Weber Genesis 1000 LP Owner Manual

Weber Genesis 1000 LP Manual

Get Weber Genesis 1000 LP PDF manuals and user guides View all Weber Genesis 1000 LP manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Genesis 1000 LP manual content summary:

  • Weber Genesis 1000 LP | Owner Manual - Page 1
    factory. GENESIS® 1000 Series LP Gas Barbecue Owner's Manual WEBER WEBER ® NationalPROPANEGAS Association WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be
  • Weber Genesis 1000 LP | Owner Manual - Page 2
    store a spare or disconnected LP tank under or near this barbecue. ƽ Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before
  • Weber Genesis 1000 LP | Owner Manual - Page 3
    of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Cooking Grates and Flavorizer Bars, 3 years, All Remaining Parts, 5 years, when assembled and operated in accordance with the printed instructions
  • Weber Genesis 1000 LP | Owner Manual - Page 4
    Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927; #4,829,978; #4,860
  • Weber Genesis 1000 LP | Owner Manual - Page 5
    . j) Locking casters for additional portability. IMPORTANT NEW FEATURES: Your Weber Gas Barbecue is equipped with a new and improved LP tank connection, that has additional safety features. They are: 1. The connection of the barbecue to the LP tank can be made without the use of tools. 2. The new
  • Weber Genesis 1000 LP | Owner Manual - Page 6
    take your Weber Gas Barbecue with you if you move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before
  • Weber Genesis 1000 LP | Owner Manual - Page 7
    LP tank filler adapter While we give much attention to our products, unfortunately an occasional error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial
  • Weber Genesis 1000 LP | Owner Manual - Page 8
    frame connectors Work table Swing table assembly Support rod Axle Accessory rack Warming rack Warm-Up Basket Five long Flavorizer Bars Eight short Flavorizer Bars Tank panel assembly Front panel Catch pan holder Catch pan Two drip pans Manifold bracket Thermometer ER Two wheels Fuel scale assembly
  • Weber Genesis 1000 LP | Owner Manual - Page 9
    Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Support rod holder Swing table end bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 x 2 inch bolts (actual size) 1/4-20 x 1 1/4 inch bolt (
  • Weber Genesis 1000 LP | Owner Manual - Page 10
    the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble top frame You will need
  • Weber Genesis 1000 LP | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame
  • Weber Genesis 1000 LP | Owner Manual - Page 12
    with the holes in the frame and insert the plastic buttons through the front panel and frame. Figure 6. Plastic buttons Figure 5 View from rear of barbecue Figure 6 12
  • Weber Genesis 1000 LP | Owner Manual - Page 13
    the frame brace. Figure 7. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame tested. you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 7 Slide the cooking box to
  • Weber Genesis 1000 LP | Owner Manual - Page 14
    , bracket and cooking box slightly and hook the tab of the bracket onto the frame brace. Figure 10. Frame brace Manifold bracket Step 10 Install tank panel assembly You will need: tank panel assembly, 1/4-20 x 1 1/4 inch bolt, 1/4-20 hex nut, nylon washer and a 7/16 inch wrench. Insert the
  • Weber Genesis 1000 LP | Owner Manual - Page 15
    scale assembly through the two small holes in the tank panel. Make sure indicator rod of fuel scale is Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to igniter up through the large part of the keyhole in the frame brace. Figure 14
  • Weber Genesis 1000 LP | Owner Manual - Page 16
    , then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look up gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized LP gas dealer by a qualified
  • Weber Genesis 1000 LP | Owner Manual - Page 17
    18 (c). Figure 16 Step 16 Connect LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. Hook the LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten the wing nut. Figure 17. E Tank lock wing nut F Figure 17 (a) Male
  • Weber Genesis 1000 LP | Owner Manual - Page 18
    open tank valve by turning the tank valve handwheel counterclockwise. Figure 19. Check: a) Hose to manifold connection. Figure 20 (a). b) Regulator to tank fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure 20
  • Weber Genesis 1000 LP | Owner Manual - Page 19
    Step 18 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box.
  • Weber Genesis 1000 LP | Owner Manual - Page 20
    You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 26. Hair pin cotter Hinge pin
  • Weber Genesis 1000 LP | Owner Manual - Page 21
    end bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. Install support rod holder on leg. Figure 29 (d). Hook the support rod into the support rod holder. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod
  • Weber Genesis 1000 LP | Owner Manual - Page 22
    accessory rack, three tubing plugs, thermometer and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right end of the lid and the (b) (c) (e) (f) (d) Figure 30 ƽCAUTION: To keep the barbecue stationary, the tabs on the locking casters should be in the down position. 22
  • Weber Genesis 1000 LP | Owner Manual - Page 23
    not use the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank
  • Weber Genesis 1000 LP | Owner Manual - Page 24
    LP tank valve and burner control knobs and start over. ƽ DANGER When the excess flow control is activated, a small amount of gas is still flowing to the burners. After turning OFF the tank and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue
  • Weber Genesis 1000 LP | Owner Manual - Page 25
    See your Weber cookbook for detailed cooking instructions. Note: gas must be turned off at the LP tank when the Weber Gas Barbecue is not in use. s When the Weber Gas Barbecue is stored indoors, the gas supply must be DISCONNECTED and the LP tank stored outdoors in a well-ventilated space. s LP tanks
  • Weber Genesis 1000 LP | Owner Manual - Page 26
    lock up out of the way. 4) Lift tank off. To refill take LP tank and tank filler adapter to a "Gas Propane" dealer. ƽWARNING: We recommend that your LP tank be filled at an authorized LP gas dealer, by a qualified attendant, who fills the tank by weight. IMPROPER FILLING IS DANGEROUS. ƽWARNING: If
  • Weber Genesis 1000 LP | Owner Manual - Page 27
    leak. If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance of
  • Weber Genesis 1000 LP | Owner Manual - Page 28
    , bugs etc. Liquid Propane (LP) Tank(s) s The LP tank and connections supplied with your Weber Gas Barbecue have been designed and tested to meet government, American Gas Association and Underwriters Laboratories requirements. s Replacement LP tanks supplied by Weber satisfy the requirements. Check
  • Weber Genesis 1000 LP | Owner Manual - Page 29
    manual. s Check all gas fittings for leaks. c) Valves to manifold connections. Figure 8 (c). d) The hose to regulator connection. Figure 8 (d). ƽWARNING: If there is a leak at connection (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When
  • Weber Genesis 1000 LP | Owner Manual - Page 30
    gas supply. Remove the manifold. (See Section "Replacing the main burners".) Look inside each burner with a flashlight. Figure 12. Weber burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off
  • Weber Genesis 1000 LP | Owner Manual - Page 31
    burner openings must be positioned properly over the valve orifices. Figure 18a. Check proper assembly before fastening manifold in place. Figure 18b. (a) Valve Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16
  • Weber Genesis 1000 LP | Owner Manual - Page 32
    If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. See Step"Check for gas leaks". White wire Black wire Figure 20 s Check that the
  • Weber Genesis 1000 LP | Owner Manual - Page 33
    . (See Section "Periodic Cleaning".) Fuel scale shows that there is gas in the LP Check adjustment of fuel scale. tank, but tank is empty. Fuel scale must be adjusted with an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. 33
  • Weber Genesis 1000 LP | Owner Manual - Page 34
    1 2 3 4 5 6 7 8 9 10 11 12 13-14 15 16 17 10,14 18 19 20 21 22 23 ® ® E BE R W E BE R W 24 25 30 26 27 28 29 31 32 34 37 33 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 65 55 60 61-62 63 64
  • Weber Genesis 1000 LP | Owner Manual - Page 35
    54 Manifold bracket 55 Igniter 56 Igniter lock nut 57 Gas catcher ignition chamber 58 Igniter wire (black) 59 Igniter wire (white) 60 Right frame 61 Fuel scale 62 1/4-20 wing nuts (2) 63 LP tank 64 Filler adapter 65 Control panel insert (2) ƽWARNING: Use only Weber factory authorized parts. The
  • Weber Genesis 1000 LP | Owner Manual - Page 36
    a Weber Barbecue. Our family here at Weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with parts or
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
W
E
B
E
R
W
E
B
E
R
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
GENESIS
®
1000 Series
LP Gas Barbecue
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
National
Association
PROPANE
GAS
®
98599
10/97