Weber Summit S-640 LP Owner Manual

Weber Summit S-640 LP Manual

Get Weber Summit S-640 LP PDF manuals and user guides View all Weber Summit S-640 LP manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Summit S-640 LP manual content summary:

  • Weber Summit S-640 LP | Owner Manual - Page 1
    : These instructions must be left with the owner and the owner should keep them for future use. THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY. ƽ WARNING: Do not try to light this appliance without reading the "Lighting Instructions" section of this manual. 43154 US 03/03/08 LP US ENGLISH
  • Weber Summit S-640 LP | Owner Manual - Page 2
    use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber® gas barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber® gas barbecue. ƽ Do
  • Weber Summit S-640 LP | Owner Manual - Page 3
    PURCHASER of this Weber® gas grill that it will set out in this owner's manual. Deterioration or damage due to in accordance with the printed instructions accompanying it. This Warranty applies the claim, WEBER-STEPHEN PRODUCTS CO. Customer Service Center 1890 Roselle Road, Suite 308 Schaumburg,
  • Weber Summit S-640 LP | Owner Manual - Page 4
    4 $, %# %$ %% %& %' %( %) %* %+ %, &# EXPLODED VIEW S-640 S640_LP_US '% '& '' '( ') '* '+ ', (# ($ (% (& (' (( () (* WWW.WEBER.COM®
  • Weber Summit S-640 LP | Owner Manual - Page 5
    25. Left Panel 44. Manifold Hose 26. Left Door 45. Hose / Regulator 27. Door Handles 46. Rear Frame Support 28. Right Door 47. Vent Cover 29. Left Vent Bracket 48. Front Frame Support 30. Kick Vent 49. Right Rear Panel 31. IR Burner Cover 50. Tank Scale 32. Infrared Burner 51. Tank
  • Weber Summit S-640 LP | Owner Manual - Page 6
    OPERATING Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. • These instructions will give you the minimum requirements for assembling your Weber® gas barbecue. Please read the instructions carefully before using your Weber® gas barbecue. Improper
  • Weber Summit S-640 LP | Owner Manual - Page 7
    the look of your stainless steel. GENERAL INSTRUCTIONS GENERAL INSTRUCTIONS IMPORTANT LP CYLINDER INFORMATION The proper filling methods for the stop, then they are off. Proceed to the next step. Your Weber® gas grill is equipped for a cylinder supply system designed for vapor withdrawal. ƽ
  • Weber Summit S-640 LP | Owner Manual - Page 8
    GAS INSTRUCTIONS GAS INSTRUCTIONS Some LP the LP cylinder so the opening of the valve is either to the front, side or rear of the Weber® gas barbecue Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. 9) When leak checking is complete, turn gas
  • Weber Summit S-640 LP | Owner Manual - Page 9
    GAS INSTRUCTIONS CHECK FOR GAS LEAKS ƽ WARNING: The gas connections of your Summit® gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your Summit® gas . If your grill has a side burner make sure the side burner is off. To perform
  • Weber Summit S-640 LP | Owner Manual - Page 10
    GAS INSTRUCTIONS CHECK: 1) Main gas line to manifold connection. 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. 4) Corregated gas the fitting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the
  • Weber Summit S-640 LP | Owner Manual - Page 11
    the color indicator level line on the side of the tank scale. 1) Empty 2) Medium 3) Full 11 11 SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS • Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moderate
  • Weber Summit S-640 LP | Owner Manual - Page 12
    12 GAS INSTRUCTIONS GRILLING METHODS Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust : place the food directly over the fire, or arrange the fire on either side of it. Using the right method is the shortest route to great results-and
  • Weber Summit S-640 LP | Owner Manual - Page 13
    GAS INSTRUCTIONS 13 GRILLING TIPS & HELPFUL HINTS • Always preheat the grill before cooking. Set also see a 3˝ - 5˝ orange flame coming from the burner lighting tube at the left side of the burner (D). Continue to hold the burner control knob in for two seconds after the "snap". This will allow
  • Weber Summit S-640 LP | Owner Manual - Page 14
    using only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn off the LP
  • Weber Summit S-640 LP | Owner Manual - Page 15
    OPERATING INSTRUCTIONS MAIN BURNER MANUAL LIGHTING ƽ DANGER Failure to open the lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) Open
  • Weber Summit S-640 LP | Owner Manual - Page 16
    hose. Contact the Customer Service Representative in your area using LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn off the LP gas clear before you try again, or try lighting with a match (see "Manually
  • Weber Summit S-640 LP | Owner Manual - Page 17
    INSTRUCTIONS MANUALLY LIGHTING THE SMOKER BURNER ƽ WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be 1 damaged in any way, do not use the grill. Replace using only Weber® authorized replacement hose. Contact the Customer 7 Service
  • Weber Summit S-640 LP | Owner Manual - Page 18
    handle end of the rotisserie onto the support rollers. 6) The rotisserie shaft should rotate so that the heavy side of the meat or poultry rotates down and warming rack to allow food to turn freely. • Follow lighting instructions for rotisserie burner on next page. • Set rotisserie burner on medium
  • Weber Summit S-640 LP | Owner Manual - Page 19
    INSTRUCTIONS replacement hose. Contact the Customer Service Representative in your area using the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn off the LP the main burners on each side of the food (See
  • Weber Summit S-640 LP | Owner Manual - Page 20
    INSTRUCTIONS MANUALLY LIGHTING THE ROTISSERIE BURNER ƽ ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas Contact the Customer Service Representative in your match by right side of rotisserie burner
  • Weber Summit S-640 LP | Owner Manual - Page 21
    PROBLEM Burners burn with a yellow or orange flame, in conjunction with the smell of gas to "Lighting Instructions". Refill LP cylinder. Straighten manually lighting the burner (refer to "Main Burner Manual Lighting"). Call customer service HANDLE LIGHT TROUBLESHOOTING PROBLEM CHECK CURE Weber
  • Weber Summit S-640 LP | Owner Manual - Page 22
    "Lighting Instructions". If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. ROTISSERIE TROUBLESHOOTING WEBER® SPIDER/INSECT SCREENS Your Weber® gas barbecue
  • Weber Summit S-640 LP | Owner Manual - Page 23
    CAUTION: Do not enlarge the burner ports when cleaning. 23 23 REPLACE MAIN BURNERS 1) Your Summit® gas grill must be off and cool. 2) Turn gas off at source. 3) Disconnect gas supply. 4) Remove cooking grates. 5) Remove smoker box. 6) Remove Flavorizer® bars. REMOVE CONTROL PANEL 7) Tool required
  • Weber Summit S-640 LP | Owner Manual - Page 24
    becomes damaged or cannot be cleaned, please contact the Customer Service Representative in your area using the contact information on our web com®. BURNER FLAME PATTERN The Weber® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown
  • Weber Summit S-640 LP | Owner Manual - Page 25
    25 25 WWW.WEBER.COM®
  • Weber Summit S-640 LP | Owner Manual - Page 26
    -Stephen Products Co. replacement part(s) information. ƽ WARNING: Do not attempt to make any repair to gas carrying or gas burning components without contacting Weber-Stephen Products Co., Customer Service Department. Your actions, if you fail to follow this product Warning, may cause a fire or an
  • Weber Summit S-640 LP | Owner Manual - Page 27
    / ¿Ha tenido alguna vez antes un asador Weber®? / Avez-vous déjà possédé un grill Weber® auparavant ? 1. Yes Number of Weber® gas grills owned: Sí Número de asadores de gas Weber® que ha tenido: Oui Nombre de grills à gaz Weber® possédés: Number of Weber® charcoal grills owned: Número de asadores de
  • Weber Summit S-640 LP | Owner Manual - Page 28
    de pièces de rechange ou si vous avez des questions sur le montage, l'utilisation ou l'entretien de votre grill, veuillez consulter le Service Client de Weber. For purchases made in the U.S.: Product Registration ▲ Para compras hechas en los Estados Unidos: P.O. Box 1999 Pour les achats effectu
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
YOU MUST READ THIS OWNER’S GUIDE
BEFORE OPERATING YOUR GAS GRILL
±
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
±
WARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
±
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
43154 US 03/03/08
LP
US ENGLISH
#00000
#43154
±
WARNING: Do not try to light this
appliance without reading the “Lighting
Instructions” section of this manual.
S-640
GAS GRILL
Built-In LP Gas Grill Owner’s Guide