Weber Summit 650 NG Owner Manual

Weber Summit 650 NG Manual

Get Weber Summit 650 NG PDF manuals and user guides View all Weber Summit 650 NG manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Summit 650 NG manual content summary:

  • Weber Summit 650 NG | Owner Manual - Page 1
    Summit 4 Burner NG Serial Number WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with the owner and the owner should keep them for future use. THIS GAS
  • Weber Summit 650 NG | Owner Manual - Page 2
    . s After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures. s Do not operate the Weber Gas Barbecue if there is a gas leak present. s Do not use a flame to check for
  • Weber Summit 650 NG | Owner Manual - Page 3
    5 Natural Gas Supply Testing 5 *REFER TO YOUR STEP-BY-STEP SECTION AT THIS TIME Lighting 6-7 Crossover Ignition System 6-7 To Extinguish 7 Manual Lighting Replacing Main Burners Crossover Ignition System Operations Troubleshooting Patents and Trademarks 11 12-16 12 12 13 13 13 16
  • Weber Summit 650 NG | Owner Manual - Page 4
    any problems with parts or assembly. Call our toll free number. For quicker service, please have your owner's manual and serial number available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish you the best in outdoor cooking enjoyment. Weber
  • Weber Summit 650 NG | Owner Manual - Page 5
    or overhang. s Your Weber Gas Barbecue is not intended to be installed in or on recreational vehicles and/or boats. s Keep this grill away from combustible materials when in use at a minimum of 24 inches of the top, bottom, back or sides. Note: See Summit 475 and 675 Step-by-Step Guide for specific
  • Weber Summit 650 NG | Owner Manual - Page 6
    instructions are on the control panel. High Medium Low Off ƽ DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas (Push each burner control knob down and turn clockwise.) 3) Turn on gas supply. ƽWARNING: Do not lean over open barbecue. Keep your face
  • Weber Summit 650 NG | Owner Manual - Page 7
    LIGHTING (CONTINUED) 1 Crossover Ignition System 2 Summit 425 or 450 3 1 Crossover Ignition System 2 Summit 475 3 1 Crossover Ignition System 2 Summit 625 or 650 3 1 2 Crossover Ignition System Summit 675 Figure 1 3 7
  • Weber Summit 650 NG | Owner Manual - Page 8
    EACH HEAT ZONE OPERATES INDEPENDENTLY. Summary lighting instructions are on the control panel. High Medium Low Off ƽ DANGER 2 Failure to open lid while igniting the Manual Lighting Summit 425 or 450 barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light
  • Weber Summit 650 NG | Owner Manual - Page 9
    MANUAL LIGHTING (CONTINUED) 5) Put a match in the match holder and strike the match. 6) Insert match holder and lit match through matchlight hole to ignite LEFT burner. Figure 3. matchlight hole in control panel Hole in cooking box assembly Control panel Left burner tube Figure 3 ƽWARNING: Do not
  • Weber Summit 650 NG | Owner Manual - Page 10
    is secured in the OFF position. When the Weber Gas Barbecue is stored indoors, the gas supply MUST BE DISCONNECTED. s After a period of storage and/or nonuse the Weber Gas Grill should be checked for gas leaks and any obstructions in the burner tubes before using. (See Maintenance Section.) s Check
  • Weber Summit 650 NG | Owner Manual - Page 11
    the Steam-N-Chips Smoker. To a lesser degree a "smoke" residue will accumulate on the inside of your Weber Gas Barbecue. This residue need not be removed and will not adversely affect the function of your Weber Gas Barbecue. Note - Remove the Steam-N-Chips Smoker when it is not in use. If it is left
  • Weber Summit 650 NG | Owner Manual - Page 12
    venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of to the burner tubes through the air shutter openings. Figure 6. Weber Spider/Insect screen Figure debris and dirt out of the burner tube. Once the spider/insect screens and burners are
  • Weber Summit 650 NG | Owner Manual - Page 13
    blue Replacing Main Burners 1. Your Weber Gas Barbecue must be OFF and cool. 2. Turn OFF gas at source. 3. To remove tube, follow the burner cleaning procedures. Main Burner Cleaning Procedure Turn off the gas supply. Remove the manifold. Look inside each burner with a flashlight. Figure 8. Summit
  • Weber Summit 650 NG | Owner Manual - Page 14
    MAINTENANCE 7. Disconnect white and black wire from each igniter. Figure 11. 8. Pull the manifold out of the burners. Figure 12. White wire Figure 11 Black wire Manifold Summit 4 Burner Manifold Summit 6 Burner Figure 12 14
  • Weber Summit 650 NG | Owner Manual - Page 15
    MAINTENANCE 9. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossover tube. Figure 13 (a). Pull out of here (a) Crossover tube 11. To reinstall the burners, reverse steps 3 through 10. ƽCAUTION: The burner openings must be positioned properly over
  • Weber Summit 650 NG | Owner Manual - Page 16
    is loose in the frame. Tighten if necessary; See Step "Install igniter" for correct procedure. If the Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 16 16
  • Weber Summit 650 NG | Owner Manual - Page 17
    TROUBLESHOOTING Problem Check Cure Burners burn with a yellow or orange flame, in Inspect Spider/Insect Screens for conjunction with the smell of gas length of the burner tube. Inside of lid problem cannot be corrected using these methods, please contact your Weber-Stephen Customer Service. 17
  • Weber Summit 650 NG | Owner Manual - Page 18
  • Weber Summit 650 NG | Owner Manual - Page 19
  • Weber Summit 650 NG | Owner Manual - Page 20
    , Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are covered by U.S. Patent Nos. 4,677
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
W
E
B
E
R
W
E
B
E
R
SUMMIT
™
4 BURNER
& 6 BURNER
Serial Number
Serial Number
Summit 4 Burner NG
Summit 6 Burner NG
92774
10/98
®
R
A P P R O V E D
CANADIAN GAS ASSOCIATION
W
E
B
E
R
W
E
B
E
R
Read before assembly
NATURAL GAS COOKING MODULES
Operating Guide
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
m
WARNING
1.
Do not store spare LP Cylinder within
10 feet (3m) of this appliance.
2.
Do not
store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, Keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death or damage to property.
NOTICE TO INSTALLER:These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.