Weber Summit S-440 NG Owner Manual
Weber Summit S-440 NG Manual
 |
View all Weber Summit S-440 NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit S-440 NG manual content summary:
- Weber Summit S-440 NG | Owner Manual - Page 1
GAS GRILL Built-In NG Gas Grill Owner's Guide S-440 - NG #43#10406000 YOU MUST READ THIS OWNER'S GUIDE BEFORE OPERATING YOUR GAS GRILL ƽ carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. NOTICE TO INSTALLER: These instructions must be left - Weber Summit S-440 NG | Owner Manual - Page 2
be checked for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber® gas barbecue if there is a gas leak present. ƽ cylinder. 2. Do not attempt to correct the problem yourself. 3. Call your fire department. WWW.WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 3
service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date - Weber Summit S-440 NG | Owner Manual - Page 4
4 $, %# %$ %% %& %' %( %) %* %+ %, &# EXPLODED VIEW S-440 S440_NG_US &+ &, '# '$ '% '& '' '( ') '* '+ ', (# ($ WWW.WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 5
Tubes 13. Manifold 14. Control Panel 15. Small Knob Bezel 16. Small Knob 17. Large Knob 18. Large Knob Bezel WWW.WEBER.COM® EXPLODED VIEW LIST S-440 26. Left Door 44. Rear Frame Support 27. Door Handles 45. Vent Cover 28. Right Door 46. Front Frame Support 29. Left Vent Bracket 47. Right - Weber Summit S-440 NG | Owner Manual - Page 6
instructions will give you the minimum requirements for assembling your Weber® gas barbecue. Please read the instructions carefully before using your Weber heat while cooking refer to the troubleshooting section of this manual. ƽ WARNING: Do not move the Weber® gas barbecue when operating or while - Weber Summit S-440 NG | Owner Manual - Page 7
cooking module - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside your stainless steel. GAS INSTRUCTIONS INSTALL GAS SUPPLY GENERAL manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. • An additional manual WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 8
INSTRUCTIONS local dealer. For safety and design reasons, the conversion of a Weber® grill from operation using Natural gas to operation using LP gas recommend that you leak check all gas connections before operating your Summit® gas grill. REMOVE CONTROL PANEL Tool required: Phillips Screwdriver. - Weber Summit S-440 NG | Owner Manual - Page 9
GAS INSTRUCTIONS 3) Remove the control panel. Tilt panel forward and lift up and away been flame-tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber® gas barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these - Weber Summit S-440 NG | Owner Manual - Page 10
10 GAS INSTRUCTIONS Check: 1) Main gas line to manifold connection. 2) Rotisserie (I.R. Burner) gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. When leak checks are complete, turn gas - Weber Summit S-440 NG | Owner Manual - Page 11
OPERATING INSTRUCTIONS GRILLING METHODS Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. the grill before grilling is important. Light your Summit® gas grill according to the instructions in this Owner's Manual. Turn all of the main burners to WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 12
INSTRUCTIONS GRILLING and shape of the food being grilled. • The temperature of your Summit® gas grill may run hotter than normal for the first few uses "snap". This will allow gas to flow completely down the burner tube (E) and insure ignition. Check that the burner is lit by looking WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 13
instructions Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber the igniter, the burner lighting tube and then main burner. 5) MAIN BURNER MANUAL LIGHTING ƽ DANGER MAIN BURNER MANUAL LIGHTING - Weber Summit S-440 NG | Owner Manual - Page 14
Light the smoker burner by following the instructions for Lighting The Smoker Burner After wood only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using action will spark the igniter, the burner lighting tube and then main burner. 7) Check that the - Weber Summit S-440 NG | Owner Manual - Page 15
OPERATING INSTRUCTIONS MANUALLY LIGHTING THE SMOKER BURNER 1) Open the lid. ƽ DANGER Failure to open the lid while igniting the grill, or not waiting 5 be grounded electrically in accordance with the National Electric Code, ANSI / NFPA 70, or Canadian Electrical Code, CSA C22.1. WWW.WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 16
handle end of the rotisserie onto the support rollers. 6) The rotisserie shaft should to turn freely. • Follow lighting instructions for rotisserie burner on next page to the burner lighting tube. You generate the energy Weber® authorized replacement hose. Contact the Customer Service Representative in your area - Weber Summit S-440 NG | Owner Manual - Page 17
OPERATING INSTRUCTIONS MANUALLY LIGHTING THE ROTISSERIE BURNER ƽ ATTENTION: READ BEFORE LIGHTING , do not use the grill. Replace using only a Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto - Weber Summit S-440 NG | Owner Manual - Page 18
the burner lighting tube. Try manually lighting the burner (refer to "Main Burner Manual Lighting"). Call customer service. All burners on deactivate the sensor by pressing power button (a). HANDLE LIGHT TROUBLESHOOTING PROBLEM CHECK CURE Weber Grill Out™ Handle Light does not light. Are the - Weber Summit S-440 NG | Owner Manual - Page 19
the Rotisserie Burner"). Does the igniter work (Do you see a spark when you repeatedly use the snap igniter? Try manually lighting the burner (refer to "Lighting the Rotisserie Burner"). Call customer service. If problems cannot be corrected by using these methods, please contact the Customer - Weber Summit S-440 NG | Owner Manual - Page 20
ports are fully open. ƽ CAUTION: Do not enlarge the burner ports when cleaning. REPLACE MAIN BURNERS 1) Your Summit® gas grill must be off and cool. 2) Turn gas off at source. 3) Disconnect gas supply. 4) Remove assembly exposing the valves, burners, igniter, and manifold. a b c WWW.WEBER.COM® - Weber Summit S-440 NG | Owner Manual - Page 21
. Lightly tap the burner to get debris and dirt out of the burner tube. Once the Spider/ Insect screens and burners are clean replace the burners. Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. BURNER FLAME PATTERN The Weber® gas - Weber Summit S-440 NG | Owner Manual - Page 22
or gas burning components. Please contact Weber-Stephen Products Co., Customer Service Department for genuine Weber-Stephen Products Co. replacement part(s) , Spirit, Grill Out, Summit, Platinum, 1-800-Grill-Out, Ranch, Matchless Flame, Zimbabwe; Weber, Kettle Configuration, Kettle Silhouette - Weber Summit S-440 NG | Owner Manual - Page 23
èle avez-vous acheté? 1. Summit® S-420 4. Summit® S-620 2. Summit® S-450 5. Summit® S-650 3. Built-In Summit® S-440 Empotrado Summit® S-440 Integre Summit® S-440 6. Built-In Summit® S-640 Empotrado Summit® S-640 Integre Summit® S-640 7. Have you ever owned a Weber® grill before? / ¿Ha tenido - Weber Summit S-440 NG | Owner Manual - Page 24
ces de rechange ou si vous avez des questions sur le montage, l'utilisation ou l'entretien de votre grill, veuillez consulter le Service Client de Weber. For purchases made in the U.S.: Product Registration ▲ Para compras hechas en los Estados Unidos: P.O. Box 1999 Pour les achats effectués aux
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
 |
 |
YOU MUST READ THIS OWNER’S GUIDE
BEFORE OPERATING YOUR GAS GRILL
±
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
±
WARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
±
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
43146 US 03/03/08
NG
US ENGLISH
#00000
#43146
±
WARNING: Do not try to light this
appliance without reading the “Lighting
Instructions” section of this manual.
S-440 - NG
GAS GRILL
Built-In NG Gas Grill Owner’s Guide