Weber Genesis 3300 LP Owner Manual
Weber Genesis 3300 LP Manual
 |
View all Weber Genesis 3300 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis 3300 LP manual content summary:
- Weber Genesis 3300 LP | Owner Manual - Page 1
your warranty and any correspondence with the factory. GENESIS® 3300 Natural Gas Barbecue Owner's Manual WEBER WEBER ® ƽ DANGER If you smell gas: 1. in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left - Weber Genesis 3300 LP | Owner Manual - Page 2
assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and away from LP tank. 2. Do not attempt to correct the problem yourself. 3. Call your fire department. 2 - Weber Genesis 3300 LP | Owner Manual - Page 3
and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual - Weber Genesis 3300 LP | Owner Manual - Page 4
; Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927 - Weber Genesis 3300 LP | Owner Manual - Page 5
Instructions 6 Assembly 7-22 Operating Instructions Lighting 23-25 Cooking 26 Storage and/or Nonuse 26 Cleaning 26 Troubleshooting & Maintenance Annual Maintenance 27 General Maintenance 28-30 Troubleshooting past to help prevent flare-ups. e) Weber Warm-Up Basket for additional cooking or - Weber Genesis 3300 LP | Owner Manual - Page 6
instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system - Weber Genesis 3300 LP | Owner Manual - Page 7
error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Hose Bottom tray Work table Two accessory trays - Weber Genesis 3300 LP | Owner Manual - Page 8
Two casters Spacer bracket Two cooking grates Warming rack Warm-Up Basket Thermometer Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide 8 - Weber Genesis 3300 LP | Owner Manual - Page 9
are taped to the inside of the side burner lid. Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 x 2 inch bolts - Weber Genesis 3300 LP | Owner Manual - Page 10
the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER ER WE B Step 3 Assemble frame You will need: left frame - Weber Genesis 3300 LP | Owner Manual - Page 11
Step 4 Continue frame assembly You will need: frame assembly, wheel frame assembly, front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel - Weber Genesis 3300 LP | Owner Manual - Page 12
Step 6 Insert casters You will need: frame assembly and two casters. Push the casters firmly into the inserts in the ends of the caster legs. Figure 5. Step 7 Install side burner locks Note: The locks are taped to the inside of the side burner lid. You will need: frame assembly, two side burner - Weber Genesis 3300 LP | Owner Manual - Page 13
the frame so the burner tubes are under the frame brace. Figure 7. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use your barbecue. Guide screw Figure 7 Slide the cooking box to the - Weber Genesis 3300 LP | Owner Manual - Page 14
2526 psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve indoors 0.3 grams of hydrogen sulfide per 100 cubic feet of gas. s Plastic tubing is suitable only for outdoor, underground use. s Gas piping in contact - Weber Genesis 3300 LP | Owner Manual - Page 15
Step 10 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition system. The igniter lock nut is on the igniter. Insert the top of the igniter up through the large part of the keyhole in the frame - Weber Genesis 3300 LP | Owner Manual - Page 16
Step 13 Install side burner You will need: side burner assembly, burner grate, manifold bracket, and an adjustable wrench. ƽWARNING: Make sure gas supply is OFF. Slide the side burner assembly into the open end of the right frame. Route the side burner hose around the tank panel so it will not - Weber Genesis 3300 LP | Owner Manual - Page 17
checked for gas leaks. The burners have been flame tested. As a safety precaution you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. ƽWARNING: Perform these leak checks even if your barbecue was dealer - Weber Genesis 3300 LP | Owner Manual - Page 18
. Figure 18 (e). ƽWARNING: If there is a leak at connections (b), (c), (d) or (e), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water. (a) (b) Step 16 Install - Weber Genesis 3300 LP | Owner Manual - Page 19
Step 17 Install the bottom tray You will need: bottom tray, catch pan holder, catch pan and one drip pan. Step 18 Install the lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. - Weber Genesis 3300 LP | Owner Manual - Page 20
Step 19 Install tool holders, control panel and burner control knobs You will need: three tool holders, control panel, two Phillips screws/washers, a Phillips screwdriver, and three burner control knobs. Hook the tool holders over the frame rail. Figure 25. Set the control panel in place over both - Weber Genesis 3300 LP | Owner Manual - Page 21
end bracket at an angle so the lower tab is inside the frame tube. Push the bracket into the frame. Check to see that the lower table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) Support rod (a) Figure 27 View - Weber Genesis 3300 LP | Owner Manual - Page 22
trays, Warm-Up Basket, warming rack, thermometer, three tubing plugs and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right with a hammer. Figure 31 (f). Figure 29 To lower table: Pull support rod up to disengage slide lock, and lower table. To raise table, lift table - Weber Genesis 3300 LP | Owner Manual - Page 23
Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure to in any way, do not use the barbecue. Replace using only Weber authorized replacement hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. Crossover Ignition System 1 2 7 1) - Weber Genesis 3300 LP | Owner Manual - Page 24
turn clockwise.) 3) Turn gas supply valve on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. 1 Manual Lighting 2 7 ƽWARNING: Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the - Weber Genesis 3300 LP | Owner Manual - Page 25
Lighting the side burner The side burner has a separate ignition system from the main cooking box. ƽ DANGER Failure to open lid while igniting the side burner, or not waiting 5 minutes to allow gas to clear if the side burner does not light, may result in an explosive flame-up which can cause - Weber Genesis 3300 LP | Owner Manual - Page 26
medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures minutes before relighting. Preheating Your Weber Genesis Gas Barbecue is an energy the Weber-Stephen Customer Service Center. - Brush any debris off of burners tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS - Weber Genesis 3300 LP | Owner Manual - Page 27
authorized replacement hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. s Inspect the burners for correct flame pattern. Clean if necessary, following the procedures outlined in the "General Maintenance" section of this manual. s Check all gas fittings for - Weber Genesis 3300 LP | Owner Manual - Page 28
and the valve, thereby preventing spiders and other insects access to the burner tubes through the air shutter openings. Figure 7. Main Burner Flame Pattern The Weber Genesis Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown in - Weber Genesis 3300 LP | Owner Manual - Page 29
burner assembly slightly, to separate the crossover tube from the burners. Figure 14. Remove the burners from the cooking box. Crossover tube Figure 11 e) Remove the manifold bracket and Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 13 - Weber Genesis 3300 LP | Owner Manual - Page 30
fin Check fit around valve Check fit around burner Figure 16 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step - Weber Genesis 3300 LP | Owner Manual - Page 31
TROUBLESHOOTING Problem Check Burners burn with a yellow or orange flame, in Inspect Weber Spider Stopper conjunction with the smell of gas. Guards for possible obstructions. (Blockage of holes.) Cure Clean Weber run the whole length of the burner tube. Are burners clean? Clean burners. ( - Weber Genesis 3300 LP | Owner Manual - Page 32
: Before attempting any troubleshooting steps, all gas controls and supply valves should be in the OFF position. Problem Side burner does not the smell of gas. Inspect the Weber Spider Stopper Guard for possible obstructions. (Blockage of holes.) Clean Weber Spider Stopper Guard. (See Section - Weber Genesis 3300 LP | Owner Manual - Page 33
- Weber Genesis 3300 LP | Owner Manual - Page 34
1 2 3 31 4 ® ® 5 6 32 7 33 8 34 9 35 36 37 10 38 39 40 11 41 12 42 13 43 44 14 45 15 46 16 47 17 18-19 48 49 20 39 21 50 51 13,19 52 22 53 23 24 54 25 55 26 E BE R W 27 56 E BE R W 28 29 30 34 - Weber Genesis 3300 LP | Owner Manual - Page 35
Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks 37 Control panel 38 Igniter button 39 Control panel hardware 40 Crossover tube 41 Front or Back burner 42 Center burner 43 1/4-20 stainless steel - Weber Genesis 3300 LP | Owner Manual - Page 36
problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
Serial Number
Please use this number in registering your warranty
and any correspondence with the factory.
W
E
B
E
R
W
E
B
E
R
GENESIS
®
3300
Natural Gas Barbecue
Owner’s Manual
92728
11/98
®
m
WARNING
1.
Do not store spare LP Cylinder within
10 feet (3m) of this appliance.
2.
Do not
store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, Keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death or damage to property.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.