Weber Summit 425 LP Owner Manual

Weber Summit 425 LP Manual

Get Weber Summit 425 LP PDF manuals and user guides View all Weber Summit 425 LP manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Summit 425 LP manual content summary:

  • Weber Summit 425 LP | Owner Manual - Page 1
    SUMMITTM425 & 450 LP Gas Barbecues Operating Guide Read before assembly WEBER EBER EBER W WEBER W Summit 425 LP Serial Number Summit 450 LP Serial Number ƽ DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, Keep away from
  • Weber Summit 425 LP | Owner Manual - Page 2
    using. See instructions in this manual for correct procedures. s Do not operate the Weber Gas Barbecue if there is a gas leak present. s Do not use a flame to check for gas leaks. s Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber Gas Barbecue
  • Weber Summit 425 LP | Owner Manual - Page 3
    SECTION AT THIS TIME Lighting 6 Crossover Ignition System 6 To Extinguish 6 Manual Lighting 7 To Extinguish 7 Cooking 8 Storage 8 Cleaning 8 Steam-N-Chips Replacing Main Burners Crossover Ignition System Operations Troubleshooting Patents and Trademarks 9 10-13 10 10 11 11 11 13
  • Weber Summit 425 LP | Owner Manual - Page 4
    any problems with parts or assembly. Call our toll free number. For quicker service, please have your owner's manual and serial number available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish you the best in outdoor cooking enjoyment. Weber
  • Weber Summit 425 LP | Owner Manual - Page 5
    Weber Gas Barbecue is designed for use with liquid propane (LP) gas only. Do not use with natural (piped in city) gas. The valves, orifices, hose and regulator are for LP gas only. s Do not use with charcoal fuel. For Installation in Canada These instructions TO YOUR STEP-BYSTEP GUIDE AT THIS TIME
  • Weber Summit 425 LP | Owner Manual - Page 6
    valve. If they are not in the OFF position, when you turn on the LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank valve and burner control knobs and start over. ƽ DANGER When the excess flow
  • Weber Summit 425 LP | Owner Manual - Page 7
    the LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank matchlight hole in control panel Hole in cooking box assembly 3 Figure 2 Manual Lighting 1 4 2 Control panel Left burner tube Figure 3 9) Observe
  • Weber Summit 425 LP | Owner Manual - Page 8
    grease to avoid a grease fire in the bottom tray. STORAGE s The gas must be turned off at the LP cylinder when the Weber Gas Barbecue is not in use. s When the Weber Gas Barbecue is stored indoors, the gas supply must be DISCONNECTED and the LP cylinder stored outdoors in a well-ventilated space
  • Weber Summit 425 LP | Owner Manual - Page 9
    the Steam-N-Chips Smoker. To a lesser degree a "smoke" residue will accumulate on the inside of your Weber Gas Barbecue. This residue need not be removed and will not adversely affect the function of your Weber Gas Barbecue. Note - Remove the Steam-N-Chips Smoker when it is not in use. If it is left
  • Weber Summit 425 LP | Owner Manual - Page 10
    They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5. This could result in a screen becomes damaged or cannot be cleaned, call Weber-Stephen Products Customer Service for replacement parts. 10
  • Weber Summit 425 LP | Owner Manual - Page 11
    1. Your Weber Gas Barbecue must be OFF and cool. 2. Turn OFF gas at source. 3. Disconnect regulator. 4. To remove control panel refer to "Remove the control panel and the front panel" in the Step-By-Step Guide. 5. Remove cooking grates. 6. Remove Flavorizer bars. 7. Remove the manifold
  • Weber Summit 425 LP | Owner Manual - Page 12
    MAINTENANCE 9. Pull the manifold out of the burners. Figure 12. 10. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossover tube. Figure 13 (a). Pull out of here Manifold Figure 12 Crossover tube Figure 13 12
  • Weber Summit 425 LP | Owner Manual - Page 13
    openings must be positioned properly over the valve orifices. Figure 15 (a). Check proper assembly before fastening manifold in place. Figure 15 (b). (a) Valve System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 16 Burner Orifice (b) Figure 15 13
  • Weber Summit 425 LP | Owner Manual - Page 14
    TROUBLESHOOTING Problem Check Cure Burners burn with a yellow or orange flame, Inspect Spider/Insect Screens for in conjunction with the smell of gas device, which is part of the barbecue to problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. 14
  • Weber Summit 425 LP | Owner Manual - Page 15
  • Weber Summit 425 LP | Owner Manual - Page 16
    , Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are covered by U.S. Patent Nos. 4,677
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
SUMMIT
TM
425 & 450
LP Gas Barbecues
Operating Guide
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
92776
10/98
Serial Number
Serial Number
Summit 425 LP
Summit 450 LP
R
A P P R O V E D
CANADIAN GAS ASSOCIATION
®
National
Association
PROPANE
GAS
Read before assembly
m
WARNING
1.
Do not store spare LP Cylinder within
10 feet (3m) of this appliance.
2.
Do not
store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, Keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death or damage to property.
NOTICE TO INSTALLER:These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.