Weber Skyline 3200 NG Owner Manual

Weber Skyline 3200 NG Manual

Get Weber Skyline 3200 NG PDF manuals and user guides View all Weber Skyline 3200 NG manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Skyline 3200 NG manual content summary:

  • Weber Skyline 3200 NG | Owner Manual - Page 1
    correspondence with the factory. SKYLINE™ 3200 Natural Gas Barbecue Owner's Manual WEBER WEBER ® WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with
  • Weber Skyline 3200 NG | Owner Manual - Page 2
    assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and away from LP tank. 2. Do not attempt to correct the problem yourself. 3. Call your fire department. 2
  • Weber Skyline 3200 NG | Owner Manual - Page 3
    and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual
  • Weber Skyline 3200 NG | Owner Manual - Page 4
    and Crossover are registered U.S. trademarks; Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos
  • Weber Skyline 3200 NG | Owner Manual - Page 5
    Instructions 6 Assembly 7-22 Operating Instructions Lighting 23-25 Cooking 26 Storage and/or Nonuse 26 Cleaning 26 Troubleshooting & Maintenance Annual Maintenance 27 General Maintenance 28-30 Troubleshooting past to help prevent flare-ups. e) Weber Warm-Up Basket for additional cooking or
  • Weber Skyline 3200 NG | Owner Manual - Page 6
    instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system
  • Weber Skyline 3200 NG | Owner Manual - Page 7
    error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Hose Bottom tray Work table Accessory rack Swing
  • Weber Skyline 3200 NG | Owner Manual - Page 8
    grates Warming rack Warm-Up Basket Thermometer Wire condiment basket with tool holders Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide 8
  • Weber Skyline 3200 NG | Owner Manual - Page 9
    locks are taped to the inside of the side burner lid. Spacer bracket Check contents of hardware packs Three burner control knobs Five tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 x 2 inch bolts
  • Weber Skyline 3200 NG | Owner Manual - Page 10
    the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble frame You will need: left
  • Weber Skyline 3200 NG | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: frame assembly, wheel frame assembly, front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel
  • Weber Skyline 3200 NG | Owner Manual - Page 12
    inch bolt, nylon washer, 1/4-20 acorn nut, pliers and a 7/16 inch wrench. Set the cooking box into the frame so the burner tubes are under the frame brace. Figure 7. Burner tubes Frame brace (b) Figure 6 Figure 7 Slide the cooking box to the left within the frame. Put the washer on the bolt. Take
  • Weber Skyline 3200 NG | Owner Manual - Page 13
    answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use your barbecue. Guide screw (b) (a) (c) Figure 9 Wing nuts psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve
  • Weber Skyline 3200 NG | Owner Manual - Page 14
    must be tin-lined if the gas contains more than 0.3 grams of hydrogen sulfide per 100 cubic feet of gas. s Plastic tubing is suitable only for outdoor, underground use. s Gas piping in contact with earth, or any other material which may corrode the piping, must be protected
  • Weber Skyline 3200 NG | Owner Manual - Page 15
    Step 11 Check that all burner valves are off You will need: one burner control knob. (Valves are shipped in the OFF position, but you should check to be sure.) Put the knob on each valve. Check by pushing down and turning clockwise. If they do not turn they are off, proceed to the next step. Figure
  • Weber Skyline 3200 NG | Owner Manual - Page 16
    checked for gas leaks. The burners have been flame tested. As a safety precaution you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. ƽWARNING: Perform these leak checks even if your barbecue was dealer
  • Weber Skyline 3200 NG | Owner Manual - Page 17
    17 (e). ƽWARNING: If there is a leak at connections (b), (c), (d) or (e), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water. (a) (b) (c) (d) Figure 17 (e) 17
  • Weber Skyline 3200 NG | Owner Manual - Page 18
    Step 15 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box.
  • Weber Skyline 3200 NG | Owner Manual - Page 19
    Step 17 Install the lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 23. Hair pin cotter Hinge pin Step 18
  • Weber Skyline 3200 NG | Owner Manual - Page 20
    end bracket at an angle so the lower tab is inside the frame tube. Push the bracket into the frame. Figure 26 (b). Check to see that in any way cracked or damaged, do not use the condiment basket. Call our Customer Service Center to order a new part. Wire end (a) View from top View from side Figure
  • Weber Skyline 3200 NG | Owner Manual - Page 21
    end bracket at an angle so the lower tab is inside the frame tube. Push the bracket into the frame. Check to see that the lower table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) Support rod (a) Figure 27 View
  • Weber Skyline 3200 NG | Owner Manual - Page 22
    rack, Warm-Up Basket, warming rack, thermometer, three tubing plugs and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right with a hammer. Figure 31 (f). Figure 29 To lower table: Pull support rod up to disengage slide lock, and lower table. To raise table, lift table
  • Weber Skyline 3200 NG | Owner Manual - Page 23
    Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure to any way, do not use the barbecue. Replace using only Weber authorized replacement hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. 1 Crossover Ignition System 1) Open
  • Weber Skyline 3200 NG | Owner Manual - Page 24
    and turn clockwise.) 3) Turn gas supply valve on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. 1 Manual Lighting ƽWARNING: Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the
  • Weber Skyline 3200 NG | Owner Manual - Page 25
    Lighting the side burner The side burner has a separate ignition system from the main cooking box. ƽ DANGER Failure to open lid while igniting the side burner, or not waiting 5 minutes to allow gas to clear if the side burner does not light, may result in an explosive flame-up which can cause
  • Weber Skyline 3200 NG | Owner Manual - Page 26
    and BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your your retailer or the Weber-Stephen Customer Service Center. Outside surfaces cooking box - Brush any debris off of burners tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside
  • Weber Skyline 3200 NG | Owner Manual - Page 27
    authorized replacement hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. s Inspect the burners for correct flame pattern. Clean if necessary, following the procedures outlined in the "General Maintenance" section of this manual. s Check all gas fittings for
  • Weber Skyline 3200 NG | Owner Manual - Page 28
    box Tips occasionally yellowish Flames Light blue Dark blue Air shutter Venturi fin Figure 6 The Weber Spider Stopper Guard is factory installed. It fits tightly around the air shutter section of the burner tube and the valve, thereby preventing spiders and other insects access to the burner
  • Weber Skyline 3200 NG | Owner Manual - Page 29
    burner assembly slightly, to separate the crossover tube from the burners. Figure 14. Remove the burners from the cooking box. Crossover tube Figure 11 e) Remove the manifold bracket and Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 13
  • Weber Skyline 3200 NG | Owner Manual - Page 30
    fin Check fit around valve Check fit around burner Figure 16 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step
  • Weber Skyline 3200 NG | Owner Manual - Page 31
    TROUBLESHOOTING Problem Check Burners burn with a yellow or orange flame, in Inspect Weber Spider Stopper conjunction with the smell of gas. Guards for possible obstructions. (Blockage of holes.) Cure Clean Weber run the whole length of the burner tube. Are burners clean? Clean burners. (
  • Weber Skyline 3200 NG | Owner Manual - Page 32
    : Before attempting any troubleshooting steps, all gas controls and supply valves should be in the OFF position. Problem Side burner does not the smell of gas. Inspect the Weber Spider Stopper Guard for possible obstructions. (Blockage of holes.) Clean Weber Spider Stopper Guard. (See Section
  • Weber Skyline 3200 NG | Owner Manual - Page 33
    33
  • Weber Skyline 3200 NG | Owner Manual - Page 34
    1 2 34 ® ® 35 36 3 37 4 38 5 6 7 39 40 41 8 42 43 44 45 9 46 47 10 48 49 11 50 12 13 51 14 15 16-17 52 53 18 54 55 19-20,17 56 12 57 21 22 23 24 25 E BE R W E BE R W 26 27 28 29 30 31 32 33 34
  • Weber Skyline 3200 NG | Owner Manual - Page 35
    Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Control panel 43 Igniter button 44 Phillips screws/washers (2) 45 Crossover tube 46 Front or Back burner 47 Center burner 48 1/4-20 stainless steel
  • Weber Skyline 3200 NG | Owner Manual - Page 36
    problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
Serial Number
Please use this number in registering your warranty
and any correspondence with the factory.
W
E
B
E
R
W
E
B
E
R
SKYLINE
™
3200
Natural Gas Barbecue
Owner’s Manual
98697
12/97
®
FOR YOUR SAFETY
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.