Viking VIPR161SS Installation Instructions
Viking VIPR161SS Manual
View all Viking VIPR161SS manuals
Add to My Manuals
Save this manual to your list of manuals |
Viking VIPR161SS manual content summary:
- Viking VIPR161SS | Installation Instructions - Page 1
VIKING RANGE burners. See "INSTALL COOKTOP" section on page 8. READ AND SAVE THESE INSTRUCTIONS ! INTENDED FOR ductwork. 8. Do not install this product with the activating switch directly behind a burner or element appliance unless specifically recommended in this manual. All other servicing - Viking VIPR161SS | Installation Instructions - Page 2
high level of air flow of this appliance may effect the gas flame on some types of gas cooktops. This is NORMAL and will cause no harm, but can be corrected by lowering the speed of the blower. All Units 1. Refer to the cooktop installation instructions for dimensions of cooktop, countertop cut-out - Viking VIPR161SS | Installation Instructions - Page 3
VIKING RANGE CORPORATION TAKE MEASUREMENTS (CONTINUED) Downdraft Ventilators Interior Blower Installation SIDE VIEW OF DOWNDRAFT WITH VIDV500 INTERIOR BLOWER 2" 7 be transitioned to 6" round). Three different discharge directions are available with side-toside adjustment for accurate alignment - Viking VIPR161SS | Installation Instructions - Page 4
VIKING RANGE CORPORATION PLAN THE CABINET CUTOUTS Interior Blower Installation Downdraft Ventilators Exterior Blower Installation LEFT SIDE DISCHARGE LEFT SIDE DISCHARGE CENTER LINES OF DUCT CUTOUT 10¼" x 3½" CUTOUT (TYP.) RIGHT SIDE DISCHARGE 241/8" 5½" CENTER LINE OF COUNTER CUTOUT CENTER - Viking VIPR161SS | Installation Instructions - Page 5
VIKING RANGE CORPORATION Downdraft Ventilators PLAN THE WIRING Interior Blower Installation 1. The Interior Downdraft Blower system draws flange of the downdraft with the 3¼" x 10" discharge pointed in the desired direction. 5. Connect motor plug. 6. Replace the gear motor cover and 2 sheet metal - Viking VIPR161SS | Installation Instructions - Page 6
VIKING RANGE CORPORATION Downdraft Ventilators PREPARE THE DOWNDRAFT Exterior Blower Installation The downdraft is shipped use island trim. Rear countertop trim (supplied with island trim) will be used in this installation. E F C C 36" 24" 33" 2-3/4" 1-1/2" 1-1/2" D 48" VGRT * VIPR182RSS - Viking VIPR161SS | Installation Instructions - Page 7
VIKING RANGE CORPORATION Downdraft Ventilators MOUNT THE UNIT All Units 1. Set 3-1/4" x 10" collar is provided for installers who prefer to rivet the ductwork to the unit.This will allow blower to be removed and replaced easily in service situations without disturbing ductwork. 1. Cut hole in - Viking VIPR161SS | Installation Instructions - Page 8
VIKING RANGE CORPORATION Downdraft Ventilators INSTALL ELECTRICAL WIRING Interior Blower Installation ! CAUTION: All electrical wiring should be done by a qualified person(s) in accordance with all applicable codes and standards. 1. Mount a standard wiring box, with 3-pronged receptacle, - Viking VIPR161SS | Installation Instructions - Page 9
VIKING RANGE CORPORATION Downdraft Ventilators INSTALLATION OF REMOTE CONTROL SWITCH WARNING: To reduce the risk of burns or ignition of clothing by reaching across burners, the remote control must be mounted - Viking VIPR161SS | Installation Instructions - Page 10
VIKING RANGE CORPORATION Downdraft Ventilators This page has been left blank intentionally. BACKSIDE OF REMOTE SWITCH TEMPLATE 10 - Viking VIPR161SS | Installation Instructions - Page 11
VIKING RANGE CORPORATION Downdraft Ventilators OPERATION UP / DOWN-----Raises and lowers vent It may be necessary to remove the downdraft blower system from Cleaning the cabinet in order to service components such as the blower motor or air vent mechanism. Use a mild detergent suitable for - Viking VIPR161SS | Installation Instructions - Page 12
Any malfunction caused to Viking ventilation products as a direct result of the use of such equipment is not covered under the Viking warranty. Painted and installation, improper operation or repair or service to the product by anyone other than an authorized Viking Range Corporation service agency - Viking VIPR161SS | Installation Instructions - Page 13
VIKING RANGE CORPORATION VeDnotwilantderuarfst INSTALLATION DE LA SURFACE DE CUISSON". LIRE ET CONSERVER CES INSTRUCTIONS ! DESTINÉ À LA CUISINE DOMESTIQUE SEULEMENT ! AVERTISSEMENT AVERTISSEMENT AFIN DE DIMINUER LES RISQUES D'INCENDIE, D'ÉLECTROCUTION OU DE BLESSURES, SUIVEZ CES DIRECTIVES - Viking VIPR161SS | Installation Instructions - Page 14
VIKING RANGE CORPORATION PRÉPARATION VeDnotwilantderuarfst Veennctaislatrtoésrs Installation du ventilateur intérieur Ce ventilateur encastré est conçu pour évacuer les contaminants INSTALLATION Tous les appareils 1. Consultez les instructions d'installation pour connaître les dimensions de la - Viking VIPR161SS | Installation Instructions - Page 15
VIKING RANGE CORPORATION PRISE DES MESURES (SUITE) Installation du ventilateur intérieur VUE DE CÔTÉ DE LA HOTTE AVEC VENTILATEUR INTÉRIEUR VIDV500 5 cm (2 po) 2" 1" 19,5 c1m1 7 "3 " (7 11/1616po) 2,5 cm (1 po) 8,2 cm (3 11/4 po) 4 3 " 9, - Viking VIPR161SS | Installation Instructions - Page 16
VIKING RANGE CORPORATION VeDnotwilantdeurarfst eVnencatislatrtéosrs PRÉPARATION DU DÉCOUPAGE DE L'ARMOIRE Installation du ventilateur intérieur Installation du ventilateur extérieur SORTIE À GAUCHE SORTIE À GAUCHE LIGNES DE CENTRE DU CDEÉNCTOEURPAGLEINPEOSUORF DCUOCNTDCUUITTOUT TRO10U¼("TxYP3 - Viking VIPR161SS | Installation Instructions - Page 17
VIKING RANGE CORPORATION PRÉPARATION DU CÂBLAGE VeDnotwilantderuarfst Veennctaislatrtoésrs Installation du ventilateur intérieur Installation la sortie de 8,3 x 25,4 cm (3-1/4 x 10 po) tournée dans la direction souhaitée. 5. Branchez la prise du moteur. 6. Replacez le couvercle du moteur et les - Viking VIPR161SS | Installation Instructions - Page 18
VIKING RANGE CORPORATION VeDnotiwlantedurarsft eVnecnatislatrtéosrs PRÉPARATION DE LA HOTTE Installation du ventilateur extérieur La hotte est livrée sans ventilateur. Procurez-vous le ventilateur extérieur modèle VEDV900 ou VEDV1200 et installez la plaque d'é - Viking VIPR161SS | Installation Instructions - Page 19
VIKING RANGE CORPORATION VeDnotwilantderuarfst Veennctaislatrtoésrs INSTALLATION DE L'UNITÉ Tous les modèles 1. Placez la hotte dans l'ouverture.Allongez les brides de nivellement jusqu'au plancher de l'armoire afin que la hotte s' - Viking VIPR161SS | Installation Instructions - Page 20
VIKING RANGE CORPORATION CÂBLAGE ÉLECTRIQUE Installation du ventilateur intérieur ! ATTENTION : Le câblage doit ê Assurez-vous que le cordon est loin de la chaleur dégagée par la surface de cuisson. INSTALLATION DE LA SURFACE DE CUISSON Tous les modèles 1. Alignez la surface de cuisson avec la - Viking VIPR161SS | Installation Instructions - Page 21
VIKING RANGE CORPORATION VeDnotwilantderuarfst Veennctaislatrtoésrs INSTALLATION DE LA TÉLÉCOMMANDE AVERTISSEMENT : Pour réduire les risques de brûlure ou que des vêtements s'enflamment en traversant les brûleurs, la télécommande doit être installée à au moins 10 cm (4 po) des brûleurs de la - Viking VIPR161SS | Installation Instructions - Page 22
VIKING RANGE CORPORATION VeDnotiwlantdeurarfst eVnencatislatrtéosrs Cette page a été laissée en blanc volontairement. ARRIÈRE DU GABARIT DE LA TÉLÉCOMMANDE 22 - Viking VIPR161SS | Installation Instructions - Page 23
VIKING RANGE CORPORATION VeDnotwilantderuarfst Veennctaislatrtoésrs FONCTIONNEMENT HAUT/BAS ---R e l è v e o u abaisse le conduit d'aération. Met Tous les modèles le ventilateur en MARCHE lorsque le conduit est RELEVÉ - Viking VIPR161SS | Installation Instructions - Page 24
Viking directement attribuable à l'utilisation de tels équipements n'est pas couverte par la garantie Viking. installation inadéquate, utilisation inadéquate, réparation ou entretien inadéquats du produit par quiconque autre qu'une agence de réparation ou un représentant agréé de Viking Range - Viking VIPR161SS | Installation Instructions - Page 25
VIKING RANGE CORPORATION Ventiladores 4 pulg. (10 cm) de los quemadores. Consulte la sección "INSTALE LA ESTUFA" en la página 32. LEA Y GUARDE ESTAS INSTRUCCIONES para el tamaño del elemento de la superficie. INSTALADOR: Conserve este manual para que lo use el inspector eléctrico y el propietario. - Viking VIPR161SS | Installation Instructions - Page 26
VIKING RANGE CORPORATION Ventiladores de tiro descendente PLANEACIÓN Instalación del ventilador interior de 48 pulg. [120 cm]) • Conecte los conductos y el sistema eléctrico. • Instale la estufa. INSTALACIÓN TÍPICA SUPERFICIE DEL GABINETE PARTE SUPERIOR DE LA CHIMENEA ESTUFA CUBIERTA DEL - Viking VIPR161SS | Installation Instructions - Page 27
VIKING RANGE CORPORATION TOME MEDIDAS (CONTINUACIÓN) Instalación del ventilador interior VISTA LATERAL DEL TIRO DESCENDENTE CON EL VENTILADOR INTERIOR VIDV500 2 pulg. (5 cm) 1 pulg. (2.54 cm) 7 11/16 - Viking VIPR161SS | Installation Instructions - Page 28
VIKING RANGE CORPORATION Ventiladores de tiro descendente PLANEE LOS CORTES DEL GABINETE Instalación del ventilador interior Instalación del ventilador exterior DESCARGA DEL LADO IZQUIERDA LÍNEAS CENTRALES DEL - Viking VIPR161SS | Installation Instructions - Page 29
VIKING RANGE CORPORATION Ventiladores de tiro descendente PLANEE EL CABLEADO ELÉCTRICO Instalación del ventilador interior Instalación del ventilador exterior 1. El sistema de ventilación de tiro descendente - Viking VIPR161SS | Installation Instructions - Page 30
VIKING RANGE CORPORATION Ventiladores de tiro descendente PREPARE EL TIRO DESCENDENTE Instalación del ventilador exterior El tiro descendente se envía sin ventilador. Compre un ventilador exterior modelo - Viking VIPR161SS | Installation Instructions - Page 31
VIKING RANGE CORPORATION Ventiladores de tiro descendente MONTE LA UNIDAD Todas las unidades 1. ÓN, REBORDE ORIENTADO HACIA AFUERA SOPORTE DE NIVELACIÓN, REBORDE ORIENTADO HACIA ADENTRO INSTALE EL SISTEMA DE CONDUCTOS Instalación del ventilador interior Instalación del ventilador exterior - Viking VIPR161SS | Installation Instructions - Page 32
VIKING RANGE CORPORATION Ventiladores de tiro descendente INSTALE EL CABLEADO ELÉCTRICO Instalación del ventilador interior el cable eléctrico esté tendido lejos del calor generado por la estufa. INSTALE LA ESTUFA Instalación del ventilador exterior ! PRECAUCIÓN: Una o más personas calificadas - Viking VIPR161SS | Installation Instructions - Page 33
VIKING RANGE CORPORATION Ventiladores de tiro descendente INSTALACIÓN DEL INTERRUPTOR DEL CONTROL REMOTO ADVERTENCIA: Para reducir el riesgo de quemadoras o de que se incendie la ropa al - Viking VIPR161SS | Installation Instructions - Page 34
VIKING RANGE CORPORATION Ventiladores de tiro descendente Esta página se ha dejado en blanco intencionalmente. PARTE POSTERIOR DE LA PLANTILLA DEL CONMUTADOR REMOTO 34 - Viking VIPR161SS | Installation Instructions - Page 35
VIKING RANGE CORPORATION Ventiladores de tiro descendente FUNCIONAMIENTO ARRIBA/ABAJO -- Sube y baja el sistema de ventilación. Enciende el ventilador Todas las unidades cuando el sistema está ARRIBA y - Viking VIPR161SS | Installation Instructions - Page 36
el servicio de garantía, comuníquese con el distribuidor a quien le compró el producto, con un agente de servicio autorizado por Viking Range Corporation o con Viking Range Corporation. Proporcione el modelo y el número de serie y la fecha de la compra original. Para obtener el nombre de su agencia
VIKING RANGE CORPORATION
Downdraft Ventilators
WARNING
READ AND SAVE THESE INSTRUCTIONS
WARNING
TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR
INJURY TO PERSONS, OBSERVE THE FOLLOWING:
1.
Use this unit only in the manner intended by the manufacturer.
If you have questions, contact the manufacturer at the address
or telephone number in the warranty.
2.
Before servicing or cleaning unit, switch power off at service panel
and lock the service disconnecting means to prevent power from
being switched on accidentally.When the service disconnecting
means cannot be locked, securely fasten a prominent warning
device, such as a tag, to the service panel.
3.
Installation work and electrical wiring must be done by a qualified
person(s) in accordance with all applicable codes and standards,
including fire-rated construction codes and
standards.
4.
Sufficient air is needed for proper combustion and exhausting
of gases through the flue (chimney) of fuel burning equipment
to prevent backdrafting. Follow the heating equipment
manufacturer’s guideline and safety standards such as those
published by the National Fire Protection Association (NFPA),
and the American Society for Heating, Refrigeration and
Air Conditioning Engineers (ASHRAE), and the local code
authorities.
5. When cutting or drilling into wall or ceiling, do not damage
electrical wiring and other hidden utilities.
6. Ducted fans must always be vented to the outdoors.
7.
To reduce the risk of fire, use only metal ductwork.
8. Do not install this product with the activating switch directly
behind a burner or element. Minimum distance between the
switch and the edge of the burner should be 4 inches.
9.
Loose-fitting or hanging clothing should never be worn when
operating this appliance. They may be ignited by burners/
elements on cooktop.
10. Children should not be left alone or unattended in the area
where this appliance is in use.
11. This unit must be grounded.
TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:
a) Never leave surface units unattended at high settings.
Boilovers cause smoking and greasy spillovers that may
ignite. Heat oils slowly on low or medium settings.
b) Always turn hood ON when cooking at high heat or when
cooking flaming foods.
c) Clean ventilating fans frequently. Grease should not be
allowed to accumulate on fan or filter.
d) Use proper pan size. Always use cookware appropriate
for the size of the surface element.
TO REDUCE THE RISK OF INJURY TO PERSONS IN THE
EVENT OF A RANGE TOP GREASE FIRE, OBSERVE THE
FOLLOWING
a
:
1.
SMOTHER FLAMES with a close-fitting lid, cookie sheet,
or metal tray, then turn off the burner. BE CAREFUL TO
PREVENT BURNS. If the flames do not go out immedi
ately, EVACUATE AND CALL THE FIRE DEPARTMENT.
2.
NEVER PICK UP A FLAMING PAN - You may be burned.
3. DO NOT USE WATER, including wet dishcloths or towels
- a violent steam explosion will result.
4. Use an extinguisher ONLY if:
A. You know you have a Class ABC extinguisher, and you
already know how to operate it.
B. The fire is small and contained in the area where it
started.
C. The fire department is being called.
D. You can fight the fire with your back to an exit.
a
Based on “Kitchen Firesafety Tips” published by NFPA.
MODEL
WIDTH
BLOWER
(purchase separately)
VIPR102
30"
VIDV500 Interior or VEDV900 Exterior
VIPR102R
30" w/ remote control
VIDV500 Interior or VEDV900 Exterior
VIPR162
36"
VIDV500 Interior or VEDV900 Exterior
VIPR162R
36" w/ remote control
VIDV500 Interior or VEDV900 Exterior
VIPR182
48"
VIDV500 Interior, VEDV900 Exterior or VEDV1200 Exterior
VIPR182R
48" w/ remote control
VIDV500 Interior, VEDV900 Exterior or VEDV1200 Exterior
WARNING - RANGETOPS ONLY:
To reduce the risk of burns or ignition of clothing by reaching across burners, an "R" model
downdraft (with remote control)
MUST
be used with a rangetop. The remote control
MUST
be mounted in the countertop - at least
4" from the burners. See "INSTALL COOKTOP" section on page 8.
!
INSTALLER:
Save this manual for Electrical
Inspector and Homeowner to use.
HOMEOWNER:
Use and Care Information on Page 11.
CAUTION
1. For general ventilating use only. Do not use to exhaust
hazardous or explosive materials and vapors.
2.
To avoid motor bearing damage and noisy and/or unbalanced
impellers, keep drywall spray, construction dust, etc. off power
unit.
3. Clean filters and grease-laden surfaces frequently.
4. Do not repair or replace any part of this appliance unless
specifically recommended in this manual. All other servicing
should be done by a qualified technician.
5.
Please read specification label on product for further information
and requirements.
6.
DO NOT INSTALL WITH GRILL MODEL RANGETOPS. This
will void the warranty.
7.
Models VIPR102SS, VIPR162SS, and VIPR182SS (non-
remote units):
DO NOT INSTALL WITH RANGETOPS. This
will void the warranty.
!
INTENDED FOR DOMESTIC COOKING ONLY
!