Whirlpool WFG510S0A Installation Instructions
Whirlpool WFG510S0A Manual
 |
View all Whirlpool WFG510S0A manuals
Add to My Manuals
Save this manual to your list of manuals |
Whirlpool WFG510S0A manual content summary:
- Whirlpool WFG510S0A | Installation Instructions - Page 1
3 Tools and Parts 3 Location Requirements 3 Electrical Requirements 5 Gas Supply Requirements 5 INSTALLATION INSTRUCTIONS 7 Unpack Range are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This - Whirlpool WFG510S0A | Installation Instructions - Page 2
call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions. • If you cannot reach your gas supplier, call the fire department. - Installation and service must be performed by a qualified installer, service agency or the gas supplier. WARNING: Gas leaks cannot always be - Whirlpool WFG510S0A | Installation Instructions - Page 3
INSTALLATION REQUIREMENTS Tools and Parts Gather the required tools and parts before starting installation. Read and follow the instructions provided with any tools listed here. Tools needed ■ Tape measure ■ Flat-blade screwdriver ■ Phillips screwdriver ■ Level ■ Hand or electric drill ■ Wrench or - Whirlpool WFG510S0A | Installation Instructions - Page 4
(located on the oven frame behind the top left side of the oven door) IMPORTANT: Range must be level after installation. Follow the instructions in the "Level Range" section. Using the cooktop as a reference for leveling the range is not recommended. *Range can be raised approximately 1" (2.5 cm - Whirlpool WFG510S0A | Installation Instructions - Page 5
: Leak testing of the range must be conducted according to the manufacturer's instructions. Type of Gas Natural gas: ■ This range is factory set for gas supplier. LP gas conversion: Conversion must be done by a qualified service technician. No attempt shall be made to convert the appliance from the - Whirlpool WFG510S0A | Installation Instructions - Page 6
regulator. ■ Do not kink or damage the flexible metal tubing when moving the range. ■ Must include a shutoff valve: The supply line must be equipped with a manual shutoff valve. This valve should be located in the same room but external to the range opening, such as an adjacent cabinet. It should be - Whirlpool WFG510S0A | Installation Instructions - Page 7
INSTALLATION INSTRUCTIONS Unpack Range WARNING Excessive Weight Hazard Use two or more people to move and install range. Failure to do so can result in back or other injury. 1. Remove shipping materials, tape and film from range. 2. Remove oven racks and parts package from inside oven. 3. Do not - Whirlpool WFG510S0A | Installation Instructions - Page 8
the range using the following installation instructions. Explosion Hazard Use a new personnel, authorized gas company personnel, and authorized service personnel. Failure to do so can result thread) D. Flexible connector HG F E. Manual gas shutoff valve F. ½" or ¾" gas pipe G. Use pipe- - Whirlpool WFG510S0A | Installation Instructions - Page 9
in the "on" position 2. Open the manual shutoff valve in the gas supply line. and grates from parts package. Burner service technician. If you need assistance or service, refer to the "Assistance or Service" section of the Use and Care Guide, or the cover or "Warranty" section of the User Instructions - Whirlpool WFG510S0A | Installation Instructions - Page 10
range without anti-tip bracket installed and engaged. Please reference the "Assistance or Service" section of the Use and Care Guide, or the cover or "Warranty" section of the User Instructions, to contact service. Level Range Determine if you have AquaLift® Technology or Steam Clean by referring - Whirlpool WFG510S0A | Installation Instructions - Page 11
within 8 seconds. Under certain conditions, it may take the burner up to 50 to 60 seconds to light. Refer to the Use and Care Guide or User Instructions for proper operation of the oven controls. Adjust Oven Broil Burner Flame (if needed) Look through oven window to check broil burner for proper - Whirlpool WFG510S0A | Installation Instructions - Page 12
3. Tighten lock screw. To Replace: 1. Align the forward drawer notches with the notches in the drawer glides on both sides. Place the rear alignment tabs into the drawer glides on both sides. A A B A. Lock screw B. Air shutter 4. Press CANCEL/OFF when finished. Warming Drawer or Premium Storage - Whirlpool WFG510S0A | Installation Instructions - Page 13
Check that all parts are now installed. If there is an extra part, go back connected. ■ See "Troubleshooting" in the Use and Care Guide or User Instructions. 8. When the range Service: Please reference the "Assistance or Service" section of the Use and Care Guide or the cover of the User Instructions - Whirlpool WFG510S0A | Installation Instructions - Page 14
licensed heating personnel, authorized gas company personnel, and authorized service personnel. Failure to do so can result in death, instructions can result in death or serious burns to children and adults. 1. Turn the manual shutoff valve to the closed position. B A C A. To range B. Manual - Whirlpool WFG510S0A | Installation Instructions - Page 15
3. Remove plastic cover from gas pressure regulator cap. 4. Turn gas pressure regulator cap counterclockwise with a ⁵⁄₈" combination wrench to remove. NOTE: Do not remove the spring beneath the cap. Side view before A 3. Apply masking tape to the end of a 7 mm) nut driver to help hold the gas - Whirlpool WFG510S0A | Installation Instructions - Page 16
To Convert Oven Bake Burner (Natural Gas to LP Gas) 1. Remove the oven racks. 2. Remove 2 screws at the rear of the oven bottom. 3. Lift the rear of the oven bottom up and back until the front of the panel is away from the front frame. Remove from oven and set it aside on a covered surface. A 8. - Whirlpool WFG510S0A | Installation Instructions - Page 17
not as distinct as the inner cone. LP gas flames have a slightly yellow tip. 3. Refer to "Complete Installation" in the "Installation Instructions" section of this manual to complete this procedure. NOTE: Make sure to save the orifices that have just been replaced in the conversion. Tip Over Hazard - Whirlpool WFG510S0A | Installation Instructions - Page 18
the top left side of the oven door for proper sizing of spuds for each burner location. 5. Place LP gas orifice spuds in plastic parts bag for future use and keep with package containing literature. 6. Replace the burner base using both screws. 7. Replace burner cap. 8. Repeat steps 1-7 for the - Whirlpool WFG510S0A | Installation Instructions - Page 19
4. Remove 2 screws from the front tabs of the flame spreader. Lift front of the flame spreader and pull forward to remove tabs from rear of oven and set it aside on a covered surface. B A A. Screws B. Flame spreader 5. Remove 2 screws from the bake burner. 6. Slide the front of the bake burner to - Whirlpool WFG510S0A | Installation Instructions - Page 20
broil burner flame is very important. Natural gas flames do not have yellow tips. 3. Refer to "Complete Installation" in the "Installation Instructions" section of this manual to complete this procedure. NOTE: Make sure to save the orifices that have just been replaced in the conversion. W10658550B
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
 |
 |
INSTALLATION INSTRUCTIONS
30" (76.2 CM) FREESTANDING GAS RANGES
RANGE SAFETY
Table of Contents
RANGE SAFETY
.............................................................................
1
INSTALLATION REQUIREMENTS
...............................................
3
Tools and Parts
............................................................................
3
Location Requirements
...............................................................
3
Electrical Requirements
...............................................................
5
Gas Supply Requirements
..........................................................
5
INSTALLATION INSTRUCTIONS
.................................................
7
Unpack Range
.............................................................................
7
Install Anti-Tip Bracket
................................................................
7
Make Gas Connection
.................................................................
8
Verify Anti-Tip Bracket Is Installed and Engaged
.......................
9
Level Range
...............................................................................
10
Electronic Ignition System
.........................................................
10
Warming Drawer or Premium Storage Drawer
.........................
12
Storage Drawer
..........................................................................
12
Oven Door
..................................................................................
13
Complete Installation
.................................................................
13
GAS CONVERSIONS
...................................................................
14
LP Gas Conversion
....................................................................
14
Natural Gas Conversion
............................................................
17
W10658550B
IMPORTANT:
Save for local inspector's use.
Installer:
Leave installation instructions with the homeowner.
Homeowner:
Keep installation instructions for future reference.
You can be killed or seriously injured if you don't immediately
You
can be killed or seriously injured if you don't follow
All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can
happen if the instructions are not followed.
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety
messages.
This is the safety alert symbol.
This symbol alerts you to potential hazards that can kill or hurt you and others.
All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.”
These words mean:
follow instructions.
instructions.
DANGER
WARNING