Weber Genesis 2000 LX LP Owner Manual
Weber Genesis 2000 LX LP Manual
 |
View all Weber Genesis 2000 LX LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis 2000 LX LP manual content summary:
- Weber Genesis 2000 LX LP | Owner Manual - Page 1
for future use. THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY. WARNING: Do not try to light this appliance without reading "Lighting" instructions section of this manual. WE BER BER WE FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of - Weber Genesis 2000 LX LP | Owner Manual - Page 2
, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak . 2. Do not attempt to correct the problem yourself. 3. Call your fire department. 2 - Weber Genesis 2000 LX LP | Owner Manual - Page 3
assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual - Weber Genesis 2000 LX LP | Owner Manual - Page 4
PATENTS AND TRADEMARKS © 1997 Weber. Weber, , Genesis, Flavorizer and Crossover are registered U.S. trademarks; Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. - Weber Genesis 2000 LX LP | Owner Manual - Page 5
Contents WARNINGS 2 Warranty & Patents 3-4 General Instructions 6 Assembly 7-21 Operating Instructions Lighting 22-23 Cooking 24 Storage and/or Nonuse 24 Cleaning 24 LP Tank Information 25-27 e a Troubleshooting & Maintenance Annual Maintenance 28 General Maintenance 29-31 - Weber Genesis 2000 LX LP | Owner Manual - Page 6
combustion or ventilation air. s The area around the LP tank must be free and clear from debris. For Installation in Canada These instructions, while generally acceptable, do not necessarily comply with the Canadian Installation codes, particularly with piping above and below ground. In Canada the - Weber Genesis 2000 LX LP | Owner Manual - Page 7
error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank LP tank filler adapter Bottom tray Two - Weber Genesis 2000 LX LP | Owner Manual - Page 8
Caster frame Two casters Two cooking grates Warming rack Warm-Up Basket Thermometer Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide 8 - Weber Genesis 2000 LX LP | Owner Manual - Page 9
scale assembly Catch pan holder Manifold bracket Spacer bracket Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 - Weber Genesis 2000 LX LP | Owner Manual - Page 10
Step 2 Assemble wheels You will need: axle, two wheel hubcaps, two wheels, wheel frame, hammer and a block of wood. Place one end of the axle on the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the - Weber Genesis 2000 LX LP | Owner Manual - Page 11
Step 4 Continue frame assembly You will need: frame assembly, wheel frame assembly, front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel - Weber Genesis 2000 LX LP | Owner Manual - Page 12
box into the frame so the burner tubes are under the frame brace. Figure 6. Burner tubes Frame brace Your Weber Gas Barbecue burner NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use your barbecue. Guide screw Figure 6 Slide the cooking box to the left within - Weber Genesis 2000 LX LP | Owner Manual - Page 13
Step 8 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Figure 9. Place your hand underneath the bracket. Lift the bracket, manifold and cooking box slightly as a unit and hook onto the frame brace. Manifold bracket Frame brace - Weber Genesis 2000 LX LP | Owner Manual - Page 14
Step 10 Add fuel scale assembly You will need: fuel scale, two 1/4-20 wing nuts and two nylon washers. Slip the bolts on the back of the fuel scale assembly through the two small holes in the tank panel. Make sure indicator rod of fuel scale is on the left side of the wheel frame. Add washers, then - Weber Genesis 2000 LX LP | Owner Manual - Page 15
manufacturer has not resolved the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look LP tank in a car on a hot day). For full instructions on safe handling of LP tanks, see section "Operating - Weber Genesis 2000 LX LP | Owner Manual - Page 16
Step 14 Check that the burner valves are off You will need: one burner control knob. Valves are shipped in the OFF position, but you should check to be sure. Put the knob on each valve. Check by pushing down and turning clockwise. If they do not turn, they are off, proceed to the next step. Figure - Weber Genesis 2000 LX LP | Owner Manual - Page 17
(d). ƽWARNING: If there is a leak at connections (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water. (a) (b) (c) E F Figure 17 Check for leaks - Weber Genesis 2000 LX LP | Owner Manual - Page 18
Step 17 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box. - Weber Genesis 2000 LX LP | Owner Manual - Page 19
Step 19 Install the lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place from the rear of the barbecue. Close and align the hinge at the rear. Insert hinge pins from the outside through the hinge. Insert hair pin cotters into the small holes in the hinge pins. Figure - Weber Genesis 2000 LX LP | Owner Manual - Page 20
the end bracket at an angle so the lower tab is inside the frame tube. Push the bracket into the frame. Check to see that the lower table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) Support rod (a) Figure 26 - Weber Genesis 2000 LX LP | Owner Manual - Page 21
tables, two accessory trays, WarmUp Basket, warming rack, thermometer, three tubing plugs and a hammer. Insert one end of the Weber Warm-Up Basket tap them lightly with a hammer. Figure 30 (f). To lower table: Pull support rod up to disengage slide lock, and lower table. To raise table, lift - Weber Genesis 2000 LX LP | Owner Manual - Page 22
Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized dealer. Crossover Ignition System 1 3 8 4 7 56 2 Figure 1 - Weber Genesis 2000 LX LP | Owner Manual - Page 23
to light the barbecue. Failure to do so may result in an explosive flame-up which can cause serious bodily injury or death. 1 Manual Lighting 3 8 7 4 56 2 Figure 2 4) Turn the tank on by turning the tank valve counterclockwise. 5) Strike a match and put the flame into the matchlight hole - Weber Genesis 2000 LX LP | Owner Manual - Page 24
medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your cooking box, or the Weber-Stephen Customer Service Center. Outside surfaces - Use Inside cooking box - Brush any debris off of burners tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside - Weber Genesis 2000 LX LP | Owner Manual - Page 25
Refilling the LP tank We recommend that you refill before the scale indicator reaches "E". Note - If you run out of fuel, check the indicator setting and/or adjust the fuel scale indicator setting with the scale setting wing nut, while the tank is empty so you do not run out again. Removal of the LP - Weber Genesis 2000 LX LP | Owner Manual - Page 26
leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas have a question regarding the tank, call the tank manufacturer's customer service center. The phone number is on the warning decal which is permanently - Weber Genesis 2000 LX LP | Owner Manual - Page 27
years. Your LP gas supplier can do this for you. Figure 7. If you have questions about spare LP tanks, please call Weber-Stephen Customer Service. D.O.T. Certification (example) DOT 4BA240 1/97 20 lb LP tank Figure 7 Date Tested s All LP tank supply systems must include a collar to protect the - Weber Genesis 2000 LX LP | Owner Manual - Page 28
, following the procedures outlined in the "General Maintenance" section of this manual. s Check all gas fittings for leaks. ƽ DANGER Do not use OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF at the source - Weber Genesis 2000 LX LP | Owner Manual - Page 29
for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out do not appear to be uniform the length of the burner tube, follow the burner cleaning procedures. Main Burner Cleaning Procedure(See - Weber Genesis 2000 LX LP | Owner Manual - Page 30
burner assembly slightly, to separate the crossover tube from the burners. Figure 17. Remove the burners from the cooking box. Crossover tube Figure 14 e) Remove the manifold bracket and Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16 - Weber Genesis 2000 LX LP | Owner Manual - Page 31
fit around valve Check fit around burner Figure 19 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step "Check - Weber Genesis 2000 LX LP | Owner Manual - Page 32
TROUBLESHOOTING Problem tank valve on slowly. Refer to "Lighting Instructions". Burner does not light, or flame is run the whole length of the burner tube. Clean burners. (See Section "General Maintenance problems cannot be corrected by using these methods, please contact Weber-Stephen Customer - Weber Genesis 2000 LX LP | Owner Manual - Page 33
- Weber Genesis 2000 LX LP | Owner Manual - Page 34
1 2 3 4 5 6 7 8 9 10-11 12 13 14 15 16, 11 17 18-19, 11 10 20 21 22, 23 24 25 26 ® ® E BE R W E BE R W 27 28 29 30 11 31 32 33 34 34 35 36 37 11 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 8 56 57 67 58-62 63-64 65 66 - Weber Genesis 2000 LX LP | Owner Manual - Page 35
. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the 46 Control panel 47 Igniter button 48 Phillips screws/washers (2) 49 Crossover tube 50 Front or Back burner 51 Center burner 52 1/4-20 stainless steel - Weber Genesis 2000 LX LP | Owner Manual - Page 36
products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
Serial Number
Please use this number in registering your warranty
and any correspondence with the factory.
W
E
B
E
R
W
E
B
E
R
GENESIS
®
2000 LX Series
LP Gas Barbecue
Owner’s Manual
National
Association
PROPANE
GAS
®
98641
10/97
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.