Weber Skyline 1200 LP Owner Manual
Weber Skyline 1200 LP Manual
 |
View all Weber Skyline 1200 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Skyline 1200 LP manual content summary:
- Weber Skyline 1200 LP | Owner Manual - Page 1
Serial Number SKYLINE™ 1200 LP Gas Barbecue Owner's Manual Please use this number in registering your warranty and any correspondence with the factory. WEBER WEBER ® NationalPROPANEGAS Association WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do - Weber Skyline 1200 LP | Owner Manual - Page 2
burner obstructions before using. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides - Weber Skyline 1200 LP | Owner Manual - Page 3
ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Recycled Work Surfaces, 10 years Cooking Grates and Flavorizer Bars, 3 years, All Remaining Parts, 5 years, when assembled and - Weber Skyline 1200 LP | Owner Manual - Page 4
Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927; #4,829,978; #4,860 - Weber Skyline 1200 LP | Owner Manual - Page 5
. f) Separate burners for temperature control. g) Crossover Ignition System with Gas Catcher Ignition Chamber. h) Fuel scale indicates LP gas supply. i) Catch pan catches excess grease. j) Locking casters for additional portability. IMPORTANT NEW FEATURES: Your Weber Gas Barbecue is equipped - Weber Skyline 1200 LP | Owner Manual - Page 6
you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas Barbecue. Improper assembly can be dangerous. s Not for use by children. s If there are local codes that apply to portable gas grills, you will have to conform to - Weber Skyline 1200 LP | Owner Manual - Page 7
occasional error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank filler adapter Bottom tray Two - Weber Skyline 1200 LP | Owner Manual - Page 8
Left frame Right frame Wheel frame Caster frame Two frame connectors Work table Swing table assembly Support rod Axle Two accessory trays Warming rack Warm-Up Basket Five long Flavorizer Bars Eight short Flavorizer Bars Tank panel assembly Front panel Catch pan - Weber Skyline 1200 LP | Owner Manual - Page 9
Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Swing table end bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) - Weber Skyline 1200 LP | Owner Manual - Page 10
on the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble frame You will need: left frame - Weber Skyline 1200 LP | Owner Manual - Page 11
Step 4 Continue frame assembly You will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame - Weber Skyline 1200 LP | Owner Manual - Page 12
front panel and two plastic buttons. Turn frame assembly right side up. Align the panel with the holes in the frame the cooking box in the frame so the burner tubes are under the frame brace. Figure 7. Burner tubes Frame brace View from rear of barbecue Figure 6 Figure 7 Slide the cooking box - Weber Skyline 1200 LP | Owner Manual - Page 13
tighten with pliers. Figure 9 (c). If you answered YES to a, b and c, the burners are correctly aligned. If you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Step 9 Install manifold bracket You will need: manifold bracket Hook the - Weber Skyline 1200 LP | Owner Manual - Page 14
of the fuel scale assembly through the two small holes in the tank panel. Make sure indicator rod of fuel scale is on the left side of the wheel frame. Add washers then wing nuts and tighten. Figure 13. Tank panel tabs Figure 11 Slide tank panel up until notch at - Weber Skyline 1200 LP | Owner Manual - Page 15
Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition system. The igniter lock nut is on the igniter. Insert the top of the igniter up through the large part hook the tank onto the fuel scale. With an empty LP tank, adjust the fuel scale setting to E with scale - Weber Skyline 1200 LP | Owner Manual - Page 16
the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look up gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized - Weber Skyline 1200 LP | Owner Manual - Page 17
connections have been thoroughly checked for gas leaks. The burners have been flame tested. As a safety precaution you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. ƽWARNING: Perform these leak checks - Weber Skyline 1200 LP | Owner Manual - Page 18
for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure 20 (c). d) The hose to regulator connection. Figure 20 (d). ƽWARNING: If there - Weber Skyline 1200 LP | Owner Manual - Page 19
pan and one drip pan. Finger grip on front edge of bottom tray Front side of catch pan holder Figure 23 Step 20 Install Lid You will need: lid cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small - Weber Skyline 1200 LP | Owner Manual - Page 20
Insert one wire end of the condiment basket into the hole in the side frame. Figure 27 (a). Insert the opposite wire end of the condiment the condiment basket. Call our Customer Service Center to order a new part. Wire end (a) Step 22 Add control panel and burner control knobs You will need: - Weber Skyline 1200 LP | Owner Manual - Page 21
pliers. Allow the slide bar to hang down. Push the support rod into the lower support bracket. Figure 29 (a). Swing the rod up so you can Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) View from rear of barbecue Figure 30 - Weber Skyline 1200 LP | Owner Manual - Page 22
and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right Figure 33 (b). Set the work table onto the left side rails. Figure 33 (c). Set the accessory rack in place Slide Support rod View from rear of barbecue (d) Figure 33 ƽCAUTION: To keep the barbecue stationary, - Weber Skyline 1200 LP | Owner Manual - Page 23
- Weber Skyline 1200 LP | Owner Manual - Page 24
. After turning OFF the tank and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame-up which can cause serious bodily injury or death. Manual Lighting 1 4) Turn the tank on by turning the - Weber Skyline 1200 LP | Owner Manual - Page 25
and/or Nonuse continued s When the LP tank is not disconnected from the Weber Gas Barbecue, the appliance and LP tank must be kept outdoors in a well-ventilated space. s The Weber Gas Barbecue should be checked for gas leaks and any obstructions in the burner tubes before using. (See Sections - Weber Skyline 1200 LP | Owner Manual - Page 26
tanks are not compatible with your barbecue connection. Scale setting wing nut Tank lock wing nut Connecting the filled LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. ƽ DANGER Do not use an open flame to check for gas leaks. Be sure there are no sparks or - Weber Skyline 1200 LP | Owner Manual - Page 27
a leak. If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance - Weber Skyline 1200 LP | Owner Manual - Page 28
, bugs etc. Liquid Propane (LP) Tank(s) s The LP tank and connections supplied with your Weber Gas Barbecue have been designed and tested to meet government, American Gas Association and Underwriters Laboratories requirements. s Replacement LP tanks supplied by Weber satisfy the requirements. Check - Weber Skyline 1200 LP | Owner Manual - Page 29
manual. s Check all gas fittings for leaks. c) Valves to manifold connections. Figure 7 (c). d) The hose to regulator connection. Figure 7 (d). ƽWARNING: If there is a leak at connection (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When - Weber Skyline 1200 LP | Owner Manual - Page 30
in and around the air shutters, under the control panel, causing serious damage to your barbecue. Venturi Main Burner Flame Pattern The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown in Figure 10. Tips occasionally yellowish - Weber Skyline 1200 LP | Owner Manual - Page 31
screw and washer in the corners of the cooking box. Figure 16. Guide screw Figure 17 h) To reinstall the burners, reverse steps c) through g). ƽCAUTION: The burner openings must be positioned properly over the valve orifices. Figure 18a. Check proper assembly before fastening manifold in place - Weber Skyline 1200 LP | Owner Manual - Page 32
Check fit around burner Figure 19 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. See Step"Check for gas leaks". Black - Weber Skyline 1200 LP | Owner Manual - Page 33
TROUBLESHOOTING Problem Check Cure Burners burn with a yellow or orange Inspect Weber Spider Stopper flame, in conjunction with the smell of gas. Guards for possible obstructions. (Blockage of holes.) Clean Weber Spider Stopper Guards. (See Section "Annual Maintenance".) Burners do not - Weber Skyline 1200 LP | Owner Manual - Page 34
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15-16 17 18 11,16 19 20-21, 11 22 23 24 25 ® ® E BE R W E BE R W 32 26 27 28 29 30 31 33 34 34 36 35 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59-60 61 62 - Weber Skyline 1200 LP | Owner Manual - Page 35
occasional error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer - Weber Skyline 1200 LP | Owner Manual - Page 36
a Weber Barbecue. Our family here at Weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with parts or
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
W
E
B
E
R
W
E
B
E
R
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
National
Association
PROPANE
GAS
®
98694
12/97
SKYLINE
™
1200
LP Gas Barbecue