Whirlpool JMV8186AAS Installation Instructions
Whirlpool JMV8186AAS Manual
 |
View all Whirlpool JMV8186AAS manuals
Add to My Manuals
Save this manual to your list of manuals |
Whirlpool JMV8186AAS manual content summary:
- Whirlpool JMV8186AAS | Installation Instructions - Page 1
Over the Range Microwave Oven BEFORE YOU BEGIN Read these instructions completely and carefully. • IMPORTANT - Save these instructions for local inspector's use. • IMPORTANT - Observe all governing codes and ordinances. • Note to Installer - Be sure to leave these instructions with the Consumer - Whirlpool JMV8186AAS | Installation Instructions - Page 2
information Important Safety Instructions 3 Electrical Requirements 3 Hood Exhaust 4, 5 Damage - Shipment/Installation 6 Parts Included 6 Tools Blower 19, 20 Mount the Microwave Oven 20, 21 Before You Use Your Microwave 22 Step-by-step installation guide Placement of Mounting Plate 8-10 - Whirlpool JMV8186AAS | Installation Instructions - Page 3
supporting the cabinet load, in addition to the added weight of this 59 pound product, plus additional oven loads of up to 50 pounds or a total weight of 109 pounds. CAUTION: For personal safety, this product cannot be installed microwave oven. The outlet box and supply circuit should be installed - Whirlpool JMV8186AAS | Installation Instructions - Page 4
Installation Instructions HOOD EXHAUST NOTE: Read these next two pages only if you plan to vent your exhaust to the outside. If you plan to recirculate the air back into the room, proceed to page 11. OUTSIDE TOP EXHAUST (EXAMPLE ONLY) The following chart describes an example of one possible - Whirlpool JMV8186AAS | Installation Instructions - Page 5
Instructions NOTE: If you need to install ducts, note that the total duct length of 3¼" x 10" rectangular or 6" diameter round duct should not exceed 60 equivalent feet. Outside ventilation requires a HOOD EXHAUST DUCT. Read the following carefully. NOTE: It is important that venting be installed - Whirlpool JMV8186AAS | Installation Instructions - Page 6
sure you have all these parts. NOTE: Some extra parts are included. ADDITIONAL PARTS PART TOP CABINET TEMPLATE QUANTITY Top Cabinet 1 Template REAR WALL TEMPLATE Rear Wall 1 Template IInnssttraullcattioionns Installation 1 Instructions Separately 2 Packed Grease Filters Exhaust - Whirlpool JMV8186AAS | Installation Instructions - Page 7
up to 36" wide. • If you are going to vent your microwave oven to the outside, see Hood Exhaust Section for exhaust duct preparation. • When installing the microwave oven beneath smooth flat cabinets be careful to follow the instructions on the top cabinet template for power cord clearance. 7 - Whirlpool JMV8186AAS | Installation Instructions - Page 8
OF THE MOUNTING PLATE A. REMOVING THE MICROWAVE OVEN FROM THE CARTON/ REMOVING THE MOUNTING PLATE 1. Remove the installation instructions, Exhaust adaptor, filters, glass tray and the small hardware bag. Do not remove the Styrofoam protecting the front of the oven. 2. Fold back all 4 carton flaps - Whirlpool JMV8186AAS | Installation Instructions - Page 9
Installation Instructions C. DETERMINING WALL PLATE LOCATION UNDER YOUR CABINET Plate position - may have decorative trim that interferes with the microwave installation. Remove the decorative trim to install the microwave properly and to make it level. THE MICROWAVE MUST BE LEVEL. Use a level to - Whirlpool JMV8186AAS | Installation Instructions - Page 10
Installation Instructions D. ALIGNING THE WALL PLATE Hole A Centerline notches Draw a Vertical Line on Wall from Center of Top Cabinet with the stud. It is important to use at least one wood screw mounted firmly in a stud to support the weight of the microwave. Set the mounting plate aside. 10 - Whirlpool JMV8186AAS | Installation Instructions - Page 11
Instructions 2. INSTALLATION TYPES (Choose A, B or C) This microwave oven is designed for adaptation to the following three types of ventilation: A. Recirculating (Non-Vented Ductless) B. Outside Top Exhaust (Vertical Duct) C. Outside Back Exhaust (Horizontal Duct) NOTE: This microwave - Whirlpool JMV8186AAS | Installation Instructions - Page 12
Installation Instructions A. RECIRCULATING (Non-Vented Ductless) INSTALLATION OVERVIEW A1. Attach Mounting Plate to Wall A2. Prepare Top Cabinet A3. Mount the Microwave Oven holes for the top support screws and a hole large enough for the power cord to fit through. • Read the instructions on the TOP - Whirlpool JMV8186AAS | Installation Instructions - Page 13
Installation Instructions A3. MOUNT THE MICROWAVE OVEN FOR EASIER INSTALLATION AND PERSONAL SAFETY, WE RECOMMEND THAT TWO PEOPLE INSTALL THIS MICROWAVE OVEN. IMPORTANT: Do not grip or use handle during installation. NOTE: If your cabinet is metal, use the nylon grommet around the power cord hole to - Whirlpool JMV8186AAS | Installation Instructions - Page 14
Installation Instructions B. OUTSIDE TOP EXHAUST (Vertical Duct) INSTALLATION OVERVIEW B1. Attach Mounting Plate to Wall B2. Prepare Top Cabinet B3. Adjust Blower B4. Check Damper Operation B5. Mount Microwave Oven B6. Adjust Exhaust Adaptor B7. Connect Ductwork B1. ATTACH THE MOUNTING PLATE TO THE - Whirlpool JMV8186AAS | Installation Instructions - Page 15
Installation Instructions B2. USE TOP CABINET TEMPLATE FOR PREPARATION OF TOP CABINET You need to drill holes for the top support screws, a hole large enough for the power cord to fit through, and a cutout large enough for the exhaust adaptor. B3. ADAPTING MICROWAVE BLOWER FOR OUTSIDE TOP EXHAUST - Whirlpool JMV8186AAS | Installation Instructions - Page 16
Facing Upward Installation Instructions B5. MOUNT THE MICROWAVE OVEN 5. Place the blower unit back into the opening. CAUTION: Do not pull or stretch the blower unit wiring. Make sure the wires are not pinched. 6. Secure blower unit to microwave with the screw. B4. INSTALLATION PROCEDURE FOR - Whirlpool JMV8186AAS | Installation Instructions - Page 17
Installation Instructions B5. MOUNT THE MICROWAVE OVEN (cont.) Cabinet Front Cabinet Bottom Shelf Filler Block B6. ADJUST THE EXHAUST ADAPTOR Open the top cabinet and adjust the exhaust adaptor to connect to the house duct. Blower-Plate Damper Back of Microwave Equivalent to Depth of Cabinet - Whirlpool JMV8186AAS | Installation Instructions - Page 18
Installation Instructions C. OUTSIDE BACK EXHAUST (Horizontal Duct) INSTALLATION OVERVIEW C1. Prepare Rear Wall C2. Attach Mounting Plate to Wall C3. Prepare Top Cabinet C4. Adjust Blower C5. Mount the Microwave Oven C1. PREPARING THE REAR WALL FOR OUTSIDE BACK EXHAUST You need to cut an opening in - Whirlpool JMV8186AAS | Installation Instructions - Page 19
microwave. Blower motor screw. 2. Lift up the Blower Plate. Blower Motor Back of Microwave the top support screws and installed. 4. Remove "Parts "A" with Nipper or Scissors Knockouts Parts"A" 5. Rotate blower unit counterclockwise 180°. Before Rotation After Rotation • Read the instructions - Whirlpool JMV8186AAS | Installation Instructions - Page 20
Installation Instructions 6. Place the blower unit back into the opening. AFTER: Fan Blade Openings Facing Back End A C5. MOUNT THE MICROWAVE OVEN End B CAUTION: Do not pull or stretch the blower unit wiring. Make sure the wires are not pinched. NOTE: The blower unit exhaust openings should - Whirlpool JMV8186AAS | Installation Instructions - Page 21
Installation Instructions C5. MOUNT THE MICROWAVE OVEN (cont.) Install grease filters. See the Owner's Manual packed with the microwave. Cabinet Front Cabinet Bottom Shelf Filler Block Equivalent to Depth of Cabinet Recess Self-Aligning Screw Microwave Oven Top 4. Attach the microwave oven to the - Whirlpool JMV8186AAS | Installation Instructions - Page 22
1. Make sure the microwave oven has been installed according to instructions. 6. Read the Owner's Manual. 2. Remove all packing material from the microwave oven. 3. Install turntable and ring in cavity. 4. Replace house fuse or turn breaker back on. 7. KEEP INSTALLATION INSTRUCTIONS FOR THE LOCAL - Whirlpool JMV8186AAS | Installation Instructions - Page 23
NOTE Installation Instructions 23 - Whirlpool JMV8186AAS | Installation Instructions - Page 24
Part No. : 8101P659-60 Form No. : Code No. : DE68-03118A
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
 |
 |
Installation Instructions
Over the Range Microwave Oven
BEFORE YOU BEGIN
Read these instructions completely and carefully.
•
IMPORTANT –
Save these instructions for
local inspector’s use.
•
IMPORTANT –
Observe all governing codes
and ordinances.
•
Note to Installer –
Be sure to leave these
instructions with the Consumer.
•
Note to Consumer –
Keep these instructions for
future reference.
•
Skill level –
Installation of this appliance requires
basic mechanical and electrical skills.
•
Proper installation is the responsibility of the
installer.
•
Product failure due to improper installation is not
covered under the Warranty.
READ CAREFULLY. KEEP THESE INSTRUCTIONS.