Weber Platinum I 3200 NG Owner Manual

Weber Platinum I 3200 NG Manual

Get Weber Platinum I 3200 NG PDF manuals and user guides View all Weber Platinum I 3200 NG manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Platinum I 3200 NG manual content summary:

  • Weber Platinum I 3200 NG | Owner Manual - Page 1
    vapors and liquids in the vicinity of this or any other appliance. WARNING: Do not try to light this appliance without reading "Lighting" instructions section of this manual. THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY. FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance
  • Weber Platinum I 3200 NG | Owner Manual - Page 2
    , the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures. ■ Do not operate the Weber Gas Barbecue if there is a gas leak . 2. Do not attempt to correct the problem yourself. 3. Call your fire department. 2
  • Weber Platinum I 3200 NG | Owner Manual - Page 3
    assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of parts which prove defective under normal use and service and which on examination shall indicate, to as set out in this owner's manual. Deterioration or damage due to severe
  • Weber Platinum I 3200 NG | Owner Manual - Page 4
    PATENTS AND TRADEMARKS © 1997 Weber. Weber, t , Flavorizer and Crossover are registered U.S. trademarks; Platinum, Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266.
  • Weber Platinum I 3200 NG | Owner Manual - Page 5
    Contents WARNINGS Warranty & Patents General Instructions Assembly Operating Instructions Lighting Cooking Storage and/or Nonuse Cleaning Troubleshooting & Maintenance Troubleshooting Annual Maintenance General Maintenance Parts Listing 2 3-4 6 7-23 24-26 27 27 27 28-29 30 31-33 35 6P 0I.6lef
  • Weber Platinum I 3200 NG | Owner Manual - Page 6
    of combustion or ventilation air. For Installation in Canada These instructions, while generally acceptable, do not necessarily comply with the be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at
  • Weber Platinum I 3200 NG | Owner Manual - Page 7
    Assembly Tools needed Screwdrivers, regular and Phillips Hammer Step 1 Check package contents Cooking box (assembly) 7/16, 5/8, 11/16, and 3/4 inch open-end or two adjustable wrenches Pliers Lid (assembly) Block of wood Supplies needed You will need a soap and water solution to check for gas
  • Weber Platinum I 3200 NG | Owner Manual - Page 8
    frame Two casters 16 Two cooking grates Warming rack Warm-Up Basket Thermometer Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide Right hand slide bar assembly Assembly consists of: Right hand slide bar
  • Weber Platinum I 3200 NG | Owner Manual - Page 9
    Catch pan holder Manifold bracket Side burner assembly Burner grate Side burner knob Two side burner locks Check contents of hardware packs Three burner control knobs Three tool holders Four tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2
  • Weber Platinum I 3200 NG | Owner Manual - Page 10
    Step 2 Assemble wheels You will need: axle, two wheel hubcaps, two wheels, wheel frame, hammer and a block of wood. Place one end of the axle on the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the
  • Weber Platinum I 3200 NG | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: frame assembly, wheel frame assembly, front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel
  • Weber Platinum I 3200 NG | Owner Manual - Page 12
    Step 7 Install side burner locks You will need: frame assembly, two side burner locks and a 7/16 inch wrench. Loosen the right rear 1/4 x 20 bolt. Install the side burner lock. The "U" shape cut out of the lock slips down over the bolt. Tighten with a wrench. Figure 6 (a). Loosen the right front 1/4
  • Weber Platinum I 3200 NG | Owner Manual - Page 13
    washers at the left rear and left front of the cooking box? The screws are only guides. Do not tighten. Figure 9 (b). c) Are the wing nuts under the burner assembly at 7 inches of water column pressure (.2526 psi). ■ A manual shut-off valve must be installed outdoors, immediately ahead of the quick
  • Weber Platinum I 3200 NG | Owner Manual - Page 14
    Typical natural gas supply installation. Figure 10. Gas supply Inside wall Outside wall To barbecue Quick disconnect Male fitting 11/ Shut off ., 0 . Locking shut off Step 10 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This
  • Weber Platinum I 3200 NG | Owner Manual - Page 15
    Step 11 Check that all burner valves are off You will need: one burner control knob. Valves are shipped in the OFF position, but you should check to be sure. Put the knob on each valve. Check by pushing down and turning clockwise. If they do not turn, they are off, proceed to the next step. Figure
  • Weber Platinum I 3200 NG | Owner Manual - Page 16
    Step 14 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Figure 16. Place your hand underneath the bracket. Lift the bracket, manifold and cooking box slightly as a unit and hook onto the frame brace. Manifold bracket a Frame
  • Weber Platinum I 3200 NG | Owner Manual - Page 17
    Check: a) Hose to manifold connection. Figure 19 (a). b) Manifold to side burner hose connection. Figure 19 (b). WARNING: If there is a leak at connections a or b, retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the
  • Weber Platinum I 3200 NG | Owner Manual - Page 18
    Step 17 Install the bottom tray You will need: bottom tray, catch pan holder, catch pan and one drip pan. - •---___ Finger grip on front edge of bottom tray Front side of catch pan holder Figure 22 Hook the ends of the catch pan holder into the hole in the bottom tray. Figure 23. The front of
  • Weber Platinum I 3200 NG | Owner Manual - Page 19
    Step 19 Install tool holders, control panel and burner control knobs You will need: three tool holders, control panel and three burner control knobs. Hook the tool holders over the frame rail. Figure 26. Set the control panel in place over both frame braces. (Hold the Crossover Ignition button up
  • Weber Platinum I 3200 NG | Owner Manual - Page 20
    screws, left hand slide bar assembly, swing table, four nylon washers, screwdriver and pliers. Allow the slide bar to hang down. Push the support rod into the lower support bracket. Figure 28 (a). Swing the rod up so you can slide the rod all the way inside the locking tab. Figure 28 (b). The
  • Weber Platinum I 3200 NG | Owner Manual - Page 21
    screws, right hand slide bar assembly, swing table, four nylon washers, screwdriver and pliers. Allow the slide bar to hang down. Push the support rod into the lower support bracket. Figure 32 (a). Swing the rod up so you can slide the rod all the way inside the locking tab. Figure 32 (b). The
  • Weber Platinum I 3200 NG | Owner Manual - Page 22
    using a screwdriver and pliers. Figure 34 Notch filik ttirre 0 0 Slide bar 00 View from front of barbecue Figure 34 Wheel frame To lower table: Pull support rod up to disengage slide lock and lower table. To raise table, lift table up and engage slide in locked position. Figure 35
  • Weber Platinum I 3200 NG | Owner Manual - Page 23
    Step 23 Complete accessory installation You will need: work table, two accessory trays, Warm-Up Basket, warming rack, thermometer, two tubing plugs and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of
  • Weber Platinum I 3200 NG | Owner Manual - Page 24
    Lighting Summary lighting instructions are on the control panel. DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if
  • Weber Platinum I 3200 NG | Owner Manual - Page 25
    Manual Lighting DANGER Failure to open lid while igniting the barbecue, or not on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. 1 Manual Lighting WARNING: If the burner does not light, turn the Front burner control knob to OFF and wait 5 minutes to
  • Weber Platinum I 3200 NG | Owner Manual - Page 26
    Lighting the side burner The side burner has a separate ignition system from the main cooking box. DANGER Failure to open lid while igniting the side burner, or not waiting 5 minutes to allow gas to clear if the side burner does not light, may result in an explosive flame-up which can cause serious
  • Weber Platinum I 3200 NG | Owner Manual - Page 27
    Then to complete cooking you would use (MOM) (FRONT at medium, CENTER off, and BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your cooking box, for the first few uses, while surfaces are still very reflective, may be hotter than those shown
  • Weber Platinum I 3200 NG | Owner Manual - Page 28
    TROUBLESHOOTING & MAINTENANCE Troubleshooting Problem Check Burners burn with a yellow or orange flame, in Inspect Weber Spider Stopper conjunction with the smell of gas. Guards for possible obstructions. (Blockage of
  • Weber Platinum I 3200 NG | Owner Manual - Page 29
    WARNING: Before attempting any troubleshooting steps, all gas controls and supply valves should be in the OFF position. Problem Side burner does not light. Check Is gas supply off? Cure Turn supply on. Flame is low in HIGH position. Is fuel hose bent or
  • Weber Platinum I 3200 NG | Owner Manual - Page 30
    the necessary parts. ■ Inspect the burners for correct flame pattern. Clean if necessary, following the procedures outlined in the "General Maintenance" section of this manual. ■ Check all gas fittings for leaks. DANGER Do not use an open flame to check for gas leaks. Be sure there are no sparks or
  • Weber Platinum I 3200 NG | Owner Manual - Page 31
    General Maintenance Weber Spider Stopper Guards Your Weber Genesis Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the
  • Weber Platinum I 3200 NG | Owner Manual - Page 32
    15. View from behind cooking box 0 Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16. Guide screw s Figure 17 h) To reinstall burners, reverse steps c) through g). CAUTION: The burner openings must be positioned
  • Weber Platinum I 3200 NG | Owner Manual - Page 33
    loose in the frame. Tighten if necessary; see Step "Install igniter" for correct procedure. If the Crossover Ignition System still fails to light, see Section "Manual Lighting", and contact your dealer. 33
  • Weber Platinum I 3200 NG | Owner Manual - Page 34
    2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18-19, 16 10 20 21 22 23 24 25 26 36 37 38 O O O 40. 6 6. 6 0 o o® 27 28 29 30 31 32 33 34 18 34 19 1635 39 40 41 42 43 44 45 46 47 48 49 50 51 52-53,49 54 43 55 56 57-62 It__ 12 14 63
  • Weber Platinum I 3200 NG | Owner Manual - Page 35
    occasional error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer
  • Weber Platinum I 3200 NG | Owner Manual - Page 36
    products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
timber®
Serial
Number
Please
use
this
number
in
registering
your
warranty
and
any
correspondence with
the
factory.
PLATINUM'
3200
Series
Natural
Gas
Barbecue
Owner's
Manual
WARNING:
Follow
all
leak
check
procedures
carefully
in
this
manual
prior
to
barbecue
operation.
Do
this
even
if
barbecue
was
dealer
assembled.
NOTICE
TO
INSTALLER:
These
instructions
must
be
left
with
the
owner
and
the
owner
should
keep
them
for
future
use.
FOR
YOUR
SAFETY
Do
not
store
or
use
gasoline
or
other
flammable
vapors
and
liquids
in
the
vicinity
of
this
or
any
other
appliance.
aio
--
g
,
0\
WARNING:
Do
not
try
to
light
this
appliance
without
reading
"Lighting"
instructions
section
of
this
manual.
THIS
GAS
APPLIANCE
IS
DESIGNED
FOR
OUTDOOR
USE
ONLY.
FOR
YOUR
SAFETY
If
you
smell
gas:
1.
Shut
off
gas
to
the
appliance.
2.
Extinguish
any
open
flame.
3.
Open
lid.
4.
If
odor
continues,
immediately
call
your
gas
supplier.
98010
2/97