Weber Summit FT 600 NG Operation Guide
Weber Summit FT 600 NG Manual
 |
View all Weber Summit FT 600 NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit FT 600 NG manual content summary:
- Weber Summit FT 600 NG | Operation Guide - Page 1
Gas Barbecues Operating Guide Read before assembly Summit 400 NG Serial Number Summit 600 NG Serial Number WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be - Weber Summit FT 600 NG | Operation Guide - Page 2
. s After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures. s Do not operate the Weber Gas Barbecue if there is a gas leak present. s Do not use a flame to check for - Weber Summit FT 600 NG | Operation Guide - Page 3
THIS TIME Lighting 6 Crossover Ignition System 6 To Extinguish 6 Manual Lighting 7 To Extinguish 7 Cooking 8 Storage 8 Cleaning 8 Maintenance Ignition System Operations 13 Troubleshooting 14 Exploded Views and Replacement parts Lists 16-19 Summit 400 NG Summit 600 NG 16-17 18- - Weber Summit FT 600 NG | Operation Guide - Page 4
years, when assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your Service staff is prepared to help you with any problems with parts or assembly. Call our toll free number. For quicker service, please have your owner's manual - Weber Summit FT 600 NG | Operation Guide - Page 5
For Installation in Canada These instructions, while generally acceptable, do not the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas the burner tubes before using. Refer to Maintenance Section. REFER TO YOUR STEP-BYSTEP GUIDE AT THIS - Weber Summit FT 600 NG | Operation Guide - Page 6
LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. Summary lighting instructions are on the control panel. High Medium Low Off DA N G E R Failure to open sliding work surfaces while igniting the barbecue, or not waiting 5 minutes to - Weber Summit FT 600 NG | Operation Guide - Page 7
MANUAL LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. Summary lighting instructions are on the control panel High Medium Low Off hole in control panel Hole in cooking box assembly Control panel Left burner tube Figure 3 8) Observe if LEFT burner has ignited by looking through matchlight hole - Weber Summit FT 600 NG | Operation Guide - Page 8
Bars are available through your retailer or the Weber-Stephen Customer Service Center. Outside surfaces - Use a warm soapy water solution or submerge in water. Inside cooking module - Brush any debris off of burners tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside of cooking box with warm - Weber Summit FT 600 NG | Operation Guide - Page 9
Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 4. This could result in a fire - Weber Summit FT 600 NG | Operation Guide - Page 10
the flames do not appear to be uniform the length of the burner tube, follow the burner cleaning procedures. Replacing the Burners 1. Your Weber Gas "Remove the control panel and the front panel" in the Step-By-Step Guide. 5. Remove splash guards. 6. Remove cooking grates. 7. Remove Flavorizer bars. - Weber Summit FT 600 NG | Operation Guide - Page 11
MAINTENANCE 9. Disconnect white and black wire from each igniter. Figure 10. 11. Pull the manifold out of the burners. Figure 12. White wire Black wire Figure 10 10. Unlatch the Spider Stopper Guards and remove. Figure 11. Manifold Summit 400 Figure 11 Manifold Summit 400 Figure 12 11 - Weber Summit FT 600 NG | Operation Guide - Page 12
MAINTENANCE 12. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossover tube. Figure 13 (a). Pull out of here 14. To reinstall the burners, reverse steps 3 through 13. CAUTION: The burner openings must be positioned properly over the - Weber Summit FT 600 NG | Operation Guide - Page 13
the frame. Tighten if necessary; See Step "Install igniter" for correct procedure. If the Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 17 13 - Weber Summit FT 600 NG | Operation Guide - Page 14
TROUBLESHOOTING Problem Check Cure burner is on HIGH. Flames do not run the whole length of the burner tube. Are burners clean? Clean burners. (See Maintenance Section.) Inside of lid appears If the problem cannot be corrected using these methods, please contact your Weber-Stephen Customer - Weber Summit FT 600 NG | Operation Guide - Page 15
15 - Weber Summit FT 600 NG | Operation Guide - Page 16
EXPLODED VIEW FOR SUMMIT 400 NG 16 - Weber Summit FT 600 NG | Operation Guide - Page 17
PARTS LIST FOR SUMMIT 400 NG 1 Cooking grate 2 Flavorizer Bars Cooking grate holders (2) 32 Right work surface 33 Crossover tubes (2) 34 Left burner (2) 35 Right burner (2) 36 manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service - Weber Summit FT 600 NG | Operation Guide - Page 18
EXPLODED VIEW FOR SUMMIT 600 NG 18 - Weber Summit FT 600 NG | Operation Guide - Page 19
PARTS LIST FOR SUMMIT 600 NG 1 Cooking grates (3) 2 Flavorizer / Cooking grate holders (2) 31 Right work surface 32 Crossover tubes (3) 33 Left burner (3) 34 Right burner (3) 35 Top manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service - Weber Summit FT 600 NG | Operation Guide - Page 20
PATENTS & TRADEMARKS © 1996 Weber-Stephen Products Co. Weber, the silhouette, Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
 |
 |
NOTICE TO INSTALLER:
These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING:
Follow all leak check
procedures carefully in this manual prior to
barbecue operation. Do this even if
barbecue was dealer assembled.
WARNING:
Do not try to light this
appliance without reading "Lighting"
instructions section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
SUMMIT 400 & 600
Natural Gas Barbecues
Operating Guide
Serial Number
Summit 400 NG
Serial Number
Summit 600 NG
97671
12/96
Read before assembly