Sony PS-DJ9000 Service Manual

Sony PS-DJ9000 - Stereo Turntable System Manual

Get Sony PS-DJ9000 - Stereo Turntable System PDF manuals and user guides View all Sony PS-DJ9000 manuals
Add to My Manuals
Save this manual to your list of manuals

Sony PS-DJ9000 manual content summary:

  • Sony PS-DJ9000 | Service Manual - Page 1
    SERVICE MANUAL Ver 1.1 2001. 06 PS-DJ9000 US Model AEP Model UK Model E Model This set is the stereo turntable in PMPK-DJ9000. Motor and Platter Drive system Motor Platter Speeds Wow and flutter Signal to noise ratio SPECIFICATIONS Direct drive quartz 3 phase 8 pole Brushless DC motor Aluminum
  • Sony PS-DJ9000 | Service Manual - Page 2
    SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, "metallized" knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
  • Sony PS-DJ9000 | Service Manual - Page 3
    instruction manual. 1 2 3 4 5 6 7 8 9 0 qa 1 POWER ON/OFF switch 2 Spindle 3 Strobo lamp 4 START/STOP button 5 Slip mat 6 Platter 7 TARGET LIGHT and release button The TARGET LIGHT allows you to see the position of the stylus use by qualified service technicians only. wd Tonearm wf PITCH ADJ.
  • Sony PS-DJ9000 | Service Manual - Page 4
    direction of the arrow. 4 Insert the headshell into the end of the tonearm. Turn the locking ring in the direction permanent damage to the stylus and record. 1 Make sure the turntable is level. 2 Set line 8 When you use the supplied cartridge, turn the counterweight counterclockwise one full rotation
  • Sony PS-DJ9000 | Service Manual - Page 5
    . knob to the center position. When the turntable is turned on, the platter speed is automatically Attach the protective cover onto the cartridge to prevent damage to the stylus. 2 Press Bx START/STOP. with mark 0 are critical for safety. Replace only with part number specified. • U : B+ Line. • V :
  • Sony PS-DJ9000 | Service Manual - Page 6
    PS-DJ9000 2-2. SCHEMATIC DIAGRAM - MAIN SECTION - • See Page 8 and 9 for Printed Wiring Boards. (Page 7) (Page 7) L003, L004, L005, L006: Exchange all the four when even this one diode breaks in either one. (Page 7) (Page 7) 6 6 (Page 7) SLIDE SW (Page 7)
  • Sony PS-DJ9000 | Service Manual - Page 7
    2-3. SCHEMATIC DIAGRAM - MOTOR SECTION - • See Page 10 for Printed Wiring Boards. (Page 6) (Page 6) (Page 6) PS-DJ9000 (Page 6) 7 7
  • Sony PS-DJ9000 | Service Manual - Page 8
    PS-DJ9000 2-4. PRINTED WIRING BOARD - MAIN SECTION - • See Page 5 for Circut Boards Location. • 8 1 7 E 14 8 1 7 14 8 14 8 7 1 7 1 7 G B (Page 9) (Page 10) A (Page 10) F (Page 9) E (Page 9) 8 8 There are a few cases that the part isn't mounted in model is printed on diagram.
  • Sony PS-DJ9000 | Service Manual - Page 9
    LED BOARD LD06 LD05 LD03 LD04 STROBO LAMP LED SW BOARD F (Page 8) There are a few cases that the part isn't mounted in model is printed on diagram. 9 9 PS-DJ9000 US POWER TRANSFORMER 4 C (Page 10) POWER TRANSFORMER 4 * 5 * POWER TRANSFORMER 4 E, MX C (Page 10) AEP, UK C (Page 10) * NOT
  • Sony PS-DJ9000 | Service Manual - Page 10
    PS-DJ9000 2-6. PRINTED WIRING BOARD - MOTOR SECTION - • See Page 5 for Circut Boards Location. • See Page 7 for Schematic Diagram. MOTOR BOARD A (Page 8) • Semiconductor Location Ref. No. Location D1 A-4
  • Sony PS-DJ9000 | Service Manual - Page 11
    SECTION 3 EXPLODED VIEW • Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Accessories and packing materials are
  • Sony PS-DJ9000 | Service Manual - Page 12
    Ref. No. 51 53 54 54 56 57 58 59 60 61 62 63 63 Part No. Description A-4412-592-A MOTOR BOARD, COMPLETE 4-231-231-01 TERGET (LIGHT) KNOB (US,MX,E) 4-231-230-01 ARM ASSY, TONE Remark 1-251-931-11 CARTRIDGE (INCLUDING STYLUS) 4-231-511-01 SHELL ASSY, HEAD 4-231-239-01 WEIGHT ASSY, COUNTER 4-231
  • Sony PS-DJ9000 | Service Manual - Page 13
    -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable • Items marked "*" are not stocked since they are seldom required for routine service. Some
  • Sony PS-DJ9000 | Service Manual - Page 14
    MAIN MOTOR Ref. No. R44 R45 R46 R47 R48 Part No. Description 1-247-847-11 CARBON 1-247-847-11 CARBON 1-247-847 1-126-964-11 ELECT 0.47uF 0.047uF 4.7uF 10uF 25V 50V 50V 20.00% 50V Ref. No. C19 Part No. Description 1-126-964-11 ELECT Remark 10uF 20.00% 50V C20 1-126-768-11 ELECT C30 1-126
  • Sony PS-DJ9000 | Service Manual - Page 15
    POWER RELAY TONE ARM Ref. No. Part No. Description PAUSE/START BOARD Remark Ref. No. Part No. SW10 1-570-245- (E,MX TONE ARM BOARD MISCELLANEOUS 57 0 62 0 T1 0 T1 0 T1 1-251-931-11 CARTRIDGE 4-231-234-01 SOCKET ASSY AC 1-435-743-11 TRANSFORMER, POWER (US,MX) 1-435-744-
  • Sony PS-DJ9000 | Service Manual - Page 16
    PS-DJ9000 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
1
SERVICE MANUAL
STEREO TURNTABLE SYSTEM
US Model
AEP Model
UK Model
E Model
PS-DJ9000
SPECIFICATIONS
Motor and Platter
Drive system
Direct drive quartz
Motor
3 phase 8 pole Brushless DC motor
Platter
Aluminum die-cast
Diameter 332 mm (13.1 inches)
Weight 750 g (1.85 lbs)
Speeds
33
and 45 rpm
1
/
3
Wow and flutter
Less than 0.15 % (WRMS)
Signal to noise ratio
More than 55 dB (DIN-B)
Tone Arm
Type
Static balanced S-shaped tonearm with
detachable headshell
Effective arm length
230 mm
Overhang
15 mm
Usable cartridge weight
4 g (min.) to 10 g (max.)
General
Power requirements
U.S.A. and Mexico: 120 V AC, 60 Hz
European countries: 220 - 230 V AC,
50/60 Hz
Other countries: 110 - 120 V/
220 - 240 V AC, 50/60 Hz
Power consumption
15 W
Dimensions
Approx. 450
×
152
×
352 mm (17
×
11
/
16
5
×
13
in) (w/h/d)
11
/
16
3
/
4
Mass
10 kg (22 lbs)
Supplied Accessories
Platter (2)
Slip mat (2)
Dust cover (with hinges) (2)
Counterweight (2)
Cartridge and headshell (2)
45 adaptor (2)
Audio cord (with ground wire) (2)
AC power cord (2)
Design and specifications are subject to change without
notice.
Replacing the Cartridge
The life expectancy of the stylus tip is about 500 hours.
To maintain optimum sound quality and prevent
damage to your records, we recommend replacing the
cartridge
before the end of this time duration.
Obtain a replacement
cartridge
from your
Sony dealer.
This set is the stereo turntable in
PMPK-DJ9000.
9-92
9
-
55
3-1
2
2001
F
0200-1
© 2001.
6
Sony Corporation
Home
Audio Company
Shinagawa Tec Service Manual Production Group
Ver 1.
1
2001. 0
6