Weber Summit 425 NG Owner Manual

Weber Summit 425 NG Manual

Get Weber Summit 425 NG PDF manuals and user guides View all Weber Summit 425 NG manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Summit 425 NG manual content summary:

  • Weber Summit 425 NG | Owner Manual - Page 1
    ODULES Operating Guide Read before assembly Summit 4 Burner NG Serial Number Summit 6 Burner NG Serial Number WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must
  • Weber Summit 425 NG | Owner Manual - Page 2
    or disconnected LP tank under or near this barbecue. s Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. s After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See
  • Weber Summit 425 NG | Owner Manual - Page 3
    TIME Lighting 6-7 Crossover Ignition System 6-7 To Extinguish 7 Manual Lighting 8-9 To Extinguish 9 Cooking 10 Storage 10 Cleaning Operations Troubleshooting Exploded Views and Replacement Parts List Summit 425 NG Summit 450 NG Summit 475 NG Summit 625 NG Summit 650 NG Summit 675 NG
  • Weber Summit 425 NG | Owner Manual - Page 4
    any problems with parts or assembly. Call our toll free number. For quicker service, please have your owner's manual and serial number available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish you the best in outdoor cooking enjoyment. Weber
  • Weber Summit 425 NG | Owner Manual - Page 5
    instructions Weber Gas Barbecue is not intended to be installed in or on recreational vehicles and/or boats. s Keep this grill away from combustible materials when in use at a minimum of 24 inches of the top, bottom, back or sides. Note: See Summit 475 and 675 Step-by-Step Guide manual shutoff
  • Weber Summit 425 NG | Owner Manual - Page 6
    LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. Summary lighting instructions are on the control panel. High Medium Low . Crossover Ignition System Summit 425 or 450 Crossover Ignition System Summit 475 Crossover Ignition System Summit 625 or 650 Crossover Ignition System Summit 675 Figure 1
  • Weber Summit 425 NG | Owner Manual - Page 7
    LIGHTING (CONTINUED) 3) Turn on gas supply. WARNING: Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue. 4) Select Heat Zone. 5) Push LEFT burner control knob down and turn to START/HI. 6) Push the Crossover Ignition
  • Weber Summit 425 NG | Owner Manual - Page 8
    MANUAL LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. Summary lighting instructions are on the control panel High Medium Low of nonflammable items only. Manual Lighting Summit 425 or 450 Manual Lighting Summit 475 Manual Lighting Summit 625 or 450 Manual Lighting Summit 475 Figure 2 1) Open the
  • Weber Summit 425 NG | Owner Manual - Page 9
    MANUAL LIGHTING (CONTINUED) 3) Turn gas supply valve on. 4) Select heat zone. 5) Put a turn to H (high). matchlight hole in control panel Hole in cooking box assembly Control panel Left burner tube Figure 3 8) Observe if LEFT burner has ignited by looking through matchlight hole. WARNING: If LEFT
  • Weber Summit 425 NG | Owner Manual - Page 10
    Flavorizer Bars are available through your retailer or the Weber-Stephen Customer Service Center. Outside surfaces - Use a warm soapy or submerge in water. Inside cooking module - Brush any debris off of burners tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside of cooking box with warm
  • Weber Summit 425 NG | Owner Manual - Page 11
    Steam-N-Chips Smoker. To a lesser degree a "smoke" residue will accumulate on the inside of your Weber Gas Barbecue. This residue need not be removed and will not adversely affect the function of your Weber Gas Barbecue. Water Pan Steam-N-Chips Body Figure 4 Place wood in here Light the barbecue
  • Weber Summit 425 NG | Owner Manual - Page 12
    Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5. This could result in a fire
  • Weber Summit 425 NG | Owner Manual - Page 13
    blue Replacing Main Burners 1. Your Weber Gas Barbecue must be OFF and the front panel" in the Step-By-Step Guide. 4. Remove cooking grates. 5. Remove Flavorizer bars uniform the length of the burner tube, follow the burner cleaning procedures. a flashlight. Figure 8. Summit 4 Burner Figure 8 Clean
  • Weber Summit 425 NG | Owner Manual - Page 14
    . 9. Pull the manifold out of the burners. Figure 13. White wire Figure 11 Black wire 8. Unlatch the Spider Stopper Guards and remove. Figure 12. Manifold Summit 4 Burner Figure 12 Manifold Summit 6 Burner Figure 13 14
  • Weber Summit 425 NG | Owner Manual - Page 15
    10. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossover tube. Figure 14 (a). Pull out of here (a) Crossover tube 12. To reinstall the burners, reverse steps 3 through 11. CAUTION: The burner openings must be positioned properly over the
  • Weber Summit 425 NG | Owner Manual - Page 16
    is loose in the frame. Tighten if necessary; See Step "Install igniter" for correct procedure. If the Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 18 16
  • Weber Summit 425 NG | Owner Manual - Page 17
    TROUBLESHOOTING Problem Check Cure burner is on HIGH. Flames do not run the whole length of the burner tube. Are burners clean? Clean burners. (See Maintenance Section.) Inside of lid If the problem cannot be corrected using these methods, please contact your Weber-Stephen Customer Service. 17
  • Weber Summit 425 NG | Owner Manual - Page 18
    EXPLODED VIEWS FOR SUMMIT 425 NG 18
  • Weber Summit 425 NG | Owner Manual - Page 19
    to the store. Call the Weber Customer Service Center toll free 1-888-33-SUMMIT (1-888-337-8664) to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine
  • Weber Summit 425 NG | Owner Manual - Page 20
    EXPLODED VIEWS FOR SUMMIT 450 NG 20
  • Weber Summit 425 NG | Owner Manual - Page 21
    to the store. Call the Weber Customer Service Center toll free 1-888-33-SUMMIT (1-888-337-8664) to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine
  • Weber Summit 425 NG | Owner Manual - Page 22
    EXPLODED VIEWS FOR SUMMIT 475 NG 22
  • Weber Summit 425 NG | Owner Manual - Page 23
    REPLACEMENT PARTS LIST FOR SUMMIT 475 NG 1 Lid 2 Thermometer 3 Flavorizer bar / cooking grate holder (2) 4 Flavorizer bar (7) 5 Cooking box 6 Crossover tube (2) 7 Left burner (2) 8 Right burner (2) 9 Burner control knob (4) 10 Igniter (2) 11 Igniter lock nut (2) 12 Igniter wire
  • Weber Summit 425 NG | Owner Manual - Page 24
    EXPLODED VIEWS FOR SUMMIT 625 NG 24
  • Weber Summit 425 NG | Owner Manual - Page 25
    to the store. Call the Weber Customer Service Center toll free 1-888-33-SUMMIT (1-888-337-8664) to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine
  • Weber Summit 425 NG | Owner Manual - Page 26
    EXPLODED VIEWS FOR SUMMIT 650 NG 26
  • Weber Summit 425 NG | Owner Manual - Page 27
    to the store. Call the Weber Customer Service Center toll free 1-888-33-SUMMIT (1-888-337-8664) to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine
  • Weber Summit 425 NG | Owner Manual - Page 28
    EXPLODED VIEWS FOR SUMMIT 675 NG 28
  • Weber Summit 425 NG | Owner Manual - Page 29
    to the store. Call the Weber Customer Service Center toll free 1-888-33-SUMMIT (1-888-337-8664) to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine
  • Weber Summit 425 NG | Owner Manual - Page 30
  • Weber Summit 425 NG | Owner Manual - Page 31
  • Weber Summit 425 NG | Owner Manual - Page 32
    , Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are covered by U.S. Patent Nos. 4,677,964; 4,727,853; 4,777,927; 4,829,978; 4,860,724; 4,941,817; and
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
NOTICE TO INSTALLER:
These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING:
Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING:
Do not try to light this appliance
without reading "Lighting" instructions section
of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY:
Do not store or use
gasoline or other flammable vapors and liquids
in the vicinity of this or any other appliance.
S
U
M
MIT
™
4 BURNER
&6 BURNER
Serial Number
Serial Number
Summit 4 Burner NG
Summit 6 Burner NG
97080
4/97
Read before assembly
NATURAL GAS COOKING M ODULES
Operating Guide