Weber Summit Silver B NG Owner Manual
Weber Summit Silver B NG Manual
View all Weber Summit Silver B NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit Silver B NG manual content summary:
- Weber Summit Silver B NG | Owner Manual - Page 1
Gas Grill Owners Guide YOU MUST READ THIS OWNERS GUIDE # BEFORE OPERATING manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. NOTICE TO INSTALLER: These instructions "Lighting" Instructions section of this manual A405_NG.d Ba402_NG.a B405_NG.c C405_NG.c D405_NG.d E403 - Weber Summit Silver B NG | Owner Manual - Page 2
for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber according to the instructions outlined in the "Assembly Instruction" section of the Owner's Guide. LIQUID PROPANE problem yourself. 3. Call your fire department. A-2 - Weber Summit Silver B NG | Owner Manual - Page 3
View A-7 Parts List A-11 Assembly Instructions B-a Gas Instructions C-1 Leak Checking C-4 Operating D-1 Grilling Methods D-1 Lighting ...D-3 Manual Lighting D-4 Lighting the Side Burner D-5 Troubleshooting D-6 Side Burner Troubleshooting D-7 Maintenance E-1 Replacing Main Burners - Weber Summit Silver B NG | Owner Manual - Page 4
assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual - Weber Summit Silver B NG | Owner Manual - Page 5
For Installation in Canada These instructions, while generally acceptable, do not for gas leaks and any obstructions in the burner tubes before using. (See Sections: "General Maintenance gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas - Weber Summit Silver B NG | Owner Manual - Page 6
Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual Service Representative in your region using the contact information sheet provided with your manual - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS - Weber Summit Silver B NG | Owner Manual - Page 7
Summit® Silver B Exploded View 1 Summit® Silver B NG 012903 2 3 39 4 40 5 41 6 42 43 7 8 9 44 10 11 12 45 13 14 46 15 47 16 48 17 18 49 19 50 20 51 - Weber Summit Silver B NG | Owner Manual - Page 8
40. Lid Assembly 41. 1/4 - 20 x 1 1/4 inch Bolt 42. Right Flavorizer® Bar Assembly 43. Warming Rack 44. Cookbox Assembly 45. Electrode Assembly 46. Right Burner Tube 47. Battery Shield Assembly 48. Side Burner Ignition Wire 49. Manifold Assembly 50. Main Gas Line 51. Hose 52. Bottom Tray 53. Summit - Weber Summit Silver B NG | Owner Manual - Page 9
Summit® Gold B Exploded View 1 Summit® Gold B NG 012903 2 3 40 4 41 5 42 6 43 7 44 8 9 10 11 45 12 13 14 15 46 16 47 17 48 18 19 20 49 50 21 51 - Weber Summit Silver B NG | Owner Manual - Page 10
Grate 6. Left Flavorizer® Bar Assembly 7. Cookbox Assembly Hardware 8. 1/4 - 20 inch Hex Nut 9. Electrode Assembly 10. Crossover® Tube 11. Left Burner Tube 12. Right Burner Tube 13. 1/4 - 20 x 1/2 inch Phillips Screw 14. Manifold 15. Negative Ignition Switch Wire 16. Positive Ignition Switch Wire - Weber Summit Silver B NG | Owner Manual - Page 11
Summit® Silver B Parts List Lid - 1 Bottom Shelf - 1 Cookbox - 1 Left Door - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Right Door - 1 Side Table - 1 Left Frame Assembly - 1 Right Frame Assembly - 1 Rear Panel - 1 Side Burner - 1 Warming Rack - 1 Warm-Up™ Rack - 1 A-11 - Weber Summit Silver B NG | Owner Manual - Page 12
Summit® Silver B Parts List Flavorizor® Bars - 2 Sets Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Stainless Steel Cooking Grates - 2 Bottom Tray - 1 Nut Hex (1/4 x 20 Blk Zinc) - 2 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Nylon Washer - 10 Catch-Pan - Weber Summit Silver B NG | Owner Manual - Page 13
Lid - 1 Cookbox - 1 Summit® Gold B Parts List Bottom Shelf - 1 Left Door - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Right Door - 1 Side Table - 1 Left Frame Assembly - 1 Right Frame Assembly - 1 Rear Panel - 1 Side Burner - 1 Warming Rack - 1 Warm-Up™ Rack - 1 A-13 - Weber Summit Silver B NG | Owner Manual - Page 14
Summit® Gold B Parts List Flavorizor® Bars - 2 Sets Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Stainless Steel Cooking Grates - 3 Bottom Tray - 1 Nut Hex (1/4 x 20 Blk Zinc) - 2 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Nylon Washer - 10 Catch-Pan - Weber Summit Silver B NG | Owner Manual - Page 15
1 Place corregated from each side of a the Cookbox under the Caster and Wheel Frame Assembly to level the frames for Frame Rail Assembly. b c (1) (3) Ba402_NG.a ƽ CAUTION: Before proceeding to the next step check that frame rail (2) is on the side with the swing tables (3). The tab - Weber Summit Silver B NG | Owner Manual - Page 16
2 a b ƽ ATTENTION! Only start these bolts. Do not tighten yet. B-b - Weber Summit Silver B NG | Owner Manual - Page 17
3 B-c - Weber Summit Silver B NG | Owner Manual - Page 18
4 a b ƽ ATTENTION! Completely remove both partially started bolts from top rear frame rail c 1 2 ƽ ATTENTION! Reinstall both bolts through rear panel and into rear frame rail. B-d - Weber Summit Silver B NG | Owner Manual - Page 19
5 ƽ ATTENTION! Remove packing tape holding the gas line and bracket(1). When installing cookbox route the gas line and bracket(1) inside the frame rails(2). a (1) (2) (2) (1) (2) (2) B-e - Weber Summit Silver B NG | Owner Manual - Page 20
6 b (1) (2) (3) B-f - Weber Summit Silver B NG | Owner Manual - Page 21
7 c (1) (2) (1) (2) B-g - Weber Summit Silver B NG | Owner Manual - Page 22
8 a b Matchlight Holder B-h - Weber Summit Silver B NG | Owner Manual - Page 23
9 a b (1) (2) (3) B-i - Weber Summit Silver B NG | Owner Manual - Page 24
10 a b a b B-j - Weber Summit Silver B NG | Owner Manual - Page 25
11 a (1) (2) NOTE: Igniter b Wire(1) is located up under right side of control panel. (1) B405_NG.c B-1 - Weber Summit Silver B NG | Owner Manual - Page 26
c ƽ CAUTION: Hold burner cap(1) down while pushing side burner ignition wire(2) on. (1) (2) d B-2 - Weber Summit Silver B NG | Owner Manual - Page 27
12 b a 13 14 B-3 - Weber Summit Silver B NG | Owner Manual - Page 28
15 16 B-4 - Weber Summit Silver B NG | Owner Manual - Page 29
B B-5 - Weber Summit Silver B NG | Owner Manual - Page 30
B B-6 - Weber Summit Silver B NG | Owner Manual - Page 31
Instructions psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve grams of hydrogen sulfide per 100 cubic feet of gas. s Plastic tubing is suitable only for outdoor, underground use. s Gas piping in contact - Weber Summit Silver B NG | Owner Manual - Page 32
Gas Instructions Connect Gas Supply a) To connect gas hose at the supply: Slide back the collar of the quick disconnect. Push male fitting of the hose into - Weber Summit Silver B NG | Owner Manual - Page 33
Gas Instructions ƽWARNING : The gas connections of your Summit® gas grill have been factory tested. We do however recommend that you leak check all gas connections before - Weber Summit Silver B NG | Owner Manual - Page 34
Gas Instructions Remove the Front Panel by sliding the panel up and out of the slots. Check for gas leaks ƽ DANGER Do not use an open flame - Weber Summit Silver B NG | Owner Manual - Page 35
Gas Instructions Check: 1) Quick disconnect hose to grill connection 2) Side burner hose to gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF - Weber Summit Silver B NG | Owner Manual - Page 36
Gas Instructions Reinstall control panel Parts required: control panel, screws, and burner control knobs. Place the control panel back onto the control panel (1) brackets on either side - Weber Summit Silver B NG | Owner Manual - Page 37
Operating Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burners - Weber Summit Silver B NG | Owner Manual - Page 38
Operating Instructions Indirect cooking The Indirect Method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can't get from - Weber Summit Silver B NG | Owner Manual - Page 39
Lighting 1 Summary lighting instructions are on the control panel. ƽ DANGER 4,5,8 Failure to open the only Weber® authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1 4,5,8 7 2 6 3 2 *The grill - Weber Summit Silver B NG | Owner Manual - Page 40
Operating Instructions Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does - Weber Summit Silver B NG | Owner Manual - Page 41
Side Burner Lighting Instructions ƽ DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner - Weber Summit Silver B NG | Owner Manual - Page 42
Troubleshooting Problem Check on HIGH. Flames do not run the whole length of the burner tube. Are burners clean? Clean burners. (See Section "Maintenance".) Inside "Cleaning".) If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your - Weber Summit Silver B NG | Owner Manual - Page 43
Side Burner Troubleshooting Problem Side Burner does not light. Check Is gas supply off? Cure Turn supply on. Flame is low in HIGH position. Is the fuel hose bent - Weber Summit Silver B NG | Owner Manual - Page 44
burner to get debris and dirt out of the burner tube. Once the spider/insect screens and burners are clean replace the burners. If the spider/insect screen becomes damaged or cannot be cleaned, call Weber-Stephen Products Customer Service for replacement parts. Main Burner Flame Pattern The Weber - Weber Summit Silver B NG | Owner Manual - Page 45
Maintenance Replacing Main Burners 1. Your Summit® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer® bars. 7. To remove control panel refer to "Remove the control panel" under "Check for Gas Leaks - Weber Summit Silver B NG | Owner Manual - Page 46
Maintenance 9. Remove screws from the manifold assembly: (a) Locate the screws on both sides of the manifold frame. (b) Remove the screws from manifold frame. 10. Pull manifold assembly out from the manifold frame. (a) (b) (a) (b) (a) (b) (a) (b) E-3 - Weber Summit Silver B NG | Owner Manual - Page 47
(1) must be positioned properly over the valve orifices (2). (2) (a) (1) 12. Remove the Crossover® tube. 13. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. Check proper assembly before fastening manifold in place. ƽWARNING: After reinstalling the gas - Weber Summit Silver B NG | Owner Manual - Page 48
sparking. If the Crossover® ignition system still fails to light, contact the Customer Service Representative in your region using the contact information sheet provided with your manual. (1) (2) Replace Igniter Batteries Parts required: 1 AA alkaline battery per igniter. Unscrew igniter button
SUMMIT
®
±
WARNING: Follow all leak-check
procedures carefully in this manual prior to
barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING
1.
Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2.
Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL
Natural Gas Grill Owners Guide
±
WARNING: Do not try to light this
appliance without reading the “Lighting”
Instructions section of this manual
#
43721 US 01/29/03
NG
43721
&
A405_NG.d
Ba402_NG.a
B405_NG.c
C405_NG.c
D405_NG.d
E403.b