Weber Genesis 1000 NG Owner Manual

Weber Genesis 1000 NG Manual

Get Weber Genesis 1000 NG PDF manuals and user guides View all Weber Genesis 1000 NG manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Genesis 1000 NG manual content summary:

  • Weber Genesis 1000 NG | Owner Manual - Page 1
    with the factory. GENESIS® 1000 Series Natural Gas Barbecue Owner's Manual WEBER WEBER ® WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with
  • Weber Genesis 1000 NG | Owner Manual - Page 2
    . ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for
  • Weber Genesis 1000 NG | Owner Manual - Page 3
    the printed instructions accompanying it. Weber may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE. This Limited Warranty shall be limited to the repair or replacement of parts which prove defective under normal use and service and which
  • Weber Genesis 1000 NG | Owner Manual - Page 4
    Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927; #4,829,978; #4,860
  • Weber Genesis 1000 NG | Owner Manual - Page 5
    Contents WARNINGS 2 Warranty & Patents 3-4 General Instructions 6 Assembly 7-21 Operating Instructions Lighting 22-23 Cooking 24 Storage and/or Nonuse 24 Cleaning 24 Troubleshooting & Maintenance Annual Maintenance 25 General Maintenance 26-28 Troubleshooting 29 Parts Listing 31 b e a h
  • Weber Genesis 1000 NG | Owner Manual - Page 6
    Weber Gas Barbecue with you if you move. The natural gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas
  • Weber Genesis 1000 NG | Owner Manual - Page 7
    will need a soap and water solution to check for gas leaks. (See Step "Check for gas leaks.") Note - The hardware size of nuts, bolts part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual
  • Weber Genesis 1000 NG | Owner Manual - Page 8
    Caster frame Two frame connectors Work table Swing table assembly Support rod Axle Accessory rack Warming rack Warm-Up Basket Five long Flavorizer Bars Eight short Flavorizer Bars Front panel Catch pan holder Catch pan Two drip pans Manifold bracket Thermometer ER Two wheels Two casters 8 WE B ER
  • Weber Genesis 1000 NG | Owner Manual - Page 9
    Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Support rod holder Swing table end bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 x 2 inch bolts (actual size) Six 1/4-20 x 1/2 inch
  • Weber Genesis 1000 NG | Owner Manual - Page 10
    the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble top frame You will need
  • Weber Genesis 1000 NG | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame
  • Weber Genesis 1000 NG | Owner Manual - Page 12
    Step 6 Insert casters You will need: frame assembly and two casters. Push the casters firmly into the inserts in the ends of the caster legs. Figure 5. Step 7 Add front panel You will need: front panel and two plastic buttons. Turn frame assembly right side up. Align the panel with the holes in the
  • Weber Genesis 1000 NG | Owner Manual - Page 13
    the frame brace. Figure 7. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 7 (b) Slide the cooking box to
  • Weber Genesis 1000 NG | Owner Manual - Page 14
    . Figure 10. Frame brace Manifold bracket Step 10 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the (b). Loosen the igniter lock nut and slide the igniter into the small part of the keyhole. Figure 11 (c). Tighten the igniter lock nut. Figure
  • Weber Genesis 1000 NG | Owner Manual - Page 15
    psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve indoors Pipe compound should be used which is resistant to the action of natural gas when connections are made. s The outdoor connector must be firmly attached
  • Weber Genesis 1000 NG | Owner Manual - Page 16
    . If they do not turn they are off, proceed to the next step.Figure 13. Step 13 Connect flexible hose to manifold You will need: the 12 foot natural gas supply hose and a 3/4 inch wrench. Thread fitting end of hose onto manifold. Figure 14 (a). Tighten with wrench. (a) Figure 13 Figure 14 16
  • Weber Genesis 1000 NG | Owner Manual - Page 17
    leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. b) Valves to manifold connections. Figure 16 (b). c) Hose to quick disconnect connection. Figure 16 (c). ƽWARNING: If there is
  • Weber Genesis 1000 NG | Owner Manual - Page 18
    Step 15 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box.
  • Weber Genesis 1000 NG | Owner Manual - Page 19
    Step 17 Install Lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 22. Hair pin cotter Hinge pin Step 18 Add
  • Weber Genesis 1000 NG | Owner Manual - Page 20
    end bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. Install support rod holder on leg. Figure 25 (d). Hook the support rod into the support rod holder. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod
  • Weber Genesis 1000 NG | Owner Manual - Page 21
    accessory installation You will need: Warm-Up Basket, warming rack, work table, accessory rack, three tubing plugs, thermometer and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of
  • Weber Genesis 1000 NG | Owner Manual - Page 22
    hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. Crossover Ignition System 1 2 7 5 3 6 1) Open the lid. Figure 1. 2) Make sure all burner control knobs are turned OFF. (Push each burner control knob down and turn clockwise.) 3) Turn gas supply valve on
  • Weber Genesis 1000 NG | Owner Manual - Page 23
    knobs are turned OFF. (Push each burner control knob down and turn clockwise.) 3) Turn gas supply valve on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. Manual Lighting 1 ƽWARNING: If the burner does not light, turn the Front burner control knob
  • Weber Genesis 1000 NG | Owner Manual - Page 24
    off, and BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your cooking box, Weber Gas Barbecue is stored indoors, the gas supply MUST BE DISCONNECTED. s After a period of storage and/or nonuse the Weber Gas Grill should be checked for gas
  • Weber Genesis 1000 NG | Owner Manual - Page 25
    soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. b) Valves to manifold connections. Figure 3 (b). c) Hose to quick disconnect connection. Figure 3 (c). ƽWARNING: If there is a leak at
  • Weber Genesis 1000 NG | Owner Manual - Page 26
    burner tube, follow the burner cleaning procedures. Main Burner Cleaning Procedure Turn off the gas supply. Remove the manifold. (See Section "Replacing the main burners".) Look inside each burner with a flashlight. Figure 7. Weber Spider Stopper Guard Figure 5 We recommend that you inspect the
  • Weber Genesis 1000 NG | Owner Manual - Page 27
    two wing nuts that hold the manifold to the cooking box. Pull the manifold and valve assembly out of the burners and carefully set it down. Figure 10. View from behind cooking box Burner (b) Wing nuts Figure 10 f) Slide the burner assembly out from under the guide screw and washer in the corners
  • Weber Genesis 1000 NG | Owner Manual - Page 28
    Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step"Check for gas Ignition System still fails to light, See Section "Manual Lighting", and contact Weber-Stephen Customer Service. 28
  • Weber Genesis 1000 NG | Owner Manual - Page 29
    TROUBLESHOOTING Problem Burners burn with a yellow or orange flame, in conjunction with the smell of gas. Check Inspect Weber Spider Stopper Guards for possible obstructions. (Blockage of holes.) Cure Clean Weber Spider Stopper Guards. (See Section "Annual Maintenance".) Burner does not light,
  • Weber Genesis 1000 NG | Owner Manual - Page 30
    1 2 3 4 5 6 7 8 9 10 11 12 13-14 15 16 17 10,14 18 19 20 21 22 23 ® ® E BE R W E BE R W 24 25 30 26 27 28 29 31 32 30 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 50 49-53 54 55
  • Weber Genesis 1000 NG | Owner Manual - Page 31
    to our products, unfortunately an occasional error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference
  • Weber Genesis 1000 NG | Owner Manual - Page 32
    problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
W
E
B
E
R
W
E
B
E
R
GENESIS
®
1000 Series
Natural Gas Barbecue
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
FOR YOUR SAFETY
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
98613
10/97
®