Sony STR-DA9000ES Service Manual
Sony STR-DA9000ES - Fm Stereo/fm-am Receiver Manual
 |
View all Sony STR-DA9000ES manuals
Add to My Manuals
Save this manual to your list of manuals |
Sony STR-DA9000ES manual content summary:
- Sony STR-DA9000ES | Service Manual - Page 1
STR-DA90ESG SERVICE MANUAL US Model Canadian Model Australian Model Manufactured under TOTAL HARMONIC DISTORTION With 8-ohm loads both channels driven, from 20 - 20,000 Hz; rated 120 watts per channel minimum RMS power, with no more Continued on page 2 - MICROFILM FM STEREO/FM-AM RECEIVER - Sony STR-DA9000ES | Service Manual - Page 2
4.5 µV Stereo: 38.3 dBf, 45 µV Usable sensitivity 11.2 dBf, 2 µV (IHF) S/N Mono: 76 dB tuning in any AM station, turn off the receiver. While holding down the PRESET + button, press antenna (1) • Remote commander (remote) (1) (remote for US and Canadian models: RM-H501) (Remote for Australian - Sony STR-DA9000ES | Service Manual - Page 3
Section 59 4-10. Schematic Diagram - AMP/OUTPUT Section 63 4-11. Printed Wiring Boards - AMP/OUTPUT Section - ....... 67 5. EXPLODED VIEWS 75 6. ELECTRICAL PARTS LIST 79 SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set - Sony STR-DA9000ES | Service Manual - Page 4
This section is extracted from instruction manual. SECTION 1 GENERAL - 4 - - Sony STR-DA9000ES | Service Manual - Page 5
SECTION 2 DISASSEMBLY Note: Follow the disassembly procedure in the numerical order given. CASE 1 three screws (M 3 × 8) 1 two screws (M 3 × 8) 2 1 three screws (M 3 × 8) 3 case 2 1 two screws (M 3 × 8) REAR PANEL SECTION 1 connector (CNV902) 3 two screws (BVTP 3 × 6) 1 connector (CNE910) - Sony STR-DA9000ES | Service Manual - Page 6
TUNER/AUDIO/SPTM BOARD, FRONT PANEL SECTION 1 connector (CNE211) 1 connector (CNS210) 8 front panel section 7 four screws (BVTP 3 × 8) 1 five connectors ( ) CND621, CNE601, 602, CNV615, 616 2 SPTM board 3 AUDIO board 7 three screws (BVTP 3 × 8) INPUT BOARD 3 claw 2 five screws (BVTP 3 × 8) 1 - Sony STR-DA9000ES | Service Manual - Page 7
SECTION 3 ELECTRICAL ADJUSTMENTS ON SCREEN SECTION OSD ADJUSTMENT Setting: S. VIDEO SG VIDEO output terminal SET Monitor TV Vectroscope VIDEO 1 S terminal INITIALIZATION OF THE MICROCOMPUTER KEEP the DISPLAY , OPEN/CLOSE buttons depressed simultaneously and then turn the POWER switch ON. - Sony STR-DA9000ES | Service Manual - Page 8
R665 + R016 2 - R715 R765 3 [AMP BOARD] (COMPONENT SIDE) FRONT Lch FRONT Rch CENTER REAR Lch REAR Rch Connecting point R615 R665 R016 R715 R765 Adjustment part RV601 RV651 RV001 RV701 RV751 Reading on Digital voltmeter 20 mV 20 mV 20 mV 20 mV 20 mV FRONT Rch R665 1 2 3 RV651 R668 C987 - Sony STR-DA9000ES | Service Manual - Page 9
(INDEX) O LED drive signal output terminal "H": LED on (for INDEX indicator) 11 DVSS - Ground terminal 12 LED-CE O LED drive signal output terminal "H": LED on (IC101, 102) 27 SIRCS1 I Sircs signal input from the remote control receiver (IC104) 28 AVCC - Power supply terminal (+5V) 29 - Sony STR-DA9000ES | Service Manual - Page 10
(IC3413) 49 U-DATA I/O Serial data in/out with the master controller (IC3413) 50 U-CLOCK I Serial data reading clock signal input from the master controller (IC3413) 51 HIFI/ES I Setting terminal for the destination (fixed at "H") 52 AUBUS-IN I Audio bus signal input terminal 53 - Sony STR-DA9000ES | Service Manual - Page 11
MB90T673PF-G-BND (ON SCREEN DISPLAY CONTROLLER) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Not used (open) I Receive data input from the FL drive controller (IC105) O Transmit data output to the FL drive controller (IC105) O Reset signal output to the RC controller (IC815) "L": reset - - Sony STR-DA9000ES | Service Manual - Page 12
Function - Not used (open) - Not used (open) - Not used (open) I Audio bus signal input terminal I Video signal exist/without "H": exist I Sircs signal input from the remote control receiver (IC104) I Detection signal input of the video system O Audio bus signal output terminal O Scart P8 - Sony STR-DA9000ES | Service Manual - Page 13
output to the on screen display controller (IC809) 11 RS O Data reception ready signal output to the on screen display controller (IC809) 12 P37 O Not Transmit data output terminal Not used (fixed at "L") 28 RXD I Receive data input terminal Not used (fixed at "L") 29 UCLK O Clock signal - Sony STR-DA9000ES | Service Manual - Page 14
clock signal input terminal Not used (open) O Not used (fixed at "L") O Sircs signal output terminal O Test terminal Not used (open) I Reset signal input from the on screen display controller (IC809) "L": reset I Sub system clock input terminal Not used (fixed at "L") O Sub system clock output - Sony STR-DA9000ES | Service Manual - Page 15
I Oscillation on/off control signal input terminal "H": on (fixed at "H") 5 DATA I Test terminal Not used (fixed at "L") 6 MCK I Test terminal Not used (fixed at "L") 7 MLTB I Test terminal Not used (fixed at "L") 8 IDST O Test terminal Not used (open) 9 IDCK O Test terminal Not used - Sony STR-DA9000ES | Service Manual - Page 16
terminal Not used (fixed at "L") I PDO out control signal input terminal "L": on O Mute control signal output terminal "H": mute on I Test terminal Not used (fixed at "L") O Test terminal Not used (open) O Test terminal Not used (open) O Digital out signal output terminal (serial data stream - Sony STR-DA9000ES | Service Manual - Page 17
terminal Not used (open) - Ground terminal O Test terminal Not used (open) O Test terminal Not used (open) O Test terminal Not used (open) O Test terminal Not used (open) O Test terminal Not used (open) I Test terminal Not used (fixed at "L") I Test terminal Not used (fixed at "L") - Ground - Sony STR-DA9000ES | Service Manual - Page 18
PROCESSOR) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 external RAM device Not used (open) O O I Serial data reading clock signal input from the master controller (IC3413) I Master clock signal input terminal (3MHz) - Power supply terminal (+5V) (for internal - Sony STR-DA9000ES | Service Manual - Page 19
Pin No. 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 Pin Name SDO1 SDO0 SVCC SCKT WST SCKR QGND QVCC SGND WSR SDI1 SDI0 DSO DSI DSCK DR MD7 MD6 MD5 MD4 DGND MD3 MD2 MD1 DVCC MD0 DGND GPIO3 GPIO2 GPIO1 GPIO0 MRD MWR MRAS MCAS I/O Function - Sony STR-DA9000ES | Service Manual - Page 20
) (for internal logic) 10 QGND - Ground terminal (for internal logic) 11 MA11 O 12 MA10 O Address signal output to the S-RAM (IC3411) MA0 O 26 SCK I Serial data reading clock signal input from the master controller (IC3413) 27 EXTAL I Master clock signal input terminal (3MHz) 28 - Sony STR-DA9000ES | Service Manual - Page 21
bus buffer) I/O I/O General digital signal processor in/out terminal Not used (open) I/O I/O General digital signal processor in/out with the master controller (IC3413) O Write strobe signal output to the S-RAM (IC3411) O Read strobe signal output to the S-RAM (IC3411) O Chip select signal - Sony STR-DA9000ES | Service Manual - Page 22
• DIGITAL BOARD IC3413 MB90641APF-G-104-BND (MASTER CONTROLLER) Pin No. Pin Name I/O 1 RFERR I 2 RFRESET O 3 STOP I 4 RDATA I 5 WDATA O 6 DIRLAT O 7 DIRCLK O 8 DIRERR I 9 ANG/DIG O 10 A/DINT O 11 Vss - 12 HREQ I 13 SS O 14 MOSI O 15 RESET O 16 MISO I - Sony STR-DA9000ES | Service Manual - Page 23
O 61 DATAIN I 62 AUTSTOP I 63 STEREO I 64, 65 N.C. - 66 HIFI/ES I 67 PROTEC I 68 VIDEO-A O 69 VIDEO-B O 70 VIDEO-E O 71 VIDEO- controller (IC105) Serial data signal input from the FL drive controller (IC105) Communication request signal output to the FL drive controller - Sony STR-DA9000ES | Service Manual - Page 24
• Circuit Boards Location PTA board AMP board PTB board MOTOR TM board SENSOR board AC board SP TM board MEMORY board S VIDEO board CBV board VIDEO board HP board SP SW board F. VIDEO board CONNECTOR board DISPLAY board BAL (B) board TUNER board INPUT board AUDIO board DIGITAL board VOL - Sony STR-DA9000ES | Service Manual - Page 25
• Waveforms - DISPLAY SECTION - 1 IC105 ^¢ 4 MHz 5 IC3402, 3403 0 48.5 MHz 9 IC3108 4 IC3425 1, 3 3.1 MHz 3.9 Vp-p 0.6 Vp-p 5.1 Vp-p - DIGITAL SECTION - 2 IC3401 0 49 MHz 6 IC3407 1 6.1 MHz 0 IC3107 4 12.4 MHz 0.6 Vp-p 4.9 Vp-p 4.6 Vp-p 3 IC3401-3403 #• IC3410 %¡ IC3414 7 IC3417 6 3.1 - Sony STR-DA9000ES | Service Manual - Page 26
!£ IC3412 @¶ 3.1 MHz !¶ IC3413 *™ 47 MHz 5 Vp-p @¡ IC805 9 14.29 4.7 Vp-p 5.4 Vp-p !¢ IC3410 @¶ 3.1 MHz !• IC3308 %§ 18.52 MHz @™ IC810 0 520.8 kHz 4.9 Vp-p 6 Vp-p 0.8 Vp-p !∞ IC3311 @¡ 3.7 MHz - VIDEO SECTION - !ª IC809 ^¢ 4 MHz @£ IC813 0 520.8 kHz 5.3 Vp-p 3.6 Vp-p 0.8 Vp-p !§ - Sony STR-DA9000ES | Service Manual - Page 27
- Sony STR-DA9000ES | Service Manual - Page 28
- Sony STR-DA9000ES | Service Manual - Page 29
- Sony STR-DA9000ES | Service Manual - Page 30
- Sony STR-DA9000ES | Service Manual - Page 31
- Sony STR-DA9000ES | Service Manual - Page 32
- Sony STR-DA9000ES | Service Manual - Page 33
- Sony STR-DA9000ES | Service Manual - Page 34
- Sony STR-DA9000ES | Service Manual - Page 35
- Sony STR-DA9000ES | Service Manual - Page 36
- Sony STR-DA9000ES | Service Manual - Page 37
CONTROLLER DECIMATION FILTER CALIBRATION SRAM SERIAL OUTPUT INTERFACE 28 VREF+ 27 VREF26 VCOMR 25 AINR+ 24 AINR23 VA 22 AGND 21 BGND 20 TEST DITHER 5 6 7 8 FIR2 FIR3 L.I.P (X8) CLOCK GENERATOR 3rd order NOISE SHAPER 9 10 11 12 13 14 15 23 R1(-) 22 VSS PLM 21 R1(+) 20 VSS2 16 17 18 - Sony STR-DA9000ES | Service Manual - Page 38
IC3516 LC7535M-TP (DIGITAL BOARD) L 5dB IN 1 L CT1 2 L CT2 3 L 5dB OUT 4 L 1dB IN 5 L 1dB OUT 6 L VM 7 VEE 8 S9 VDD 10 VSS 11 LEVEL SHIFT CONTROL +L LATCH +D D SHIFT RESISTER 22 R 5dB IN 21 R CT1 20 R CT2 19 R 5dB OUT 18 R 1dB IN 17 R 1dB OUT 16 R VM 15 VCC 14 CE - Sony STR-DA9000ES | Service Manual - Page 39
YIN 1 CIN 2 VIN 3 AVCC 4 FSCO 5 VBLK 6 VCC 7 EXS 8 XS 9 HSYNC 10 VSYNC 11 TO BLOCK 4FSC CLOCK OSC ANALOG SWITCH VIDEO SIGNAL GENERATOR SERIAL INPUT CONTROL NTSC/PAL SIGNAL GENERATOR OUTPUT CONTROL DISPLAY MEMORY CONTROL EXHSYN 12 EXVSYN 13 GND 14 H/V SEPARATOR VRAM TO BLOCK CGROM DOT CLOCK - Sony STR-DA9000ES | Service Manual - Page 40
3 4 56 7 8 9 10 H L L H C AMP Y AMP PLL-B GND 11 B/W DET 12 24 23 22 21 20 19 GND (STAGE) 18 17 VCC 16 15 14 BOARD) VCC 8Q 8D 7D 7Q 6Q 6D 5D 20 19 18 17 16 15 14 13 (ENABLE) 5Q C 12 11 Q D C OE D Q C OE Q D C OE D Q C OE Q D C OE Q D C - Sony STR-DA9000ES | Service Manual - Page 41
601, 651 STK350-230 (INPUT BOARD) CONTROL SUB L1 1 L2 2 L3 3 L4 4 L COM1 5 L5 6 L6 7 L COM2 8 L7 9 L8 10 L COM3 11 VEE 12 CE 13 DI 14 CL CIRCUIT PROTECTOR REG DRIVE PRE DRIVE PRE DRIVE DRIVE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 MUTE + VOUT1 - VOUT1 COMP1 MF1 IN1 GND IN2 NF2 COMP2 - VOUT2 + - Sony STR-DA9000ES | Service Manual - Page 42
's Color SECTION 5 EXPLODED VIEWS • Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and - Sony STR-DA9000ES | Service Manual - Page 43
53 54 Part No. Description 4-991-378-01 PANEL, FRONT (US, Canadian) 4-991-378-71 PANEL, FRONT (Australian) 4-942-568-01 EMBLEM (NO.5), SONY X-4948-618 SWITCH (A) BLOCK, TOUCH 92 1-475-109-31 SWITCH (B) BLOCK, TOUCH 93 1-775-084-11 WIRE (FLAT TYPE) (9 CORE) 94 4-980-639-01 KNOB (R14) 69 70 - Sony STR-DA9000ES | Service Manual - Page 44
Australian) 4-947-010-01 SCREW, FEEDER FIXED 4-991-373-01 PANEL (STR), BACK (US) 4-991-373-11 PANEL (STR), BACK (Canadian) Ref. No. * 161 * 162 * 163 * 163 * 164 Part No. Description Remark 4-991-373-21 PANEL (STR), BACK (Australian) A-4398-801-A S VIDEO BOARD, COMPLETE A-4398-799-A VIDEO BOARD - Sony STR-DA9000ES | Service Manual - Page 45
-01 FOOT (F50180S) 3-905-609-01 SCREW (TRANSISTOR) A-4398-783-A AMP BOARD, COMPLETE Remark Ref. No. * 205 206 * 207 * 208 Part No. Description 1-666-310-11 TUNER BOARD 1-773-001-11 WIRE (FLAT TYPE) (15 CORE) A-4398-782-A INPUT BOARD, COMPLETE A-4398-806-A DIGITAL BOARD, COMPLETE Remark - 78 - - Sony STR-DA9000ES | Service Manual - Page 46
marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS BOARD, COMPLETE (Australian) 1-533-293-11 HOLDER, FUSE 7-685-872-09 SCREW +BVTT 3X8 (S) Ref. No. Part No. Description < FUSE > Remark ! - Sony STR-DA9000ES | Service Manual - Page 47
. No. C011 C012 C013 Part No. Description 1-107-597-11 CERAMIC 1-107-597-11 CERAMIC 1-107-597-11 CERAMIC 22PF 22PF 22PF Remark 10% 500V 10% 500V 10% 500V C020 C022 C023 C608 C610 1-102-110-00 FILM 1-126-935-11 ELECT 1-126-965-11 ELECT 1-126-051-11 ELECT 1-107-597-11 CERAMIC 220PF 470uF 22uF - Sony STR-DA9000ES | Service Manual - Page 48
BAL (A) Ref. No. Part No. Description Remark Ref. No. Part No. R655 1-249-421-11 CARBON 2.2K 5% 1/4W Description < CONNECTOR > Remark R656 R657 ! R660 ! R661 ! R662 1-249-437-11 CARBON 1-249-411-11 CARBON 1-249-393-11 CARBON 1-249-393-11 CARBON 1-249-393-11 CARBON 47K 5% 330 5% 10 - Sony STR-DA9000ES | Service Manual - Page 49
BAL (A) BAL (B) CBV CONNECTOR DIGITAL Ref. No. Part No. Description < RESISTOR > Remark Ref. No. Part No. Description < RESISTOR > Remark R140 R141 R142 R143 1-249-429-11 CARBON 1-249-429-11 CARBON 1-249-411-11 CARBON 1-249-411-11 CARBON 10K 5% 10K 5% 330 5% 330 5% < VARIABLE - Sony STR-DA9000ES | Service Manual - Page 50
20% 16V 50V 50V 50V C3423 1-165-319-11 CERAMIC CHIP 0.1uF 50V Ref. No. Part No. Description Remark C3424 1-165-319-11 CERAMIC CHIP 0.1uF 50V C3425 1-163-251-11 CERAMIC CHIP 100PF 5% 50V C3426 1-163-251-11 CERAMIC CHIP 100PF 5% 50V C3427 1-165-319-11 CERAMIC CHIP 0.1uF 50V C3428 1-163-263 - Sony STR-DA9000ES | Service Manual - Page 51
CERAMIC CHIP 0.1uF 50V C3568 1-110-339-11 MYLAR 220PF 5% 50V C3569 1-110-339-11 MYLAR 220PF 5% 50V C3570 1-165-319-11 CERAMIC CHIP 0.1uF 50V C3571 1-165-319-11 CERAMIC CHIP 0.1uF 50V Ref. No. C3572 C3573 C3574 C3575 Part No. Description 1-110-339-11 MYLAR 1-126-048-81 ELECT 1-126-048-81 - Sony STR-DA9000ES | Service Manual - Page 52
INDUCTOR 1-410-397-21 FERRITE BEAD INDUCTOR < FILTER > FL3301 1-233-866-11 FILTER, BAND PASS < IC > IC3101 IC3102 IC3103 IC3104 IC3105 8-759-636- IC M5218AFP IC M5218AFP IC M5218AFP IC M5218AFP IC M5218AFP Ref. No. Part No. Description IC3511 IC3512 IC3513 IC3514 IC3515 8-759-636-55 IC 8- - Sony STR-DA9000ES | Service Manual - Page 53
073-00 METAL CHIP 10K 5% Remark Ref. No. R3114 R3115 R3116 R3117 R3118 Part No. Description 1-216-025-00 METAL GLAZE 1-216-025-00 METAL GLAZE 1- R3317 R3318 R3319 R3320 1-216-073-00 METAL CHIP 1-216-049-11 METAL GLAZE 1-216-049-11 METAL GLAZE 1-216-083-00 METAL CHIP 1-216-043-00 METAL GLAZE - Sony STR-DA9000ES | Service Manual - Page 54
Part No. Description R3334 1-216-065-00 METAL CHIP 4.7K R3335 1-216-065-00 METAL CHIP 4.7K R3336 1-216-049-11 METAL GLAZE 1K R3337 1-216-061-00 METAL CHIP 3.3K R3338 1-216-049-11 R3401 1-216-057-00 METAL CHIP 2.2K 5% R3402 1-216-049-11 METAL GLAZE 1K 5% R3403 1-216-097-00 METAL CHIP 100K 5% - Sony STR-DA9000ES | Service Manual - Page 55
10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. Part No. Description R3542 1-216-065-00 METAL CHIP 4.7K 5% R3543 1-216-065-00 METAL 8.2K 5% R3574 1-216-295-00 CONDUCTOR, CHIP (2012) R3575 1-216-049-11 METAL GLAZE 1K 5% R3576 1-216-057-00 METAL CHIP 2.2K 5% R3577 1-216 - Sony STR-DA9000ES | Service Manual - Page 56
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. Part No. Description R3667 1-216-073-00 METAL CHIP 10K 5% R3668 1-216-295-00 CONDUCTOR, C109 C110 1-163-251-11 CERAMIC CHIP 1-163-251-11 CERAMIC CHIP 1-126-795-11 ELECT 1-165-319-11 CERAMIC CHIP 1-126-795-11 ELECT 100PF 100PF 10uF - Sony STR-DA9000ES | Service Manual - Page 57
C126 C127 C128 C129 C130 C132 C133 C142 Part No. Description 1-165-319-11 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 1-165-319-11 CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF Remark 50V 50V 50V 50V 50V 1-126-786-11 ELECT 47uF 20% 16V 1-165-319 - Sony STR-DA9000ES | Service Manual - Page 58
DISPLAY F.VIDEO HP INPUT Ref. No. Part No. Description R137 1-216-049-11 METAL GLAZE 1K R138 1-216-049-11 METAL GLAZE 1K ! R139 1-249-385-11 CARBON 2.2 R140 1-216-073-00 METAL CHIP 10K R144 1-216-049-11 METAL GLAZE 1K R145 R146 R147 R148 R149 1-216-049-11 METAL GLAZE 1-216-073-00 METAL - Sony STR-DA9000ES | Service Manual - Page 59
20% 16V 100uF 20% 25V 100uF 20% 25V C980 1-126-023-11 ELECT C983 1-126-023-11 ELECT 100uF 100uF 20% 25V 20% 25V < CONNECTOR > CNE620 1-770-966-11 PIN, CONNECTOR (PCB) (V TYPE) 6P Ref. No. Part No. Description Remark CNE621 1-770-967-11 PIN, CONNECTOR (PCB) (V TYPE) 7P CNE622 1-770-969 - Sony STR-DA9000ES | Service Manual - Page 60
R203 R204 R205 Part No. Description 1-249-441-11 CARBON 1-249-441-11 CARBON 1-249-416-11 CARBON 1-247-897-11 CARBON R206 R207 R208 R210 R211 1-249-437-11 CARBON 1-249-441-11 CARBON 1-247-807-31 CARBON 1-249-417-11 CARBON 1-249-417-11 CARBON R212 R213 R214 R216 R220 1-249-417-11 CARBON 1-249 - Sony STR-DA9000ES | Service Manual - Page 61
CARBON 10K 5% 1/4W R8013 1-249-429-11 CARBON 10K 5% 1/4W R8014 1-249-429-11 CARBON 10K 5% 1/4W R8018 1-247-807-31 CARBON 100 5% 1/4W * 1-666-313-11 MOTOR TM BOARD C914 Part No. Description 1-666-303-11 PTB BOARD ********** 1-533-293-11 HOLDER, FUSE < CAPACITOR > 1-126-947 - Sony STR-DA9000ES | Service Manual - Page 62
R884 R886 R891 Part No. Description < RESISTOR > 1-249-429-11 CARBON 1-247-807-31 CARBON 1-249-419-11 CARBON 1-249-429-11 CARBON 1-249-417-11 CARBON 1-249-403-11 CARBON 1-249-403-11 CARBON 1-249-403-11 CARBON 1-249-409-11 CARBON 1-249-409-11 CARBON 1-249-409-11 CARBON 1-249-409-11 CARBON 1-249 - Sony STR-DA9000ES | Service Manual - Page 63
TM (B) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R8057 R8058 R8059 R8060 1-249-413-11 CARBON 1-247-807-31 FILM 0.022uF 5% 50V < TEST PIN > < CONNECTOR > * TP801 1-560-062-00 PIN, CONNECTOR 4P < VIBRATOR > X801 1-567-819-11 VIBRATOR, CERAMIC (4MHz) X805 - Sony STR-DA9000ES | Service Manual - Page 64
SP TM (B) TUNER VIDEO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R026 R030 R031 1-249-435-11 CARBON 1-249-425-11 CARBON 1-249-429-11 CARBON 33K 5% 1/4W 4.7K 5% 1/4W 10K 5% 1/4W FE201 1-693-351-11 ENCAPSULATED COMPONENT (Australian) < RESISTOR > ! R032 - Sony STR-DA9000ES | Service Manual - Page 65
Part No. Description 1-162-282-31 CERAMIC C848 C849 C850 C851 C852 1-126-960-11 ELECT 1-136-162-00 FILM 1-136-157-00 FILM 1-164-159-11 CERAMIC 1-126-967-11 ELECT C853 1-126-960-11 Ref. No. IC811 IC813 IC814 IC823 J808 J809 J810 J811 Part No. Description 8-759-061-95 IC SN761200 8-759-341-79 - Sony STR-DA9000ES | Service Manual - Page 66
1-475-138-11 REMOTE COMMANDER (RM-VR101) (Australian) 1-475-324-11 RAY-CATCHER UNIT (WITH PLUG) 1-501-374-11 ANTENNA, LOOP 1-501-594-11 ANTENNA (FM) (Australian) 3-810-765-11 MANUAL, COMMONNESS INSTRUCTION 3-860-901-11 MANUAL, INSTRUCTION (ENGLISH) 3-860-901-21 MANUAL, INSTRUCTION (FRENCH) (Canadian - Sony STR-DA9000ES | Service Manual - Page 67
STR-DA90ESG 9-920-924-11 Sony Corporation Home A&V Products Company - 100 - 97H057028-1 Printed in Singapore © 1997. 8 Published by General Engineering Dept. (Shibaura) - Sony STR-DA9000ES | Service Manual - Page 68
STR-DA90ESG SERVICE MANUAL US Model Canadian Model Australian Model SUPPLEMENT-1 File this supplement with the service manual. Subject: Change of AMP Board (SPM-98017) - Sony STR-DA9000ES | Service Manual - Page 69
STR-DA90ESG 1. PRINTED WIRING BOARD • Semiconductor Location Ref. No. Location D001 A-4 D002 A-3 D003 H-2 D011 A-3 D603 F-1 D653 E-4 D703 G-1 D753 G-3 D971 C-3 D972 C-3 D973 B-3 D991 C-2 D992 C-2 Q001 H-3 Q002 H-3 Q005 H-1 - Sony STR-DA9000ES | Service Manual - Page 70
2. SCHEMATIC DIAGRAM STR-DA90ESG - 3 - - 4 - - Sony STR-DA9000ES | Service Manual - Page 71
service. 11 ELECT 1-117-856-11 ELECT 22PF 10% 22PF 10% 15000uF 20% 15000uF 20% 500V 500V 71V 71V Q010 Q011 Q012 Q601 8-729-119-79 TRANSISTOR 2SC2785-FEK 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA 8-729-140-82 TRANSISTOR 2SA988-PAFAEA 8-729-119-76 TRANSISTOR 2SA1175-HFE STR-DA90ESG AMP Ref. No. Part
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
 |
 |
FM STEREO/FM-AM RECEIVER
MICROFILM
US Model
Canadian Model
Australian Model
Audio power specificaitons
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION
With 8-ohm loads both channels
driven, from 20 - 20,000 Hz; rated 120
watts per channel minimum RMS
power, with no more than 0.05 % total
harmonic distortion from 250 miliwatts
to rated output (US model only).
Amplifier section
POWER OUTPUT
Stereo mode
8 ohms 20 Hz - 20 kHz,
THD 0.05 %,
120 W + 120 W
Surround mode
(8 ohms at 1 kHz, THD
0.05 %)
Front: 120 W + 120 W
Center*: 120 W
Rear*: 120 W + 120 W
*
No sound may be out-
put when using certain
sound sources and/or
sound mode settings.
SPECIFICATIONS
SERVICE MANUAL
STR-DA90ESG
Manufactured under license from Dolby
Laboratories Licensing Corporation.
“Dolby,” the double-D symbol
a
, “AC-3” and
“Pro Logic” are trademarks of Dolby Labo-
ratories Licensing Corporation.
Dynamic power
165 W + 165 W, 8 ohms
output (US,
280 W + 280 W, 4 ohms
Canadian model)
Harmonic
Less than 0.05 %
distortion at
(Direct Pass)
rated output
Frequency
PHONO: RIAA
response
equalization curve
±0.5 dB
CD, TAPE, DAT/MD,
LD, DVD, TV/DBS,
VIDEO: 10 Hz - 50
kHz
dB
(Direct Pass)
Input (ANALOG)
Sensitivity
Impedance
S/N
PHONO
2.5 mV
50
75 dB*
kilohms
(A, 2.5 mV)
CD, TAPE,
DAT/MD,
VIDEO,
200 mV
50
82 dB*
LD/DVD,
kilohms
(A, 200mV)
TV/DBS
+0.5
–2
Input (DIGITAL)
Sensitivity
Impedance
S/N
LD/DVD
–
75 ohms
100 dB
AC-3 RF
(A, 20 kHz LPF)
LD/DVD
–
75 ohms
100 dB
COAXIAL
(A, 20 kHz LPF)
LD/DVD,CD,
DAT/MD,
–
–
100 dB
TV/DBS,
(A, 20 kHz LPF)
OPTICAL
* '78 IHF
Outputs
REC OUT:
DAT/MD, TAPE
Voltage: 200 mV
Impedance: 1 kilohms
AUDIO OUT:
VIDEO 1, 2
Voltage: 200mV
Impedance: 1 kilohms
PRE OUT
Voltage: 2V
Impedance: 1 kilohms
PHONES: Accepts low
and high impedance
headphones
BASS BOOST
+6 dB at 70 Hz
– Continued on page 2 –