Weber Spirit 700 LP Owner Manual
Weber Spirit 700 LP Manual
 |
View all Weber Spirit 700 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Spirit 700 LP manual content summary:
- Weber Spirit 700 LP | Owner Manual - Page 1
your warranty and any correspondence with the factory. SPIRIT™ 700 Series LP Gas Barbecue Owner's Manual ® NationalPROPANEGAS Association ƽ DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, Keep away from the appliance - Weber Spirit 700 LP | Owner Manual - Page 2
. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber Gas Barbecue. ƽ Do - Weber Spirit 700 LP | Owner Manual - Page 3
of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Cooking Grates and Flavorizer Bars, 3 years, All Remaining Parts, 5 years, when assembled and operated in accordance with the printed instructions - Weber Spirit 700 LP | Owner Manual - Page 4
PATENTS AND TRADEMARKS © 1999 Weber. Weber, , Flavorizer and Crossover are registered U.S. trademarks; Spirit, Gas Catcher, FlameCheck, and Spider Stopper are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Spirit is covered under the following - Weber Spirit 700 LP | Owner Manual - Page 5
. h) Catch pan catches excess grease. IMPORTANT NEW FEATURES: Your Weber Gas Barbecue is equipped with a new and improved LP tank connection, that has additional safety features. They are: 1. The connection of the barbecue to the LP tank can be made without the use of tools. 2. The new connection - Weber Spirit 700 LP | Owner Manual - Page 6
take your Weber Gas Barbecue with you if you move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before - Weber Spirit 700 LP | Owner Manual - Page 7
missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank Bottom tray Two cooking grates LP tank filler adapter Control panel 7 - Weber Spirit 700 LP | Owner Manual - Page 8
Left frame Right frame Wheel frame Leg frame Frame connector Molded work table Molded swing table assembly Support rod Accessory rack Warming rack Five Flavorizer Bars Tank panel assembly Front panel Catch pan holder Catch pan Two drip pans Manifold bracket Thermometer ER - Weber Spirit 700 LP | Owner Manual - Page 9
Check contents of hardware packs Three burner control knobs Two tool holders Seven tubing plugs (two are spares) Support rod holder Swing table end bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) 1/4-20 x 2 inch bolt (actual size) Two 1/4-20 x 1 3/4 inch bolts ( - Weber Spirit 700 LP | Owner Manual - Page 10
and a block of wood. Set one end of wheel frame on the block of wood (or other hard, protected surface). Put one wheel on axle, WEBER side facing up, and tap on one hubcap.Figure 1. Repeat with other wheel and hubcap. ER WE B ER WE B Step 3 Assemble top frame You will need - Weber Spirit 700 LP | Owner Manual - Page 11
You will need: front panel and two plastic buttons. Turn frame assembly right side up. Align the panel with the holes in the frame and insert the and frame. Figure 5. Plastic buttons Fuel scale decal View from rear of barbecue Figure 3 Step 5 Install tubing plugs You will need: two tubing plugs - Weber Spirit 700 LP | Owner Manual - Page 12
the frame brace. Figure 6. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame tested. answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 6 Slide the cooking box to the - Weber Spirit 700 LP | Owner Manual - Page 13
Step 8 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Figure 9. Place your hand underneath the bracket. Lift the manifold, bracket and cooking box slightly and hook the tab of the bracket onto the frame brace. Frame brace - Weber Spirit 700 LP | Owner Manual - Page 14
tank panel. Make sure indicator rod of fuel scale is on the left side of the wheel frame. Add washers then wing nuts and tighten. Figure 12 Step 11 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the - Weber Spirit 700 LP | Owner Manual - Page 15
the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look up gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized - Weber Spirit 700 LP | Owner Manual - Page 16
be at 3, 6, or 9 o'clock. It should not be pointed up. Figure 17 (c). Figure 15 Step 15 Connect LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. Hook the LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten - Weber Spirit 700 LP | Owner Manual - Page 17
for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure 19 (c). d) The hose to regulator connection. Figure 19 (d). ƽWARNING: If there - Weber Spirit 700 LP | Owner Manual - Page 18
need: five Flavorizer Bars and two cooking grates. Set the Flavorizer Bars side to side in the cooking box. Figure 20. Step 18 Install the bottom tray one drip pan. Figure 20 Finger grip on front edge of bottom tray Front side of catch pan holder Figure 22 Hook the ends of the catch pan holder - Weber Spirit 700 LP | Owner Manual - Page 19
hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 25. Hair pin cotter Hinge pin - Weber Spirit 700 LP | Owner Manual - Page 20
table end bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. Install support rod holder on leg. Figure 28 (d). Hook the support rod into the support rod holder. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod - Weber Spirit 700 LP | Owner Manual - Page 21
the bottom braces in front of the frame connector. Figure 29 (a). Open the lid and set the warming rack into the slots at the rear of the cooking box. Figure 29 (b). Set the work table onto the left side rails and work table spacer. Figure 29 (c). Note: Work table should rest - Weber Spirit 700 LP | Owner Manual - Page 22
instructions are on the control panel. ƽ DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service - Weber Spirit 700 LP | Owner Manual - Page 23
Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) Open the lid. Figure 2. 2) Check that fuel scale reads - Weber Spirit 700 LP | Owner Manual - Page 24
Weber cookbook for detailed cooking instructions gas must be turned off at the LP tank when the Weber Gas Barbecue is not in use. s When the Weber Gas Barbecue is stored indoors, the gas supply must be DISCONNECTED and the LP tank stored outdoors in a well-ventilated space. s LP Lid - While lid - Weber Spirit 700 LP | Owner Manual - Page 25
tanks are not compatible with your barbecue connection. Scale setting wing nut Tank lock wing nut Connecting the filled LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. ƽ DANGER Do not use an open flame to check for gas leaks. Be sure there are no sparks or - Weber Spirit 700 LP | Owner Manual - Page 26
a leak. If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance - Weber Spirit 700 LP | Owner Manual - Page 27
, bugs etc. Liquid Propane (LP) Tank(s) s The LP tank and connections supplied with your Weber Gas Barbecue have been designed and tested to meet government, American Gas Association and Underwriters Laboratories requirements. s Replacement LP tanks supplied by Weber satisfy the requirements. Check - Weber Spirit 700 LP | Owner Manual - Page 28
Maintenance" section of this manual. s Check all gas fittings for leaks. ƽ DANGER Do not use an open flame to check for gas leaks. Be sure there are OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. (d) Figure 8 Inspection and Cleaning of the Weber Spider Stopper - Weber Spirit 700 LP | Owner Manual - Page 29
ports are fully open. Figure 13 ƽCAUTION: Do not enlarge the burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Remove the screws holding the control panel in - Weber Spirit 700 LP | Owner Manual - Page 30
. Figure 18a. Check proper assembly before fastening manifold in place. Figure 18b. (a) Valve Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16 - Weber Spirit 700 LP | Owner Manual - Page 31
Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step"Check for gas leaks"). Crossover Ignition System Operations If the Crossover - Weber Spirit 700 LP | Owner Manual - Page 32
. (See Section "Periodic Cleaning".) Fuel scale shows that there is gas in the LP Check adjustment of fuel scale. tank, but tank is empty. Fuel scale must be adjusted with an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. 32 - Weber Spirit 700 LP | Owner Manual - Page 33
- Weber Spirit 700 LP | Owner Manual - Page 34
1 2 3 4 5 6 7 8 9 10 11 12-13 14 15 16 17 18 19 20 21 22 ® ® E BE R W E BE R W 29 23 24 25 26 27 28 30 34 13 31 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 62 53 52 58-59 60 61 - Weber Spirit 700 LP | Owner Manual - Page 35
1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 (800) 446-1071 1 Lid (assembly) 2 Lid handle 3 Warming rack 4 Flavorizer bars - Weber Spirit 700 LP | Owner Manual - Page 36
for choosing a Weber Barbecue. Our family here at Weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
W
E
B
E
R
W
E
B
E
R
SPIRIT
™
700 Series
LP Gas Barbecue
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
National
Association
PROPANE
GAS
®
98583
3/99
m
WARNING
1.
Do not store spare LP Cylinder within
10 feet (3m) of this appliance.
2.
Do not
store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, Keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death or damage to property.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.