Weber Summit Gold A NG Owner Manual
Weber Summit Gold A NG Manual
 |
View all Weber Summit Gold A NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit Gold A NG manual content summary:
- Weber Summit Gold A NG | Owner Manual - Page 1
Gas Grill Owners Guide YOU MUST READ THIS OWNERS GUIDE # BEFORE OPERATING manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. NOTICE TO INSTALLER: These instructions "Lighting" Instructions section of this manual A403_NG.f Ba402_NG.b B403_NG.b C402_NG.d D402_NG.d E402 - Weber Summit Gold A NG | Owner Manual - Page 2
for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber according to the instructions outlined in the "Assembly Instruction" section of the Owner's Guide. LIQUID PROPANE problem yourself. 3. Call your fire department. A-2 - Weber Summit Gold A NG | Owner Manual - Page 3
Methods A-6 Cleaning A-6 Exploded Views A-7 Parts List A-11 Assembly Instructions B-a Gas Instructions C-1 Leak Checking C-4 Operating D-1 Grilling Methods D-1 Lighting ...D-3 Manual Lighting D4 Troubleshooting D-5 Maintenance E-1 Replacing Main Burners E-2 Crossover® Ignition System - Weber Summit Gold A NG | Owner Manual - Page 4
assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual - Weber Summit Gold A NG | Owner Manual - Page 5
For Installation in Canada These instructions, while generally acceptable, do not for gas leaks and any obstructions in the burner tubes before using. (See Sections: "General Maintenance gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas - Weber Summit Gold A NG | Owner Manual - Page 6
Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual Service Representative in your region using the contact information sheet provided with your manual - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS - Weber Summit Gold A NG | Owner Manual - Page 7
Summit® Silver A Exploded View 1 Summit® Silver A NG 032403 2 3 38 4 39 5 40 6 41 42 7 8 9 10 43 11 12 13 14 44 15 45 16 46 17 18 47 19 48 20 49 21 50 51 22 52 23 53 24 54 55 25 26 27 56 28 29 57 30 58 31 32 59 33 34 35 60 36 61 62 37 63 A-7 - Weber Summit Gold A NG | Owner Manual - Page 8
Assembly 40. 1/4 - 20 x 1 1/4 inch Bolt 41. Right Flavorizer® Bar Assembly 42. Warming Rack 43. Cooking Box Assembly 44. Electrode Assembly 45. Right Burner Tube 46. Battery Shield Assembly 47. Manifold Assembly 48. Main Gas Line 49. Hose 50. Bottom Tray 51. Summit Catch Pan Holder 52. Summit Catch - Weber Summit Gold A NG | Owner Manual - Page 9
Summit® Gold A Exploded View 1 Summit® Gold A NG 032403 2 3 39 4 40 5 41 6 42 7 43 8 9 10 11 44 12 13 14 15 45 16 46 17 47 18 19 48 20 49 21 50 22 51 23 52 53 24 54 25 55 26 56 27 28 29 30 57 31 58 32 33 59 34 35 60 61 36 37 62 63 38 64 A-9 - Weber Summit Gold A NG | Owner Manual - Page 10
Grate 6. Left Flavorizer® Bar Assembly 7. Cookbox Assembly Hardware 8. 1/4 - 20 inch Hex Nut 9. Electrode Assembly 10. Crossover® Tube 11. Left Burner Tube 12. Right Burner Tube 13. 1/4 - 20 x 1/2 inch Phillips Screw 14. Manifold 15. Negative Ignition Switch Wire 16. Positive Ignition Switch Wire - Weber Summit Gold A NG | Owner Manual - Page 11
Summit® Silver A Parts List Lid - 1 Bottom Shelf - 1 Cookbox - 1 Left Door - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Right Door - 1 Side Table - 2 Left Frame Assembly - 1 Right Frame Assembly - 1 Warming Rack - 1 Warm-Up™ Rack - 1 Rear Panel - 1 A-11 - Weber Summit Gold A NG | Owner Manual - Page 12
Summit® Silver A Parts List Flavorizor® Bars - 2 Sets Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Stainless Steel Cooking Grates - 2 Bottom Tray - 1 Nut Hex (1/4 x 20 Blk Zinc) - 2 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Nylon Washer - 10 Catch-Pan - Weber Summit Gold A NG | Owner Manual - Page 13
Lid - 1 Cookbox - 1 Summit® Gold A Parts List Bottom Shelf - 1 Left Door - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Right Door - 1 Side Table - 2 Left Frame Assembly - 1 Right Frame Assembly - 1 Warming Rack - 1 Warm-Up™ Rack - 1 Rear Panel - 1 A-13 - Weber Summit Gold A NG | Owner Manual - Page 14
Summit® Gold A Parts List Flavorizor® Bars - 2 Sets Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Stainless Steel Cooking Grates - 3 Bottom Tray - 1 Nut Hex (1/4 x 20 Blk Zinc) - 2 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Nylon Washer - 10 Catch-Pan - Weber Summit Gold A NG | Owner Manual - Page 15
1 Place corregated from each side of a the Cookbox under the Caster and Wheel Frame Assembly to level the frames for Frame Rail Assembly. b c (1) (3) Ba402_NG.b (3) (2) B-a ƽ CAUTION: Before proceeding to the next step check that frame rail (2) is on the side with the swing tables (3). - Weber Summit Gold A NG | Owner Manual - Page 16
2 a b ƽ ATTENTION! Only start these bolts. Do not tighten yet. B-b - Weber Summit Gold A NG | Owner Manual - Page 17
3 B-c - Weber Summit Gold A NG | Owner Manual - Page 18
4 a b ƽ ATTENTION! Completely remove both partially started bolts from top rear frame rail c 1 2 ƽ ATTENTION! Reinstall both bolts through rear panel and into rear frame rail. B-d - Weber Summit Gold A NG | Owner Manual - Page 19
5 ƽ ATTENTION! Remove packing tape holding the gas line and bracket(1). When installing cookbox route the gas line and bracket(1) inside the frame rails(2). a (1) (2) (2) (1) (2) (2) B-e - Weber Summit Gold A NG | Owner Manual - Page 20
6 b (1) (2) (3) B-f - Weber Summit Gold A NG | Owner Manual - Page 21
7 c (1) (2) (1) (2) B-g - Weber Summit Gold A NG | Owner Manual - Page 22
8 a b Matchlight Holder B-h - Weber Summit Gold A NG | Owner Manual - Page 23
9 a b (1) (2) (3) B-i - Weber Summit Gold A NG | Owner Manual - Page 24
10 a b a b B-j - Weber Summit Gold A NG | Owner Manual - Page 25
11 12 b a B403_NG.b B-1 - Weber Summit Gold A NG | Owner Manual - Page 26
13 14 B-2 - Weber Summit Gold A NG | Owner Manual - Page 27
15 16 B-3 - Weber Summit Gold A NG | Owner Manual - Page 28
A B-4 - Weber Summit Gold A NG | Owner Manual - Page 29
A B-5 - Weber Summit Gold A NG | Owner Manual - Page 30
Instructions psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve grams of hydrogen sulfide per 100 cubic feet of gas. s Plastic tubing is suitable only for outdoor, underground use. s Gas piping in contact - Weber Summit Gold A NG | Owner Manual - Page 31
Gas Instructions Connect Gas Supply a) To connect gas hose at the supply: Slide back the collar of the quick disconnect. Push male fitting of the hose into - Weber Summit Gold A NG | Owner Manual - Page 32
Gas Instructions ƽWARNING : The gas connections of your Summit® gas grill have been factory tested. We do however recommend that you leak check all gas connections before - Weber Summit Gold A NG | Owner Manual - Page 33
Gas Instructions Remove the Front Panel by sliding the panel up and out of the slots. Check for gas leaks ƽ DANGER Do not use an open flame - Weber Summit Gold A NG | Owner Manual - Page 34
leak at connections (1),(2), or (3) turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water - Weber Summit Gold A NG | Owner Manual - Page 35
Gas Instructions Reinstall control panel Parts required: control panel, screws, and burner control knobs. Place the control panel back onto the control panel (1) brackets on either side - Weber Summit Gold A NG | Owner Manual - Page 36
Operating Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burners - Weber Summit Gold A NG | Owner Manual - Page 37
Operating Instructions Indirect cooking The Indirect Method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can't get from - Weber Summit Gold A NG | Owner Manual - Page 38
Lighting Summary lighting instructions are on the control panel. 1 ƽ DANGER Failure to open the lid only Weber® authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1 4,5,8 7 2 6 2 3 *The - Weber Summit Gold A NG | Owner Manual - Page 39
Operating Instructions Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does - Weber Summit Gold A NG | Owner Manual - Page 40
Troubleshooting Problem on HIGH. Flames do not run the whole length of the burner tube. Are burners clean? Clean burners. (See Section "Maintenance".) Inside NOT A DEFECT. If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your region - Weber Summit Gold A NG | Owner Manual - Page 41
burner to get debris and dirt out of the burner tube. Once the spider/insect screens and burners are clean replace the burners. If the spider/insect screen becomes damaged or cannot be cleaned, call Weber-Stephen Products Customer Service for replacement parts. Main Burner Flame Pattern The Weber - Weber Summit Gold A NG | Owner Manual - Page 42
Maintenance Replacing Main Burners 1. Your Summit® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer® bars. 7. To remove control panel refer to "Remove the control panel" under "Check for Gas Leaks - Weber Summit Gold A NG | Owner Manual - Page 43
Maintenance 9. Remove screws from the manifold assembly: (a) Locate the screws on both sides of the manifold frame. (b) Remove the screws from manifold frame. 10. Pull manifold assembly out from the manifold frame. (a) (b) (a) (b) (a) (b) (a) (b) E-3 - Weber Summit Gold A NG | Owner Manual - Page 44
11. Lift and twist the burner assembly slightly, to separate 14. To reinstall the manifold assembly, reverse steps 7 the Crossover® tube (a) from the burners (b). through 13. ƽCAUTION: The burner openings (1) must be positioned properly over the valve orifices (2). (2) (b) (b) (a) (1) 12 - Weber Summit Gold A NG | Owner Manual - Page 45
sparking. If the Crossover® ignition system still fails to light, contact the Customer Service Representative in your region using the contact information sheet provided with your manual. (1) (2) Replace Igniter Batteries Parts required: 1 AA alkaline battery per igniter. Unscrew igniter button
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
 |
 |
SUMMIT
®
±
WARNING: Follow all leak-check
procedures carefully in this manual prior to
barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING
1.
Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2.
Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL
Natural Gas Grill Owners Guide
±
WARNING: Do not try to light this
appliance without reading the “Lighting”
Instructions section of this manual
#
42095 US 05/09/03
NG
42095
&
A403_NG.f
Ba402_NG.b
B403_NG.b
C402_NG.d
D402_NG.d
E402.c