Weber Genesis Gold B LP Owner Manual
Weber Genesis Gold B LP Manual
 |
View all Weber Genesis Gold B LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis Gold B LP manual content summary:
- Weber Genesis Gold B LP | Owner Manual - Page 1
property. Liquid Propane Gas ® ® WEBER WEBER WEBER WEBER ƽ WARNING 1. GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY. YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL ƽ WARNING: Do not try to light this appliance without reading the "Lighting" Instructions section of this manual - Weber Genesis Gold B LP | Owner Manual - Page 2
use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber gas barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber gas barbecue - Weber Genesis Gold B LP | Owner Manual - Page 3
) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, lifetime, 1 year paint Porcelain Hood Section, 25 years Porcelain Side Table, 25 years Burners, 10 years Igniter - Weber Genesis Gold B LP | Owner Manual - Page 4
D-1 Manual Lighting D-2 Cooking D-3 Storage and/or Nouse D-3 Cleaning D-3 Refilling the LP Cylinder D-4 Safe handling tips for LP Gas Cylinders D-5 Annual Maintenance D-7 General Maintenance D-8 Replacing Main Burners D-9 Crossover Ignition System Operations D-10 Troubleshooting D-11 - Weber Genesis Gold B LP | Owner Manual - Page 5
you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas Barbecue. Improper assembly can be dangerous. • Not for use by children. • If there are local codes that apply to portable gas grills, you will have to conform to - Weber Genesis Gold B LP | Owner Manual - Page 6
1 Genesis Gold-B LP 2 3 36 4 5 6 37 7 8 9 38 39 10 40 41 11 42 12 43 13 44 14 45 15 46 16 17 47 18 48 19 49 20 50 21 41 22 17 23 16 24 19 25 26 27 18 28 51 52 29 53 30 31 54 26 55 56 57 32 33 58 34 59 35 A-6 - Weber Genesis Gold B LP | Owner Manual - Page 7
Pan Holder 16. Work Surface Trim 17. Work Surface 18. Side Frame (Right front/Left rear) 19. Side Frame (Left front/Right rear) 20. Tool holders 21. Nylon Manifold, Hose and regulator (assembled) 47. Manifold Hardware 48. Manifold Support Bracket 49. Igniter 50. Igniter Bracket 51. Back Panel 52. - Weber Genesis Gold B LP | Owner Manual - Page 8
-Stephen Products Co., Weber, the silhouette, and the kettle configuration are registered trademarks ® of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by one or more United States patents and patents in - Weber Genesis Gold B LP | Owner Manual - Page 9
box. Pull out bottom tray from cooking box. Remove packaging material from bottom tray, catch pan holder, catch pan, and drip pan. Remove Grill from Lower Packaging ƽ WARNING: Lifting the barbecue from the lower packaging requires at least two people. With two people: lift straight up and over - Weber Genesis Gold B LP | Owner Manual - Page 10
Flavorizer Bars - 5 Cooking Grates - 2 1/2 inch bolts (1/4 x 20 x 1/2 inch bolts) - 4 Nylon Washers - 4 Left Work Surface - 1 Condiment basket - 1 Bottom Shelf - 1 Slide Out Buttom Tray - 1 Right Work Surface - 1 LP Cylinder - 1 Catch pan holder - 1 Catch Pan - 1 Disposable Drip Pans - 2 A-10 - Weber Genesis Gold B LP | Owner Manual - Page 11
Assembly Instructions Install the slide out bottom tray You will need: the slide out bottom tray(1), the hole in the slide out bottom tray. The front of the catch pan holder must be on the same side as the finger grip(1) of the bottom tray. (1) Put the disposable drip pan into the catch pan. Slide - Weber Genesis Gold B LP | Owner Manual - Page 12
. Set the cooking grates onto the ledges in the cooking box with the rounded sides up. Install the bottom shelf You will need: Bottom shelf. Set the bottom will need: Warm-Up Basket Insert one end of the Weber Warm-Up Basket into the hole at the right side of the inside of the lid, and the other - Weber Genesis Gold B LP | Owner Manual - Page 13
the Customer Service Representative in your region using the contact information sheet provided with your manual. To fill be filled at an authorized liquid propane gas dealer by a qualified attendant, who fills instructions on safe handling of liquid propane cylinders, see Section "Operating". - Weber Genesis Gold B LP | Owner Manual - Page 14
ƽNEVER store a spare LP Cylinder under or near this barbecue. ƽNEVER fill the tank beyond 80% full. Your Weber gas grill is equipped with a instructions on the LP cylinder before attempting to fill. ƽWARNING: Do not exchange the LP tank provided with your barbecue, unless the exchange LP tank - Weber Genesis Gold B LP | Owner Manual - Page 15
tank valve(1), clockwise, or to the right. Hand tighten only. Note: This is a new type of connection. It tightens clockwise and will not allow gas to flow unless the connection is tight. The connection requires tightening by hand only. ƽ WARNING: Do not use a wrench to tighten the connection. Using - Weber Genesis Gold B LP | Owner Manual - Page 16
fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these leak gas. DO NOT OPERATE THE BARBECUE. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual - Weber Genesis Gold B LP | Owner Manual - Page 17
control panel (after checking for gas leaks) (1) Set the control panel in place over both sides of the frame. Hold the not overtighten. (3) Push each of the burner control knobs onto their valve. (4) Reinstall Side Burner cover. Install Right Work Surface You will need right work surface, two 1/2 - Weber Genesis Gold B LP | Owner Manual - Page 18
Weber authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1 ƽ DANGER: When the "excess gas FRONT burner. 2 7 5 3 6 4 *The grill illustrated may have slight differences than the model purchased. To - Weber Genesis Gold B LP | Owner Manual - Page 19
on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP tank valve OFF position. Turn gas supply OFF at the source. 1 2 7 3 4,6 5 *The grill illustrated may have slight differences than the model - Weber Genesis Gold B LP | Owner Manual - Page 20
Weber Gas Barbecue is not in use. s When the Weber Gas Barbecue is stored indoors, the gas supply must be DISCONNECTED and the LP cylinder stored outdoors in a well-ventilated space. s LP Customer Service Representative in your region using the contact information sheet provided with your manual. - Weber Genesis Gold B LP | Owner Manual - Page 21
or explosion which can cause serious Your Weber gas grill is equipped with a cylinder supply system designed for vapor withdrawal. bodily injury or death, and damage to property. ƽWARNING: Only use this grill outdoors in a well- You will need: LP cylinder, a soap and water solution ventilated - Weber Genesis Gold B LP | Owner Manual - Page 22
and water solution. If leak does not stop, Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. Do not use the barbecue. 8) When leak checking is complete, turn gas supply OFF at the source and rinse connections with water. Liquid - Weber Genesis Gold B LP | Owner Manual - Page 23
date tested(2) is within five years. Your LP gas supplier can do this for you. If you have questions about spare LP cylinders contact the Customer Service Representative in your region using the contact information sheet provided with your manual. s All LP tank supply systems must include a collar - Weber Genesis Gold B LP | Owner Manual - Page 24
. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water. (1) (2) (3) (4) Inspection and Cleaning of the Weber Spider Stopper™ Guards - Weber Genesis Gold B LP | Owner Manual - Page 25
shutters, under the control panel, causing serious damage to your barbecue. (1) Main Burner Flame Pattern The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown. 1) Burner tube 2) Tips occasionally flicker yellow 3) Light blue - Weber Genesis Gold B LP | Owner Manual - Page 26
Replacing Main Burners 1) Your Weber Gas Barbecue must be OFF and cool. 2) Turn gas OFF at source. 3) To remove control panel: take off the burner manifold in place. (2) (1) (1) 6) Slide the burner assembly out from under the guide screw and washer(1) in the corners of the cooking box. (1) D-9 - Weber Genesis Gold B LP | Owner Manual - Page 27
ƽ CAUTION: If the Spider Stopper Guards do not fit tightly, contact the Customer Service Representative in your region using the contact information sheet provided with your manual. ƽ WARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using - Weber Genesis Gold B LP | Owner Manual - Page 28
Troubleshooting Problem Check Burners burn with a yellow or Inspect Weber Spider Stopper orange flame, in conjunction with Guards for possible obstructions. the smell of gas. (Blockage of holes.) Cure Clean Weber . Refer to "Lighting Instructions". Refill LP cylinder. Straighten fuel hose
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
 |
 |
A007.c
B018.a
C016.
b
D002.e
±
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These
instructions must be left with the owner
and the owner should keep them for future
use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING: Do not try to light this
appliance without reading the “Lighting”
Instructions section of this manual
±
WARNING
1.
Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2.
Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
®
55010 04/14/00
Liquid Propane Gas
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
Owners Guide
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R