Weber Summit Silver C NG Owner Manual
Weber Summit Silver C NG Manual
View all Weber Summit Silver C NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit Silver C NG manual content summary:
- Weber Summit Silver C NG | Owner Manual - Page 1
Gas Grill Owners Guide YOU MUST READ THIS OWNERS GUIDE # BEFORE OPERATING this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. NOTICE TO INSTALLER: These instructions "Lighting" Instructions section of this manual A407_NG.d Ba402_NG.a B407_NG.c C407_NG.c D407_NG.d E401 - Weber Summit Silver C NG | Owner Manual - Page 2
for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber according to the instructions outlined in the "Assembly Instruction" section of the Owner's Guide. LIQUID PROPANE problem yourself. 3. Call your fire department. A-2 - Weber Summit Silver C NG | Owner Manual - Page 3
A-7 Parts List A-9 Assembly Instructions B-a Gas Instructions C-1 Leak Checking C-4 Operating D-1 Grilling Methods D-1 Lighting ...D-3 Manual Lighting D-4 Lighting the Side Burner D-5 Lighting the Smoker D-7 Troubleshooting D-9 Side Burner Troubleshooting D-10 Maintenance E-1 Replacing - Weber Summit Silver C NG | Owner Manual - Page 4
assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual - Weber Summit Silver C NG | Owner Manual - Page 5
For Installation in Canada These instructions, while generally acceptable, do not for gas leaks and any obstructions in the burner tubes before using. (See Sections: "General Maintenance supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas - Weber Summit Silver C NG | Owner Manual - Page 6
Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual Service Representative in your region using the contact information sheet provided with your manual - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS - Weber Summit Silver C NG | Owner Manual - Page 7
Exploded View 1 Summit® Silver C NG 012903 2 3 43 4 44 5 45 6 46 7 47 48 8 9 10 11 49 12 13 14 15 16 17 50 18 51 19 52 20 21 53 22 - Weber Summit Silver C NG | Owner Manual - Page 8
1/4 inch Bolt 46. 12 inch Cooking Grate 47. Right Flavorizer® Bar Assembly 48. Warming Rack 49. Cookbox Assembly 50. Electrode Assembly 51. Right Burner Tube 52. Battery Shield Assembly 53. Manifold Assembly 54. Main Gas Line 55. Hose 56. Side Burner Igniter Wire 57. Bottom Tray 58. Summit Catch Pan - Weber Summit Silver C NG | Owner Manual - Page 9
Lid - 1 Cookbox - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Left Frame Assembly - 1 Right Frame Assembly - 1 Rear Panel - 1 Parts List Bottom Shelf - 1 Left Door - 1 Right Door - 1 Side Table - 2 Side Burner - 1 Warming Rack - 1 Warm-Up™ Rack - 1 A-9 - Weber Summit Silver C NG | Owner Manual - Page 10
Flavorizor® Bars - 2 Sets Stainless Steel Cooking Grates - 2 Bottom Tray - 1 Catch-Pan Holder - 1 Catch-Pan - 1 Disposable Drip Pans - 2 Smoker - 1 Parts List Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Nut Hex (1/4 x 20 Blk Zinc) - 2 1/2 inch Bolts (1/4 x 20 x - Weber Summit Silver C NG | Owner Manual - Page 11
1 Place corregated from each side of a the Cookbox under the Caster and Wheel Frame Assembly to level the frames for Frame Rail Assembly. b c (1) (3) Ba402_NG.a ƽ CAUTION: Before proceeding to the next step check that frame rail (2) is on the side with the swing tables (3). The tab - Weber Summit Silver C NG | Owner Manual - Page 12
2 a b ƽ ATTENTION! Only start these bolts. Do not tighten yet. B-b - Weber Summit Silver C NG | Owner Manual - Page 13
3 B-c - Weber Summit Silver C NG | Owner Manual - Page 14
4 a b ƽ ATTENTION! Completely remove both partially started bolts from top rear frame rail c 1 2 ƽ ATTENTION! Reinstall both bolts through rear panel and into rear frame rail. B-d - Weber Summit Silver C NG | Owner Manual - Page 15
5 ƽ ATTENTION! Remove packing tape holding the gas line and bracket(1). When installing cookbox route the gas line and bracket(1) inside the frame rails(2). a (1) (2) (2) (1) (2) (2) B-e - Weber Summit Silver C NG | Owner Manual - Page 16
6 b (1) (2) (3) B-f - Weber Summit Silver C NG | Owner Manual - Page 17
7 c (1) (2) (1) (2) B-g - Weber Summit Silver C NG | Owner Manual - Page 18
8 a b Matchlight Holder B-h - Weber Summit Silver C NG | Owner Manual - Page 19
9 a b (1) (2) (3) B-i - Weber Summit Silver C NG | Owner Manual - Page 20
10 a b a b B-j - Weber Summit Silver C NG | Owner Manual - Page 21
11 a (1) (2) NOTE: Igniter b Wire(1) is located up under right side of control panel. (1) B407_NG.c B-1 - Weber Summit Silver C NG | Owner Manual - Page 22
c ƽ CAUTION: Hold burner cap(1) down while pushing side burner ignition wire(2) on. (1) (2) d B-2 - Weber Summit Silver C NG | Owner Manual - Page 23
12 b a 13 B-3 - Weber Summit Silver C NG | Owner Manual - Page 24
14 15 B-4 - Weber Summit Silver C NG | Owner Manual - Page 25
16 17 B-5 - Weber Summit Silver C NG | Owner Manual - Page 26
B-6 - Weber Summit Silver C NG | Owner Manual - Page 27
Instructions psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve grams of hydrogen sulfide per 100 cubic feet of gas. s Plastic tubing is suitable only for outdoor, underground use. s Gas piping in contact - Weber Summit Silver C NG | Owner Manual - Page 28
Gas Instructions Connect Gas Supply a) To connect gas hose at the supply: Slide back the collar of the quick disconnect. Push male fitting of the hose into - Weber Summit Silver C NG | Owner Manual - Page 29
Gas Instructions ƽWARNING : The gas connections of your Summit® gas grill have been factory tested. We do however recommend that you leak check all gas connections before - Weber Summit Silver C NG | Owner Manual - Page 30
Gas Instructions Check for gas leaks ƽ DANGER Do not use an open flame to check OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF at the - Weber Summit Silver C NG | Owner Manual - Page 31
Gas Instructions Reinstall control panel Parts required: control panel, screws, and burner control knobs. Place the control panel back onto the control panel brackets on either side - Weber Summit Silver C NG | Owner Manual - Page 32
Operating Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burners - Weber Summit Silver C NG | Owner Manual - Page 33
Operating Instructions Indirect cooking The Indirect Method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can't get from - Weber Summit Silver C NG | Owner Manual - Page 34
Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure to open only Weber® authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1) Open the lid. 2) Make sure all burner - Weber Summit Silver C NG | Owner Manual - Page 35
Operating Instructions Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does - Weber Summit Silver C NG | Owner Manual - Page 36
Side Burner Lighting Instructions ƽ DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner - Weber Summit Silver C NG | Owner Manual - Page 37
. This residue need not be removed and will not adversely affect the function of your gas grill. (1) Light the smoker burner by following the instructions for Lighting The Smoker Burner After wood starts to smolder turn control knob to low. Smoke will start in approximately 10 minutes and last as - Weber Summit Silver C NG | Owner Manual - Page 38
way, do not use the grill. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1) Open the grill lid. ƽDANGER: Failure to open the lid while igniting the grill, or not - Weber Summit Silver C NG | Owner Manual - Page 39
Instructions Manually Lighting the Smoker Burner 1 ƽWARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber® authorized replacement hose. Contact the Customer Service - Weber Summit Silver C NG | Owner Manual - Page 40
Burner Troubleshooting Problem Check HIGH. Flames do not run the whole length of the burner tube. Are burners clean? Clean burners. (See Section "Maintenance".) Inside "Cleaning".) If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your - Weber Summit Silver C NG | Owner Manual - Page 41
Side Burner Troubleshooting Problem Side Burner does not light. Check Is gas supply off? Cure Turn supply on. Flame is low in HIGH position. Is the fuel hose bent - Weber Summit Silver C NG | Owner Manual - Page 42
burner to get debris and dirt out of the burner tube. Once the spider/insect screens and burners are clean replace the burners. If the spider/insect screen becomes damaged or cannot be cleaned, call Weber-Stephen Products Customer Service for replacement parts. Main Burner Flame Pattern The Weber - Weber Summit Silver C NG | Owner Manual - Page 43
Maintenance Replacing Main Burners 9. 1. Your Summit® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer® bars. 7. To remove control panel refer to "Remove the control panel" under "Check for Gas - Weber Summit Silver C NG | Owner Manual - Page 44
orifices (2). Check proper assembly before fastening manifold in place. (2) (1) 12. Remove the Crossover® tube. 13. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and - Weber Summit Silver C NG | Owner Manual - Page 45
the igniter sparking. If the Crossover® ignition system still fails to light, contact the Customer Service Representative in your region using the contact information sheet provided with your manual. Parts required: 1 AA alkaline battery per igniter. Unscrew igniter button from top of control panel
±
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if
the barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING
1.
Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2.
Do not store or use gasoline or other
flammable liquids or vapors within
25 feet (8m) of this appliance.
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL
Natural Gas Grill Owners Guide
±
WARNING: Do not try to light this
appliance without reading the “Lighting”
Instructions section of this manual
#
42097 US 01/29/03
NG
SUMMIT
®
42097
A407_NG.d
Ba402_NG.a
B407_NG.c
C407_NG.c
D407_NG.d
E401.b