Weber Platinum I 3200 LP Owner Manual
Weber Platinum I 3200 LP Manual
 |
View all Weber Platinum I 3200 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Platinum I 3200 LP manual content summary:
- Weber Platinum I 3200 LP | Owner Manual - Page 1
with the factory. PLATINUM' 3200 Series Natural Gas Barbecue Owner's Manual aio -- g, 0\ WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with - Weber Platinum I 3200 LP | Owner Manual - Page 2
store a spare or disconnected LP tank under or near this barbecue. ■ Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ■ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before - Weber Platinum I 3200 LP | Owner Manual - Page 3
Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Cooking Grates and Flavorizer Bars, 3 years, All Remaining Parts, 5 years, when assembled and operated in accordance with the printed instructions manual. - Weber Platinum I 3200 LP | Owner Manual - Page 4
PATENTS AND TRADEMARKS © 1997 Weber. Weber, t , Flavorizer and Crossover are registered U.S. trademarks; Platinum, Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. - Weber Platinum I 3200 LP | Owner Manual - Page 5
Instructions Assembly Operating Instructions Lighting Cooking Storage and/or Nonuse Cleaning Troubleshooting & Maintenance Troubleshooting past to help prevent flare-ups. e) Weber Warm-Up Basket for additional cooking or . h) Crossover Ignition System with Gas Catcher Ignition Chamber. i) Catch pan - Weber Platinum I 3200 LP | Owner Manual - Page 6
to use and gives you more cooking control than charcoal fuel. ■ These instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas Barbecue. Improper assembly can be dangerous. ■ Not for use by children - Weber Platinum I 3200 LP | Owner Manual - Page 7
or two adjustable wrenches Pliers Lid (assembly) Block of wood Supplies needed You will need a soap and water solution to check for gas leaks. (See Step "Check for gas leaks.") Note - The hardware size of nuts, bolts and screws is given. For example "1/4-20 x 2 inch bolt" means a bolt 1/4 inch in - Weber Platinum I 3200 LP | Owner Manual - Page 8
frame Two casters 16 Two cooking grates Warming rack Warm-Up Basket Thermometer Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide Right hand slide bar assembly Assembly consists of: Right hand slide bar - Weber Platinum I 3200 LP | Owner Manual - Page 9
Catch pan holder Manifold bracket Side burner assembly Burner grate Side burner knob Two side burner locks Check contents of hardware packs Three burner control knobs Three tool holders Four tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2 - Weber Platinum I 3200 LP | Owner Manual - Page 10
the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. Step 3 Assemble frame You will need: left frame, right frame, two - Weber Platinum I 3200 LP | Owner Manual - Page 11
Step 4 Continue frame assembly You will need: frame assembly, wheel frame assembly, front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel - Weber Platinum I 3200 LP | Owner Manual - Page 12
Step 7 Install side burner locks You will need: frame assembly, two side burner locks and a 7/16 inch wrench. Loosen the right rear 1/4 x 20 bolt. Install the side burner lock. The "U" shape cut out of the lock slips down over the bolt. Tighten with a wrench. Figure 6 (a). Loosen the right front 1/4 - Weber Platinum I 3200 LP | Owner Manual - Page 13
Your Weber Gas Barbecue not use your barbecue. Guide screw (b) , (a) (c) IC) Figure 9 ng nuts Step 9 Install gas supply General Specifications for operate at 7 inches of water column pressure (.2526 psi). ■ A manual shut-off valve must be installed outdoors, immediately ahead of the quick - Weber Platinum I 3200 LP | Owner Manual - Page 14
barbecue Quick disconnect Male fitting 11/ Shut off ., 0 . Locking shut off Step 10 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition system. The igniter lock nut and igniter gasket are on - Weber Platinum I 3200 LP | Owner Manual - Page 15
5/8 inch and an 11/16 inch or two adjustable wrenches. WARNING: Make sure gas supply is OFF. CAUTION: No sealant is required on the side burner fitting. 12 Connect flexible hose to manifold You will need: the 12 foot natural gas supply hose and a 3/4 inch wrench. Thread fitting end of hose onto - Weber Platinum I 3200 LP | Owner Manual - Page 16
burners have been flame tested. As a safety precaution you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. WARNING: Perform these leak checks even if your barbecue was dealer or store assembled. You will - Weber Platinum I 3200 LP | Owner Manual - Page 17
the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact your dealer. c) Side burner hose to side burner connection. Figure 19 (c). d) Valves to manifold connections. Figure - Weber Platinum I 3200 LP | Owner Manual - Page 18
Step 17 Install the bottom tray You will need: bottom tray, catch pan holder, catch pan and one drip pan. - •---___ Finger grip on front edge of bottom tray Front side of catch pan holder Figure 22 Hook the ends of the catch pan holder into the hole in the bottom tray. Figure 23. The front of - Weber Platinum I 3200 LP | Owner Manual - Page 19
Step 19 Install tool holders, control panel and burner control knobs You will need: three tool holders, control panel and three burner control knobs. Hook the tool holders over the frame rail. Figure 26. Set the control panel in place over both frame braces. (Hold the Crossover Ignition button up - Weber Platinum I 3200 LP | Owner Manual - Page 20
screws, left hand slide bar assembly, swing table, four nylon washers, screwdriver and pliers. Allow the slide bar to hang down. Push the support rod into the lower support bracket. Figure 28 (a). Swing the rod up so you can slide the rod all the way inside the locking tab. Figure 28 (b). The - Weber Platinum I 3200 LP | Owner Manual - Page 21
screws, right hand slide bar assembly, swing table, four nylon washers, screwdriver and pliers. Allow the slide bar to hang down. Push the support rod into the lower support bracket. Figure 32 (a). Swing the rod up so you can slide the rod all the way inside the locking tab. Figure 32 (b). The - Weber Platinum I 3200 LP | Owner Manual - Page 22
using a screwdriver and pliers. Figure 34 Notch filik ttirre 0 0 Slide bar 00 View from front of barbecue Figure 34 Wheel frame To lower table: Pull support rod up to disengage slide lock and lower table. To raise table, lift table up and engage slide in locked position. Figure 35 - Weber Platinum I 3200 LP | Owner Manual - Page 23
installation You will need: work table, two accessory trays, Warm-Up Basket, warming rack, thermometer, two tubing plugs and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of - Weber Platinum I 3200 LP | Owner Manual - Page 24
Lighting Summary lighting instructions are on the control panel. DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. Crossover - Weber Platinum I 3200 LP | Owner Manual - Page 25
burner control knobs are turned OFF. (Push each knob down and turn clockwise.) 3) Turn gas supply valve on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. 1 Manual Lighting WARNING: If the burner does not light, turn the Front burner control knob to - Weber Platinum I 3200 LP | Owner Manual - Page 26
lid while igniting the side burner, or not waiting 5 minutes to allow gas to clear if the side burner does not light, may result in main burner control valves are OFF (push down and turn clockwise). 3) Turn the LP tank valve on (turn counterclockwise). 4) Push down and turn the side burner control - Weber Platinum I 3200 LP | Owner Manual - Page 27
at medium, CENTER off, and BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your cooking box, for the in the bottom tray. Storage and/or Nonuse ■ When storing the Weber Gas Barbecue, make sure that the inside shut off valve and/or locking outdoor - Weber Platinum I 3200 LP | Owner Manual - Page 28
TROUBLESHOOTING & MAINTENANCE Troubleshooting Problem Check Burners burn with a yellow or orange flame, in Inspect Weber Spider Stopper conjunction with the smell of gas. Guards for possible obstructions. (Blockage of holes.) Cure Clean Weber Spider Stopper Guards. (See Section "Annual - Weber Platinum I 3200 LP | Owner Manual - Page 29
WARNING: Before attempting any troubleshooting steps, all gas controls and supply valves should be in the OFF position. Problem Side burner does not light. Check Is gas supply off? Cure Turn supply on. Flame is low in HIGH position. Is fuel hose bent or kinked? Straighten hose. Flame - Weber Platinum I 3200 LP | Owner Manual - Page 30
Maintenance" section of this manual. ■ Check all gas fittings for leaks. DANGER Do not use an open flame to check for gas leaks. Be sure there c, Figure 8 (e) A. (d) !.- I• Inspection and Cleaning of the Weber Spider Stopper Guards To inspect the Spider Stopper Guards, remove the control panel - Weber Platinum I 3200 LP | Owner Manual - Page 31
may result in a fire which can cause serious bodily injury or death and cause damage to property. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Put your fingers under the edge of the - Weber Platinum I 3200 LP | Owner Manual - Page 32
15. View from behind cooking box 0 Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16. Guide screw s Figure 17 h) To reinstall burners, reverse steps c) through g). CAUTION: The burner openings must be positioned - Weber Platinum I 3200 LP | Owner Manual - Page 33
Guards do not fit tightly, contact your dealer. CAUTION: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See If the Crossover Ignition System still fails to light, see Section "Manual Lighting", and contact your dealer. 33 - Weber Platinum I 3200 LP | Owner Manual - Page 34
2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18-19, 16 10 20 21 22 23 24 25 26 36 37 38 O O O 40. 6 6. 6 0 o o® 27 28 29 30 31 32 33 34 18 34 19 1635 39 40 41 42 43 44 45 46 47 48 49 50 51 52-53,49 54 43 55 56 57-62 It__ 12 14 63 - Weber Platinum I 3200 LP | Owner Manual - Page 35
Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South wire (black) 61 Igniter wire (white) 62 Gas catcher ignition chamber 63 Hose WARNING: Use only Weber factory authorized parts. The use of any part - Weber Platinum I 3200 LP | Owner Manual - Page 36
problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
timber®
Serial
Number
Please
use
this
number
in
registering
your
warranty
and
any
correspondence with
the
factory.
PLATINUM'
3200
Series
Natural
Gas
Barbecue
Owner's
Manual
WARNING:
Follow
all
leak
check
procedures
carefully
in
this
manual
prior
to
barbecue
operation.
Do
this
even
if
barbecue
was
dealer
assembled.
NOTICE
TO
INSTALLER:
These
instructions
must
be
left
with
the
owner
and
the
owner
should
keep
them
for
future
use.
FOR
YOUR
SAFETY
Do
not
store
or
use
gasoline
or
other
flammable
vapors
and
liquids
in
the
vicinity
of
this
or
any
other
appliance.
aio
--
g
,
0\
WARNING:
Do
not
try
to
light
this
appliance
without
reading
"Lighting"
instructions
section
of
this
manual.
THIS
GAS
APPLIANCE
IS
DESIGNED
FOR
OUTDOOR
USE
ONLY.
FOR
YOUR
SAFETY
If
you
smell
gas:
1.
Shut
off
gas
to
the
appliance.
2.
Extinguish
any
open
flame.
3.
Open
lid.
4.
If
odor
continues,
immediately
call
your
gas
supplier.
98010
2/97