Weber Genesis 2300 LP Owner Manual
Weber Genesis 2300 LP Manual
 |
View all Weber Genesis 2300 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis 2300 LP manual content summary:
- Weber Genesis 2300 LP | Owner Manual - Page 1
with the factory. GENESIS® 2300 Series LP Gas Barbecue Owner's Manual BER WE ® BER WE WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with - Weber Genesis 2300 LP | Owner Manual - Page 2
using. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber Gas Barbecue - Weber Genesis 2300 LP | Owner Manual - Page 3
operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your Weber. This Warranty applies only to products sold at retail. WEBER-STEPHEN PRODUCTS CO. Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 (800) 446-1071 LP Tank The LP - Weber Genesis 2300 LP | Owner Manual - Page 4
Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927; #4,829,978; #4,860 - Weber Genesis 2300 LP | Owner Manual - Page 5
Contents WARNINGS 2 Warranty & Patents 3-4 General Instructions 6 Assembly 7-21 Operating Instructions Lighting 22-23 Cooking 24 Storage and/or Nonuse 24 Cleaning 24 LP Tank Information 25-27 e a Troubleshooting & Maintenance Annual Maintenance 28 General Maintenance 29-31 - Weber Genesis 2300 LP | Owner Manual - Page 6
location in your yard or on your patio. Portability means you can take your Weber Gas Barbecue with you if you move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your - Weber Genesis 2300 LP | Owner Manual - Page 7
missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank LP tank filler adapter Bottom tray Two work tables Two accessory trays - Weber Genesis 2300 LP | Owner Manual - Page 8
Caster frame Two casters Two cooking grates Warming rack Warm-Up Basket Thermometer Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide 8 - Weber Genesis 2300 LP | Owner Manual - Page 9
Fuel scale assembly Catch pan holder Manifold bracket Spacer bracket Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4- - Weber Genesis 2300 LP | Owner Manual - Page 10
on the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble frame You will need: left frame - Weber Genesis 2300 LP | Owner Manual - Page 11
bolts, insert in the holes as shown and tighten with the wrench. Figure 3. Note - Fuel scale decal on wheel frame must be on the same side as the front panel. Dimples to the inside Step 5 Complete frame assembly You will need: partial frame assembly, two frame connectors, four 1/4-20 x 2 inch bolts - Weber Genesis 2300 LP | Owner Manual - Page 12
and a 7/16 inch wrench. Turn frame assembly right side up. Uncoil the hose. Set the cooking box into 6. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory are misaligned. Contact Weber-Stephen Customer Service. Do not use your barbecue. Guide screw Figure 6 Slide - Weber Genesis 2300 LP | Owner Manual - Page 13
Step 8 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Figure 9. Place your hand underneath the bracket. Lift the bracket, manifold and cooking box slightly as a unit and hook onto the frame brace. Manifold bracket Frame brace - Weber Genesis 2300 LP | Owner Manual - Page 14
tank panel. Make sure indicator rod of fuel scale is on the left side of the wheel frame. Add washers, then wing nuts and tighten. Figure Step 11 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the - Weber Genesis 2300 LP | Owner Manual - Page 15
the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look up gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized - Weber Genesis 2300 LP | Owner Manual - Page 16
be at 3, 6, or 9 o'clock. It should not be pointed up. Figure 16 (c). Figure 14 Step 15 Connect LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. Hook the LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten - Weber Genesis 2300 LP | Owner Manual - Page 17
for leaks before using your Weber Genesis Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. ƽWARNING: Perform these retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure - Weber Genesis 2300 LP | Owner Manual - Page 18
short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to drip pan. Figure 19 Finger grip on front edge of bottom tray Front side of catch pan holder Figure 21 Hook the ends of the catch pan holder - Weber Genesis 2300 LP | Owner Manual - Page 19
Step 19 Install the lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place from the rear of the barbecue. Close and align the hinge at the rear. Insert hinge pins from the outside through the hinge. Insert hair pin cotters into the small holes in the hinge pins. Figure - Weber Genesis 2300 LP | Owner Manual - Page 20
bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) Support rod (a) Figure 26 View from rear of barbecue Figure 27 Slot in frame (view from below - Weber Genesis 2300 LP | Owner Manual - Page 21
and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right Set the work tables onto the left and right side rails. Figure 30 (b). Set the accessory trays between hammer. Figure 30 (f). To lower table: Pull support rod up to disengage slide lock, and lower table. To - Weber Genesis 2300 LP | Owner Manual - Page 22
the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized dealer. LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP - Weber Genesis 2300 LP | Owner Manual - Page 23
LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame-up which can cause serious bodily injury or death. 1 Manual - Weber Genesis 2300 LP | Owner Manual - Page 24
Weber cookbook for detailed cooking instructions Weber Genesis Gas gas must be turned off at the LP tank when the Weber Gas Barbecue is not in use. s When the Weber Gas Barbecue is stored indoors, the gas supply must be DISCONNECTED and the LP tank stored outdoors in a well-ventilated space. s LP - Weber Genesis 2300 LP | Owner Manual - Page 25
and turn tank lock up out of the way. 4) Lift tank off. To refill take LP tank and tank filler adapter to a "Gas Propane" dealer. ƽWARNING: We recommend that your LP tank be filled at an authorized LP gas dealer, by a qualified attendant, who fills the tank by weight. IMPROPER FILLING IS DANGEROUS - Weber Genesis 2300 LP | Owner Manual - Page 26
a leak. If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance - Weber Genesis 2300 LP | Owner Manual - Page 27
been tested within five years. Your LP gas supplier can do this for you. Figure 7. If you have questions about spare LP tanks, please call Weber-Stephen Customer Service. D.O.T. Certification (example) DOT 4BA240 1/97 20 lb LP tank Figure 7 Date Tested s All LP tank supply systems must include - Weber Genesis 2300 LP | Owner Manual - Page 28
" section of this manual. s Check all gas fittings for leaks. ƽ DANGER Do not use an open flame to check for gas leaks. Be sure there after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connection. Figure - Weber Genesis 2300 LP | Owner Manual - Page 29
ports are fully open. Figure 13 ƽCAUTION: Do not enlarge the burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Remove the screws holding the control panel in - Weber Genesis 2300 LP | Owner Manual - Page 30
. Figure 18a. Check proper assembly before fastening manifold in place. Figure 18b. (a) Valve Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16 - Weber Genesis 2300 LP | Owner Manual - Page 31
fit around valve Check fit around burner Figure 19 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step "Check for - Weber Genesis 2300 LP | Owner Manual - Page 32
. (See Section "Periodic Cleaning".) Fuel scale shows that there is gas in the LP Check adjustment of fuel scale. tank, but tank is empty. Fuel scale must be adjusted with an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. 32 - Weber Genesis 2300 LP | Owner Manual - Page 33
- Weber Genesis 2300 LP | Owner Manual - Page 34
1 2 3 4 5 6 7 8 9 10-11 12 13 14 15 16, 11 17 18-19, 11 10 20 21 22, 23 24 25 26 ® ® E BE R W E BE R W 27 28 29 30 11 31 32 33 34 34 35 36 37 11 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 8 56 57 67 58-62 63-64 65 66 - Weber Genesis 2300 LP | Owner Manual - Page 35
Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Gas catcher ignition chamber 63 Fuel scale 64 1/4-20 wing nuts (2) 65 Filler adapter 66 LP tank 67 Control panel inserts (2) ƽWARNING: Use only Weber - Weber Genesis 2300 LP | Owner Manual - Page 36
problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
Serial Number
Please use this number in registering your warranty
and any correspondence with the factory.
W
E
B
E
R
W
E
B
E
R
GENESIS
®
2300 Series
LP Gas Barbecue
Owner’s Manual
®
92182
1/99
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.