Weber Summit Gold C4 LP Owner Manual
Weber Summit Gold C4 LP Manual
 |
View all Weber Summit Gold C4 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit Gold C4 LP manual content summary:
- Weber Summit Gold C4 LP | Owner Manual - Page 1
SUMMIT® GAS GRILL LP Gas Grill Owner's Guide #38008 YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL ƽ DANGER If you smell gas: 1. Shut off gas in this manual prior to barbecue operation. Do this even if the barbecue was dealerassembled. NOTICE TO INSTALLER: These instructions must - Weber Summit Gold C4 LP | Owner Manual - Page 2
instructions in this manual for correct procedures. ƽ Do not operate the Weber® gas barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber® gas Weber® gas gas - Weber Summit Gold C4 LP | Owner Manual - Page 3
Weber® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions service, owner's manual. Deterioration Summit, Platinum, 1-800-Grill-Out, Ranch, Matchless Flame, Zimbabwe; Weber - Weber Summit Gold C4 LP | Owner Manual - Page 4
its location in your yard or on your patio. Portability means you can take your Weber® gas barbecue with, if you move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. • These instructions will give you the minimum requirements for assembling your - Weber Summit Gold C4 LP | Owner Manual - Page 5
INSTRUCTIONS 5 GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. ƽ WARNING: Do not move the Weber® gas contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com® Outside - Weber Summit Gold C4 LP | Owner Manual - Page 6
station fills your LP cylinder by weight or volume. Ask your filling station to read purging and filling instructions on the LP cylinder before attempting apply it. 1) Turn the LP cylinder so the opening of the valve is either to the front, side or rear of the Weber® gas barbecue. Lift and hook the - Weber Summit Gold C4 LP | Owner Manual - Page 7
information on our web site. Log onto www.weber.com®. Do not use the barbecue. 8) When leak checking is complete, turn gas supply OFF at the source and rinse connections with water. 7 CHECK FOR GAS LEAKS ƽWARNING : The gas connections of your Summit® gas grill have been factory tested. We do - Weber Summit Gold C4 LP | Owner Manual - Page 8
8 GAS INSTRUCTIONS Put your fingers under the front edge you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these leak checks even if your after checking for leaks. Make sure side burner is OFF. - Weber Summit Gold C4 LP | Owner Manual - Page 9
the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www. weber.com®. 4) Side burner hose to manifold connection 5) Side burner hose to side burner connection, and sideburner valve to - Weber Summit Gold C4 LP | Owner Manual - Page 10
GAS INSTRUCTIONS REINSTALL CONTROL PANEL Parts required: control panel, screws, and burner control knobs. Place the control panel back onto the control panel brackets on either side troubleshooting section of this manual Summit® gas grill according to the instructions in this Owner's Manual Gold D4 - Weber Summit Gold C4 LP | Owner Manual - Page 11
indicator level line on the side of the (1) tank scale. 1) Empty 2) Medium 3) Full 11 (1) (2) (2) (3) SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS • Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures - Weber Summit Gold C4 LP | Owner Manual - Page 12
12 GAS INSTRUCTIONS • Treat "empty" LP cylinders with the same care as when full. Even when the LP tank is empty of liquid there still may be gas pressure in the cylinder. Always close the cylinder valve before disconnecting. ƽ CAUTION: When transporting the LP cylinder make sure the plastic dust - Weber Summit Gold C4 LP | Owner Manual - Page 13
INSTRUCTIONS GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual . Light your Summit® gas grill according to the instructions in this Owner's Manual. Turn both fire, or arrange the fire on either side of it. Using the right method is the - Weber Summit Gold C4 LP | Owner Manual - Page 14
INSTRUCTIONS INDIRECT COOKING The Indirect Method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can't get from an oven. To set up for Indirect cooking, gas burners are lit on either side The temperature of your Summit® gas grill may run hotter - Weber Summit Gold C4 LP | Owner Manual - Page 15
the barbecue. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP - Weber Summit Gold C4 LP | Owner Manual - Page 16
each burner control knob clockwise to OFF position. Turn gas supply OFF at the source. MANUAL LIGHTING ƽ DANGER Failure to open the lid while LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP - Weber Summit Gold C4 LP | Owner Manual - Page 17
OPERATING INSTRUCTIONS 17 ƽ DANGER When the "excess gas flow control" feature is activated, a small amount of gas is still flowing to the burners. After turning OFF the cylinder and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to - Weber Summit Gold C4 LP | Owner Manual - Page 18
18 OPERATING INSTRUCTIONS SIDE BURNER LIGHTING INSTRUCTIONS LIGHTING WITH IGNITER ƽ DANGER Failure to open the lid while igniting the side burner, SUMMIT® B, C, D or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can - Weber Summit Gold C4 LP | Owner Manual - Page 19
OPERATING INSTRUCTIONS 19 MANUALLY LIGHTING SIDE BURNER ƽ DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flameup which can cause serious bodily injury or death. MANUAL - Weber Summit Gold C4 LP | Owner Manual - Page 20
fully penetrate the food. Light the smoker burner by following the instructions for Lighting The Smoker Burner After wood starts to smolder turn fish recipes in the gas grill cookbook. Cook with the lid down according to the times indicated in charts or recipes. (1) SUMMIT® C, D Cleaning the smoker - Weber Summit Gold C4 LP | Owner Manual - Page 21
OPERATING INSTRUCTIONS 21 LIGHTING THE SMOKER BURNER ƽ WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber® authorized replacement hose. Contact the Customer Service - Weber Summit Gold C4 LP | Owner Manual - Page 22
INSTRUCTIONS to LOW. SUMMIT® C, D gas supply OFF at the source. MANUALLY Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. 1) Open the lid. ƽDANGER Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas - Weber Summit Gold C4 LP | Owner Manual - Page 23
INSTRUCTIONS 23 ƽWARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas - Weber Summit Gold C4 LP | Owner Manual - Page 24
24 OPERATING INSTRUCTIONS ROTISSERIE ASSEMBLY Parts required: rotisserie motor bracket(1), rotisserie motor(1), rotisserie shaft(1), spit forks(4) and fork screws (4). 1) Install the motor bracket Attach the stainless steel motor bracket to the left side of the cooking box, using the 1/4-20 - Weber Summit Gold C4 LP | Owner Manual - Page 25
holder and the Indirect Cooking Method. IMPORTANT SAFEGUARDS ƽWARNINGS • Read all instructions before using your rotisserie. • This rotisserie is for outdoor use only end of the rotisserie onto the support rollers. 6) The rotisserie shaft should rotate so that the heavy side of the meat or poultry - Weber Summit Gold C4 LP | Owner Manual - Page 26
the grill. Replace using only a Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on to allow the gas to clear if the grill does not light, may result in an explosive flare-up which can cause serious bodily injury or death. SUMMIT® D 1 8 - Weber Summit Gold C4 LP | Owner Manual - Page 27
INSTRUCTIONS LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP cylinder valve and burner control knobs. Then start over. SUMMIT® D 1 8 ƽDANGER: When the "excess gas on each side of the food - Weber Summit Gold C4 LP | Owner Manual - Page 28
INSTRUCTIONS MANUALLY LIGHTING THE ROTISSERIE BURNER ƽATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas Weber® authorized replacement hose. Contact the Customer Service Representative in your area - Weber Summit Gold C4 LP | Owner Manual - Page 29
INSTRUCTIONS 29 ƽWARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas side of - Weber Summit Gold C4 LP | Owner Manual - Page 30
TROUBLESHOOTING PROBLEM Burners burn with a yellow or orange flame, in conjunction with the smell of gas , or flame is low Is LP fuel low or empty? in HIGH to "Lighting Instructions". Refill LP cylinder. Straighten problems cannot be corrected by using these methods, please contact the Customer Service - Weber Summit Gold C4 LP | Owner Manual - Page 31
"Lighting Instructions". Straighten hose. If match lights burner, check igniter (see below). If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. SIDE BURNER - Weber Summit Gold C4 LP | Owner Manual - Page 32
32 ROTISSERIE TROUBLESHOOTING PROBLEM Burner does not light. CHECK Did you hold the cylinder valve on slowly. Refer to "Lighting Instructions". If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on - Weber Summit Gold C4 LP | Owner Manual - Page 33
Weber® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas flow, and can cause the gas be cleaned, call Weber-Stephen Products Customer Service for replacement parts. 33 - Weber Summit Gold C4 LP | Owner Manual - Page 34
Weber® gas barbecue burners have been factory set for the correct air and gas BURNERS 1. Your Summit® gas grill must be OFF and cool. 2. Turn gas OFF at source. = White Tab with Black Wire c = Solid White Wire d = Grounding Wire Gold D4 -+ -+ a c ef bd a = Blue Tab with Black Wire b = Yellow - Weber Summit Gold C4 LP | Owner Manual - Page 35
9. Disconnect the Thermocouple from the IR Burner valve. 35 10. Remove screws from the manifold assembly: (a) Locate the screws on both sides of the manifold frame. (b) Remove the screws from manifold frame. 11. Pull manifold assembly out from the manifold frame. (a ) (b ) (a (b ) 12. Lift - Weber Summit Gold C4 LP | Owner Manual - Page 36
proper assembly before fastening manifold in place. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before Customer (2 ) Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. REPLACE IGNITER
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
±
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
±
WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
±
WARNING: Follow all leak-check
procedures carefully in this manual
prior to barbecue operation. Do this
even if the barbecue was dealer-
assembled.
NOTICE TO INSTALLER: These
instructions must be left with the owner
and the owner should keep them for future
use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING: Do not try to light this
appliance without reading the "Lighting"
Instructions section of this manual.
YOU MUST READ THIS OWNERS GUIDE
BEFORE OPERATING YOUR GAS GRILL
38008 US 04/12/05
LP
US ENGLISH
#38008
SUMMIT
®
GAS GRILL
LP Gas Grill Owner’s Guide