK, 1/16W (SAF) 5% 1/16W (EA) 5% 1/16W (E2, E51, MX) Note: Refer to the servicing notes "MAIN BOARD DISCRIMINATION" (page 5) for how to distinguish SUFFIX-11 and SUFFIX-12. - Sony HCD-SH2000 | Service Manual - Page 83
HCD-SH2000 Ver. 1.1 MAIN Ref. No. R290 R294 Part No. 1-218-990-81 1-218-967 1/16W 5% 1/16W 5% 1/16W 5% 1/16W 5% 1/16W 5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W Ref. No. Part No. Description R675 1-218-959-11 METAL CHIP 3.3K R676 1-216-833-11 METAL CHIP 10K R677 1-216-845-11 METAL CHIP 100K - Sony HCD-SH2000 | Service Manual - Page 84
HCD-SH2000 Ver. 1.1 MAIN MIC Ref. No. Part No. Description R817 1-218-990-81 SHORT 1/10W 0.5% 1/10W 5% 1/16W 5% 1/16W 5% 1/10W 5% 1/16W 5% 1/16W 5% 1/16W 5% 1/10W Ref. No. Part No. Description C1309 1-100-597-91 CERAMIC CHIP 0.1uF 10% C1310 1-100-597-91 CERAMIC CHIP 0.1uF 10% C1311 1-126- - Sony HCD-SH2000 | Service Manual - Page 85
HCD-SH2000 Ver. 1.1 MIC MS-214 TUNER USB VOLUME Ref. No. Part No. Description R1313 1-216-839-11 METAL 1-257-173-91 METAL CHIP 560 5% 1/3W L1601 * L1602 * L1603 1-457-998-11 COIL, AM ANTENNA 1-400-973-21 INDUCTOR (EMI FERRITE) 1-400-973-21 INDUCTOR (EMI FERRITE) VOLUME BOARD < CAPACITOR - Sony HCD-SH2000 | Service Manual - Page 86
HCD-SH2000 Ver. 1.1 VOLUME VOLUME LED Ref. No. C1001 C1005 C1007 C1008 Part No. 1-100-597-91 1-124-584-00 1-100- 25V 20% 6.3V 10% 25V 10% 25V 5% 1/10W 5% 1/3W 5% 1/3W 5% 1/3W Ref. No. Part No. Description R1005 1-216-819-11 METAL CHIP 680 Remark 5% 1/10W R1006 1-216-821-11 METAL CHIP 1K R1007 - Sony HCD-SH2000 | Service Manual - Page 87
207 1-828-300-11 WIRE (FLAT TYPE) (7 CORE) FL901 1-483-367-11 VACUUM FLUORESCENT DISPLAY 0 M891 1-855-006-11 FAN, DC Ref. No. Part No. Description HCD-SH2000 Ver. 1.1 Remark Note: If wire (flat type) is replaced, install it after bending it in the same form as that before replacement. 87 - Sony HCD-SH2000 | Service Manual - Page 88
HCD-SH2000 REVISION HISTORY Checking the version allows you to jump to the revised page. Also, clicking the version at the top of the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2011.06 New 1.1 2011.09 Addition of South African model
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
 |
 |
SERVICE MANUAL
Sony Corporation
Published by Sony EMCS (Malaysia) PG Tec
HCD-SH2000
MINI HI-FI COMPONENT SYSTEM
9-890-576-02
2011I08-1
©
2011.09
E Model
Ver. 1.1
2011.09
• HCD-SH2000 is the tuner, USB, CD
and ampli
fi
er section in FST-SH2000/LBT-SH2000.
• “WALKMAN” and “WALKMAN” logo are registered trademarks of Sony Corporation.
• MPEG Layer-3 audio coding technology and patents licensed from Fraunhofer IIS and
Thomson.
• Windows Media is either a registered trademark or trademark of Microsoft Corporation in
the United States and/or other countries.
•
This product contains technology subject to certain intellectual property rights of Microsoft.
Use or distribution of this technology outside of this product is prohibited without the ap-
propriate license(s) from Microsoft.
SPECIFICATIONS
Ampli
fi
er section
The following are measured at AC 120 V -
240 V, 50/60 Hz
Power output (rated):
High channel
300 W + 300 W (at 4
Ω
, 1 kHz,
1% THD)
Low channel
300 W + 300 W (at 4
Ω
, 100 Hz,
1% THD)
RMS output power (reference):
High channel
500 W + 500 W (per channel at
4
Ω
, 1 kHz)
Low channel
500 W + 500 W (per channel at
4
Ω
, 100 Hz)
Inputs
PC (AUDIO IN) L/R, TV (AUDIO IN) L/R,
DVD/SAT (AUDIO IN) L/R, GAME
(AUDIO IN) L/R
Voltage 2 V, impedance 47 k
Ω
MIC
Sensitivity 1 mV, impedance 10 k
Ω
A,
B port: Type A
USB section
Supported bit rate
MP3 (MPEG 1 Audio Layer-3):
32 kbps – 320 kbps, VBR
WMA: 48 kbps – 192 kbps
AAC: 48 kbps – 320 kbps
Sampling frequencies
MP3 (MPEG 1 Audio Layer-3):
32 kHz/44.1 kHz/48 kHz
WMA: 44.1 kHz
AAC: 44.1 kHz
Transfer speed
Full-Speed
Supported USB device
Mass Storage Class
Maximum current
500 mA
Disc player section
System
Compact disc and digital audio system
Laser Diode Properties
Emission Duration: Continuous
Laser Output*: Less than 44.6
μ
W
* This output is the value measurement
at a distance of 200 mm from the
objective lens surface on the Optical
Pick-up Block with 7 mm aperture.
Frequency response
20 Hz – 20 kHz
Signal-to-noise ratio
More than 90 dB
Dynamic range
More than 88 dB
Tuner section
FM stereo, FM/AM superheterodyne tuner
Antenna:
FM lead antenna
AM loop antenna
FM tuner section
Tuning range
87.5 MHz – 108.0 MHz (50 kHz step)
AM tuner section
Tuning range
AR, E2, E51 and MX models:
530 kHz – 1,710 kHz (10 kHz step)
531 kHz – 1,710 kHz (9 kHz step)
MY model:
530 kHz – 1,610 kHz (10 kHz step)
531 kHz – 1,602 kHz (9 kHz step)
General
Power requirements
AC 120 V – 240 V, 50/60 Hz
Power consumption
320 W
Dimensions (w/h/d) (excl. speakers)
(Approx.)
510 mm × 235 mm × 420 mm
Mass (excl. speakers) (Approx.)
10.0 kg
Supplied accessories
Remote control (1)
R6 (Size AA) batteries (2)
FM lead/AM loop antenna (1)
Speaker foot (8)
Design and speci
fi
cations are subject to
change without notice.
• Abbreviation
E2
: 120V AC area in E model
E51
: Chilean and Peruvian models
EA
: Saudi Arabia model
MX
: Mexican model
MY
: Malaysia model
SAF
: South African model
CD
Section
CD Mechanism
Type
CDM86B-DVBU101
Optical Pick-up
Name
KHM-313CAB/C2NP