Weber Spirit 700 LX Owner Manual

Weber Spirit 700 LX Manual

Get Weber Spirit 700 LX PDF manuals and user guides View all Weber Spirit 700 LX manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Spirit 700 LX manual content summary:

  • Weber Spirit 700 LX | Owner Manual - Page 1
    . SPIRIT™ 700 LX Series LP Gas Barbecue Owner's Manual WEB ER ER WEB ® NationalPROPANEGAS Association WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must
  • Weber Spirit 700 LX | Owner Manual - Page 2
    assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and away from LP tank. 2. Do not attempt to correct the problem yourself. 3. Call your fire department.
  • Weber Spirit 700 LX | Owner Manual - Page 3
    the printed instructions accompanying it. Weber may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE. This Limited Warranty shall be limited to the repair or replacement of parts which prove defective under normal use and service and which
  • Weber Spirit 700 LX | Owner Manual - Page 4
    PATENTS AND TRADEMARKS © 1999 Weber. Weber, , Flavorizer and Crossover are registered U.S. trademarks; Spirit, Gas Catcher, FlameCheck, and Spider Stopper are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Weber Gas Barbecues are covered under
  • Weber Spirit 700 LX | Owner Manual - Page 5
    Instructions 6 Assembly 7-21 Operating Instructions Lighting 22-23 Cooking 24 Storage and/or Nonuse 24 Cleaning 24 LP Tank Information 25-27 Troubleshooting & Maintenance Annual Maintenance 28 General Maintenance 29-31 Troubleshooting 32 Parts NEW FEATURES: Your Weber Gas Barbecue is
  • Weber Spirit 700 LX | Owner Manual - Page 6
    to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas Barbecue. Improper assembly can be dangerous. s Not for use by children
  • Weber Spirit 700 LX | Owner Manual - Page 7
    to our products, unfortunately an occasional error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP
  • Weber Spirit 700 LX | Owner Manual - Page 8
    Left frame Right frame Wheel frame Leg frame Frame connector Work table Swing table assembly Support rod Accessory racks (2) Warming rack Flavorizer Bars (5) Tank panel assembly Front panel Catch pan holder Catch pan Drip pans (2) Manifold bracket Thermometer ER Wheels (2) Fuel
  • Weber Spirit 700 LX | Owner Manual - Page 9
    Check contents of hardware packs Burner control knobs (3) Tool holders (2) Tubing plugs (7) (two are spares) Support rod holder Swing table end bracket Hinge pins (2) (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) 1/4-20 x 2 inch bolt (actual size) 1/4-20 x 1 3/4 inch bolts (2) (actual
  • Weber Spirit 700 LX | Owner Manual - Page 10
    and a block of wood. Set one end of wheel frame on the block of wood (or other hard, protected surface). Put one wheel on axle, WEBER side facing up, and tap on one hubcap.Figure 1. Repeat with other wheel and hubcap. ER ER WE B Step 3 Assemble top frame You will need
  • Weber Spirit 700 LX | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: leg frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the leg frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame with the
  • Weber Spirit 700 LX | Owner Manual - Page 12
    If you answered YES to a, b and c, the burners are correctly aligned. If you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 6 Slide the cooking box to the left within the frame. Put the washer on the bolt. Take the spacer
  • Weber Spirit 700 LX | Owner Manual - Page 13
    Step 8 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Figure 9. Place your hand underneath the bracket. Lift the manifold, bracket and cooking box slightly and hook the tab of the bracket onto the frame brace. Frame brace
  • Weber Spirit 700 LX | Owner Manual - Page 14
    igniter. Insert the top of the igniter up through the large part of the keyhole in the frame brace. Figure 13 (b). Loosen the igniter lock nut and slide the igniter into the small part of the keyhole. Figure 13 (c). Tighten the igniter lock nut. Figure 13.
  • Weber Spirit 700 LX | Owner Manual - Page 15
    tank manufacturer has not resolved the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to in a car on a hot day). For full instructions on safe handling of LP tanks, see Section "Safe handling tips for LP gas". F F
  • Weber Spirit 700 LX | Owner Manual - Page 16
    Step 14 Check that all burner valves are off Valves are shipped in the OFF position, but you should check to be sure. Put the knob on each valve. Check by pushing down and turning clockwise. If they do not turn they are off, proceed to the next step. Figure 15. Route the hose so it will not
  • Weber Spirit 700 LX | Owner Manual - Page 17
    . Figure 19 (d). ƽWARNING: If there is a leak at connections (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF and rinse connections with water. (a) (b) Figure 18 Check for leaks by wetting the
  • Weber Spirit 700 LX | Owner Manual - Page 18
    Step 17 Install Flavorizer Bars and Cooking Grates You will need: five Flavorizer Bars and two cooking grates. Set the Flavorizer Bars side to side in the cooking box. Figure 20. Step 18 Install the bottom tray You will need: bottom tray, catch pan holder, catch pan and one drip pan. Finger grip
  • Weber Spirit 700 LX | Owner Manual - Page 19
    Step 19 Install Lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 25. Hair pin cotter Hinge pin Step 20 Add
  • Weber Spirit 700 LX | Owner Manual - Page 20
    table end bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. Install support rod holder on leg. Figure 28 (d). Hook the support rod into the support rod holder. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod
  • Weber Spirit 700 LX | Owner Manual - Page 21
    Step 22 Complete accessory installation You will need: work table, two accessory racks, warming rack, three tubing plugs and thermometer. Set the accessory rack across the bottom braces in front of the frame connector. Figure 29 (a). Set the second accessory rack across the bottom braces in the back
  • Weber Spirit 700 LX | Owner Manual - Page 22
    Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure way, do not use the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized dealer. Crossover Ignition System 1 3 8
  • Weber Spirit 700 LX | Owner Manual - Page 23
    Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if burner. To Extinguish Turn gas supply OFF at the source, then push down and turn each burner control knob clockwise to OFF. Manual Lighting 1 3 8 4 57 2 6 Figure 2 23
  • Weber Spirit 700 LX | Owner Manual - Page 24
    CENTER off, and BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your cooking box, for are available through your retailer or the Weber-Stephen Products Service Center. Outside surfaces - Use a SPIRITS OR XYLENE. Rinse well after cleaning. 24
  • Weber Spirit 700 LX | Owner Manual - Page 25
    Refilling the LP tank We recommend that you refill before the scale indicator reaches "E". Note - If you run out of fuel, check the indicator setting and/or adjust the fuel scale indicator setting with the scale setting wing nut, while the tank is empty so you do not run out again. Removal of the LP
  • Weber Spirit 700 LX | Owner Manual - Page 26
    watching for bubbles. If bubbles form or if a bubble grows there is a leak. If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank
  • Weber Spirit 700 LX | Owner Manual - Page 27
    five years. Your LP gas supplier can do this for you. Figure 7. If you have questions about spare LP tanks, please call Weber-Stephen Customer Service. D.O.T. Certification (example) DOT 4BA240 1/97 20 lb LP tank Figure 7 Date Tested s All LP tank supply systems must include a collar to protect
  • Weber Spirit 700 LX | Owner Manual - Page 28
    Service Center or authorized dealer. s Inspect the burners for correct flame pattern. Clean if necessary, following the procedures outlined in the "General Maintenance" section of this manual . DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn
  • Weber Spirit 700 LX | Owner Manual - Page 29
    the valve, thereby preventing spiders and other insects access to the burner tubes through the air shutter openings. Figure 10. Main Burner Flame Pattern The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown in Figure 11. Tips
  • Weber Spirit 700 LX | Owner Manual - Page 30
    . Figure 18a. Check proper assembly before fastening manifold in place. Figure 18b. (a) Valve Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16
  • Weber Spirit 700 LX | Owner Manual - Page 31
    20. Check fit around burner Figure 19 White wire Black wire ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See
  • Weber Spirit 700 LX | Owner Manual - Page 32
    TROUBLESHOOTING Problem Check Cure Burners burn with a yellow or orange Inspect Weber Spider Stopper flame, in conjunction with the smell of gas. Guards for possible obstructions. (Blockage of holes.) Clean Weber which is part of the . Refer to "Lighting Instructions". Burner does not light
  • Weber Spirit 700 LX | Owner Manual - Page 33
  • Weber Spirit 700 LX | Owner Manual - Page 34
    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15-16 17 18 19 20 21 22 23 24 25 ® ® E BE R W E BE R W 26 27 28 29 32 30 31 33 34 11 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 44 52 53 54-55 56 57
  • Weber Spirit 700 LX | Owner Manual - Page 35
    part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual (11) 14 Leg frame 15 Swing table assembly 16 Support rod holder 17 Support rod 18 Bottom tray 19 Catch pan holder 20 Catch pan
  • Weber Spirit 700 LX | Owner Manual - Page 36
    problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
W
E
B
E
R
W
E
B
E
R
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
National
Association
PROPANE
GAS
®
SPIRIT
™
700 LX Series
LP Gas Barbecue
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
98639
4/99