Toro 20332 Operation Manual
Toro 20332 - Recycler 190CC Personal Pace Lawn Mower Manual
 |
UPC - 021038203324
View all Toro 20332 manuals
Add to My Manuals
Save this manual to your list of manuals |
Toro 20332 manual content summary:
- Toro 20332 | Operation Manual - Page 1
22in Recycler® Lawn Mower Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up Model No. 20352-Serial No. 312000001 and Up Form No. 3371-667 Rev A Operator's Manual Replacement parts are available from an Authorized Service Dealer or at www.shoptoro.com. - Toro 20332 | Operation Manual - Page 2
-behind rotary lawn mowers and the B71.1 specifications of the American National Standards Institute in effect at the time of production. Read and understand the contents of this manual before you start the engine. The safety alert symbol (Figure 2) is used to alert you to potential personal injury - Toro 20332 | Operation Manual - Page 3
make any adjustments or repairs with the engine running. Disconnect the spark plug wire and ground against engine to prevent unintended starting. • Check grass catcher components and the discharge guard frequently and replace with manufacturer's recommended parts, when necessary. • Mower blades are - Toro 20332 | Operation Manual - Page 4
instructions before servicing or performing maintenance. 4. Cutting/dismemberment hazard of hand or foot, mower blade-stay away from moving parts. 5. Cutting/dismemberment hazard of hand or foot, mower blade-do not operate up and down slopes; operate side to side on slopes; stop the engine before - Toro 20332 | Operation Manual - Page 5
the Engine with Oil No Parts Required Procedure Important: Your mower does not come with oil in the engine, but it does come with a bottle of oil. Before starting the engine, fill the engine with oil. Max. fill: 20 oz. (0.59 l), type: SAE 30 detergent oil with an API service classification of - Toro 20332 | Operation Manual - Page 6
Changing the Engine Oil. Product Overview 3 Charging the Battery No Parts Required Procedure Electric-start models only Refer to Charging the Battery in the Maintenance section. Figure 5 1. Handle 8. Cutting height lever (4) 2. Blade control bar 9. Air filter 3. Ignition key (electric-start - Toro 20332 | Operation Manual - Page 7
is cold. Wipe up spills. • Do not handle gasoline when smoking or around an open flame or sparks. • Store gasoline in an approved fuel container, out of the reach of children. Checking the Engine Oil Level Service Interval: Before each use or daily Note: Max. fill: 20 oz. (0.59 l), type: SAE 30 - Toro 20332 | Operation Manual - Page 8
. Starting the Engine 1. Hold the blade control bar against the handle (Figure 10). CAUTION If the engine has been running, the muffler will be hot and can severely burn you. Keep away from the hot muffler. Adjust the cutting height as desired. Set the front wheels to the same height as the rear - Toro 20332 | Operation Manual - Page 9
new Toro replacement bag. Note: If the mower does not freely roll backward after self-propelling, stop walking, hold your hands in place, and allow the mower to roll a couple of inches (centimeters) forward to disengage the wheel drive. You can also try reaching just under the personal pace handle - Toro 20332 | Operation Manual - Page 10
an open rear discharge area could allow small stones and other similar debris to be thrown in the operator's or bystander's direction and result in serious personal injury or death to the operator or bystanders. Stop the engine and wait for all moving parts to stop before cleaning the bag-on-demand - Toro 20332 | Operation Manual - Page 11
bag is on the mower and the bag-on-demand lever is in the bagging position, move the lever to the recycling position (refer to Operating the Bag-on-Demand Lever). WARNING The blade is sharp; contacting the blade can result in serious personal injury. Stop the engine and wait for all moving parts - Toro 20332 | Operation Manual - Page 12
an object or starts to vibrate, immediately stop the engine, disconnect the wire from the spark plug, and examine the mower for damage. • For best performance, install a new blade before the cutting season begins. • Replace the blade when necessary with a Toro replacement blade. Cutting Grass • Cut - Toro 20332 | Operation Manual - Page 13
from under the mower. • Replace the air filter; replace it more frequently in dusty operating conditions. • Charge the battery for 24 hours (electric-start models only). • Empty the fuel tank before repairs as directed and before annual storage. • Change the engine oil. • Replace the blade or have - Toro 20332 | Operation Manual - Page 14
the air filter cover (Figure 19). 2. Replace the air filter (Figure 19). 3. Install the cover. 1. Dipstick Figure 20 4. Tip the mower onto its side with the air filter up to drain the used oil out through the oil fill tube (Figure 21). Figure 19 Changing the Engine Oil Service Interval: After - Toro 20332 | Operation Manual - Page 15
only a few minutes until the battery is fully charged. Replacing the Fuse Electric-start models only If the battery does not charge or the engine does not run with the electric starter, the fuse may be blown. Replace it with a 40-amp plug-in type fuse. 1. Raise the rear deflector and locate the - Toro 20332 | Operation Manual - Page 16
, or replace it. WARNING The blade is sharp; contacting the blade can result in serious personal injury. Wear gloves when servicing the blade. 1. Refer to Preparing for Maintenance. 2. Tip the mower onto its side with the air filter up. 3. Use a block of wood to hold the blade steady (Figure 25 - Toro 20332 | Operation Manual - Page 17
self-propel drive is out of adjustment, adjust the self-propel drive cable. 1. Loosen the cable support nut (Figure 27). 2. Pull down the cable jacket (toward the mower) until there is no slack in the cable (Figure 27). 3. Tighten the nut on the cable support. Cleaning the Mower Service Interval - Toro 20332 | Operation Manual - Page 18
install the spark plug. 9. Tighten all nuts, bolts, and screws. 10. Charge the battery for 24 hours, then unplug the battery charger an store the mower in an unheated area. If you must store the mower in a heated area, you must charge the battery every 90 days (electric-start models only). WARNING - Toro 20332 | Operation Manual - Page 19
Notes: 19 - Toro 20332 | Operation Manual - Page 20
regular maintenance service or parts, such as filters, fuel, lubricants, oil changes, spark plugs, air filters blade sharpening or worn blades, cable/linkage adjustments, or brake and clutch adjustments • Any product or part which has been altered or misused and requires replacement or repair due to
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
 |
 |
Form No.
3371-667 Rev A
22in Recycler
®
Lawn Mower
Model No. 20332—Serial No. 312000001 and Up
Model No. 20334—Serial No. 312000001 and Up
Model No. 20352—Serial No. 312000001 and Up
Operator's Manual
Replacement parts are available from an Authorized Service Dealer or at www.shoptoro.com.
Introduction
This rotary-blade, walk-behind lawn mower is intended
to be used by residential homeowners. It is designed
primarily for cutting grass on well-maintained lawns
on residential properties. It is not designed for cutting
brush or for agricultural uses.
Read this information carefully to learn how to operate
and maintain your product properly and to avoid injury
and product damage. You are responsible for operating
the product properly and safely.
You may contact Toro directly at www.Toro.com for
product and accessory information, help finding a dealer,
or to register your product.
Whenever you need service, genuine Toro parts,
or additional information, contact an Authorized
Service Dealer or Toro Customer Service and have
the model and serial numbers of your product ready.
Figure 1 identifies the location of the model and serial
numbers on the product.
Figure 1
1.
Model and serial number plate
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has safety
messages identified by the safety alert symbol (Figure 2),
which signals a hazard that may cause serious injury
or death if you do not follow the recommended
precautions.
Figure 2
1.
Safety alert symbol
This manual uses 2 words to highlight information.
Important
calls attention to special mechanical
information and
Note
emphasizes general information
worthy of special attention.
WARNING
CALIFORNIA
Proposition 65 Warning
The engine exhaust from this product
contains chemicals known to the State of
California to cause cancer, birth defects,
or other reproductive harm.
Important:
This engine is not equipped with a
spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate
the engine on any forest-covered, brush-covered, or
grass-covered land. Other states or federal areas
may have similar laws.
This spark ignition system complies with Canadian
ICES-002.
© 2011—The Toro® Company
8111 Lyndale Avenue South
Bloomington, MN 55420
Register at www.Toro.com.
Original Instructions (EN)
Printed in the USA
All Rights Reserved