Weber Spirit 530 LP Mica Owner Manual
Weber Spirit 530 LP Mica Manual
 |
View all Weber Spirit 530 LP Mica manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Spirit 530 LP Mica manual content summary:
- Weber Spirit 530 LP Mica | Owner Manual - Page 1
and any correspondence with the factory. SPIRIT™ 530 Series LP Gas Barbecue Owner's Manual WEBER WEBE R ® NationalPROPANEGAS Association ƽ carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left - Weber Spirit 530 LP Mica | Owner Manual - Page 2
property. ƽWARNINGS ƽ Do not store a spare or disconnected LP tank under or near this barbecue. ƽ Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks - Weber Spirit 530 LP Mica | Owner Manual - Page 3
operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your Weber. This Warranty applies only to products sold at retail. WEBER-STEPHEN PRODUCTS CO. Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 (800) 446-1071 LP Tank The LP - Weber Spirit 530 LP Mica | Owner Manual - Page 4
PATENTS AND TRADEMARKS © 1998 Weber. Weber, , Flavorizer and Crossover are registered U.S. trademarks; Spirit, Gas Catcher, FlameCheck, and Spider Stopper are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Spirit is covered under the following - Weber Spirit 530 LP Mica | Owner Manual - Page 5
Warranty & Patents 3-4 General Instructions 6 Assembly 7-20 Operating Instructions Lighting 21-22 Cooking 23 Storage and/or Nonuse 23 Cleaning 23 LP Tank Information 24-26 a Troubleshooting & Maintenance Annual Maintenance 27 General Maintenance 28-30 Troubleshooting 31 Parts Listing 33 - Weber Spirit 530 LP Mica | Owner Manual - Page 6
location in your yard or on your patio. Portability means you can take your Weber Gas Barbecue with you if you move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your - Weber Spirit 530 LP Mica | Owner Manual - Page 7
missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank Bottom tray Two cooking grates LP tank filler adapter Control panel 7 - Weber Spirit 530 LP Mica | Owner Manual - Page 8
Left frame Right frame Wheel frame Leg frame Frame connector Work table Accessory rack Warming rack Five Flavorizer Bars Tank panel assembly Front panel Catch pan holder Catch pan Two drip pans Manifold bracket Thermometer ER Two wheels Fuel scale assembly Spacer bracket 8 WE B ER WE B - Weber Spirit 530 LP Mica | Owner Manual - Page 9
Check contents of hardware packs Two burner control knobs Two tool holders Eight tubing plugs (two are spares) Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) 1/4-20 x 2 inch bolt (actual size) Two 1/4-20 x 1 3/4 inch bolts (actual size) Six 1/4-20 x 1/2 inch bolts (actual - Weber Spirit 530 LP Mica | Owner Manual - Page 10
and a block of wood. Set one end of wheel frame on the block of wood (or other hard, protected surface). Put one wheel on axle, WEBER side facing up, and tap on one hubcap.Figure 1. Repeat with other wheel and hubcap. ER WE B ER WE B Step 3 Assemble top frame You will - Weber Spirit 530 LP Mica | Owner Manual - Page 11
Step 4 Continue frame assembly You will need: leg frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the leg frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame with the - Weber Spirit 530 LP Mica | Owner Manual - Page 12
If you answered YES to a, b and c, the burners are correctly aligned. If you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 6 Slide the cooking box to the left within the frame. Put the washer on the bolt. Take the spacer - Weber Spirit 530 LP Mica | Owner Manual - Page 13
Step 8 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at approximately the center of the length of the manifold. Place your hand underneath the bracket. Lift the manifold, bracket and cooking box slightly and hook the tab of the bracket onto the frame - Weber Spirit 530 LP Mica | Owner Manual - Page 14
Step 10 Add fuel scale assembly You will need: fuel scale assembly, two 1/4-20 wing nuts and two nylon washers. Slip the bolts on the back of the fuel scale assembly through the two small holes in the tank panel. Make sure indicator rod of fuel scale is on the left side of the wheel frame. Add - Weber Spirit 530 LP Mica | Owner Manual - Page 15
satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler LP tank where temperatures can reach 125° Fahrenheit (too hot to hold by hand - for example: do not leave the LP tank in a car on a hot day). For full instructions on safe handling of LP - Weber Spirit 530 LP Mica | Owner Manual - Page 16
be at 3, 6, or 9 o'clock. It should not be pointed up. Figure 17 (c). Figure 15 Step 15 Connect LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. Hook the LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten - Weber Spirit 530 LP Mica | Owner Manual - Page 17
. Figure 19 (d). ƽWARNING: If there is a leak at connections (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF and rinse connections with water. (a) (b) Figure 18 Check for leaks by wetting the - Weber Spirit 530 LP Mica | Owner Manual - Page 18
Step 17 Install Flavorizer Bars and Cooking Grates You will need: five Flavorizer Bars and two cooking grates. Set the Flavorizer Bars side to side in the cooking box. Figure 20. Step 18 Install the bottom tray You will need: bottom tray, catch pan holder, catch pan and one drip pan. Finger grip - Weber Spirit 530 LP Mica | Owner Manual - Page 19
Step 19 Install Lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 25. Hair pin cotter Hinge pin Step 20 Add - Weber Spirit 530 LP Mica | Owner Manual - Page 20
Step 21 Complete accessory installation You will need: work table, accessory rack, warming rack, four tubing plugs and thermometer. Set the accessory rack across the bottom braces in front of the frame connector. Figure 27 (a). Open the lid and set the warming rack into the slots at the rear of the - Weber Spirit 530 LP Mica | Owner Manual - Page 21
instructions barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized dealer. Crossover before turning on the LP tank valve. If they are not in the OFF position, when you turn on the LP tank valve, the - Weber Spirit 530 LP Mica | Owner Manual - Page 22
must be in the OFF position before turning on the LP tank valve. If they are not in the OFF position, when you turn on the LP tank valve, the excess flow control will activate, limiting the down and turn each burner control knob clockwise to OFF. 1 Manual Lighting 3 8 57 2 4 6 Figure 2 22 - Weber Spirit 530 LP Mica | Owner Manual - Page 23
See your Weber cookbook for detailed cooking instructions. Note: The LP tank is not disconnected from the Weber Gas Barbecue, the appliance and LP tank must be kept outdoors in a well-ventilated space. s The Weber Weber-Stephen Products Service MINERAL SPIRITS OR XYLENE. Rinse well after cleaning. 23 - Weber Spirit 530 LP Mica | Owner Manual - Page 24
while the tank is empty so you do not run out again. Removal of the LP tank 1) Close tank valve (turn clockwise). Figure 3 (a). 2) Slide the collar can cause serious bodily injury or death and damage to property. You will need: LP tank, a soap and water solution and a rag or brush to apply it. Note - Weber Spirit 530 LP Mica | Owner Manual - Page 25
the gas and contact Weber-Stephen Customer Service. Do not use LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance of the tank. If the tank has a defect, malfunctions, or you have a question regarding the tank, call the tank manufacturer's customer service - Weber Spirit 530 LP Mica | Owner Manual - Page 26
gas supplier can do this for you. Figure 7. If you have questions about spare LP tanks, please call Weber-Stephen Customer Service. D.O.T. Certification (example) DOT 4BA240 1/98 20 lb LP tank Date Tested Figure 7 s All LP tank supply systems must include a collar to protect the tank valve. s The - Weber Spirit 530 LP Mica | Owner Manual - Page 27
Service Center or authorized dealer. s Inspect the burners for correct flame pattern. Clean if necessary, following the procedures outlined in the "General Maintenance" section of this manual . DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn - Weber Spirit 530 LP Mica | Owner Manual - Page 28
the valve, thereby preventing spiders and other insects access to the burner tubes through the air shutter openings. Figure 10. Main Burner Flame Pattern The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown in Figure 11. Tips - Weber Spirit 530 LP Mica | Owner Manual - Page 29
. Figure 18a. Check proper assembly before fastening manifold in place. Figure 18b. (a) Valve Figure 15 Wing nuts f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16 - Weber Spirit 530 LP Mica | Owner Manual - Page 30
fin Check fit around valve Check fit around burner Figure 19 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. See Step - Weber Spirit 530 LP Mica | Owner Manual - Page 31
. (See Section "Periodic Cleaning".) Fuel scale shows that there is gas in the LP Check adjustment of fuel scale. tank, but tank is empty. Fuel scale must be adjusted with an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. - Weber Spirit 530 LP Mica | Owner Manual - Page 32
1 2 3 4 5 6 7 8 9 10 11 12 13 14-15 16 17 18 19 20 21 22 W E BE R W ® ® E BE R 32 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 31 38 39 40 41 42 43 44-45 46 47-48 49 50 51 - Weber Spirit 530 LP Mica | Owner Manual - Page 33
Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks 49 1/4-20 x 1 3/4 inch bolts (2) 50 Filler adapter 51 LP tank ṇWARNING: Use only Weber factory authorized parts. The use of any part that is not - Weber Spirit 530 LP Mica | Owner Manual - Page 34
- Weber Spirit 530 LP Mica | Owner Manual - Page 35
- Weber Spirit 530 LP Mica | Owner Manual - Page 36
problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
W
E
B
E
R
W
E
B
E
R
SPIRIT
™
530 Series
LP Gas Barbecue
Owner’s Manual
National
Association
PROPANE
GAS
®
92694
11/98
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
m
WARNING
1.
Do not store spare LP Cylinder within
10 feet (3m) of this appliance.
2.
Do not
store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, Keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death or damage to property.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.