Whirlpool WFG530S0ES Installation Guide
Whirlpool WFG530S0ES Manual
 |
View all Whirlpool WFG530S0ES manuals
Add to My Manuals
Save this manual to your list of manuals |
Whirlpool WFG530S0ES manual content summary:
- Whirlpool WFG530S0ES | Installation Guide - Page 1
INSTRUCTIONS 30" (76.2 CM) FREESTANDING GAS RANGES Table of Contents RANGE SAFETY 1 INSTALLATION REQUIREMENTS 3 Tools and Parts 3 Location Requirements 3 Electrical Requirements 5 Gas Supply Requirements 5 INSTALLATION INSTRUCTIONS 7 Unpack Range 7 Install Anti-Tip Bracket 7 Make Gas - Whirlpool WFG530S0ES | Installation Guide - Page 2
from a neighbor's phone. Follow the gas supplier's instructions. • If you cannot reach your gas supplier, call the fire department. - Installation and service must be performed by a qualified installer, service agency or the gas supplier. WARNING: Gas leaks cannot always be detected by smell - Whirlpool WFG530S0ES | Installation Guide - Page 3
Title 24, HUD Part 280). When such standard is not applicable, use the Standard for Manufactured Home Installations, ANSI A225.1/NFPA 501A or with local codes. Mobile home installations require: ■ When this range is installed in a mobile home, it must be secured according to the instructions in this - Whirlpool WFG530S0ES | Installation Guide - Page 4
range to front of cooktop** F. Model/serial rating plate (located on the oven frame behind the top left side of the oven door) IMPORTANT: Range must be level after installation. Follow the instructions in the "Level Range areas are recommended for installation of rigid gas pipe. G. 4¹⁄₂" (11.4 cm) - Whirlpool WFG530S0ES | Installation Guide - Page 5
the manufacturer's instructions. Type of Gas Natural gas: This range is design-certified by CSA International for use with Natural gas or, after proper conversion, for use with LP gas. ■ This range is factory set for use with Natural gas. See "Gas Conversions" section. The model/serial rating plate - Whirlpool WFG530S0ES | Installation Guide - Page 6
model/serial rating plate. Line pressure testing above ½ psi gauge (14" WCP) The range and its individual shutoff valve must be disconnected from the gas The range must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas - Whirlpool WFG530S0ES | Installation Guide - Page 7
INSTALLATION INSTRUCTIONS Unpack Range WARNING Excessive Weight Hazard Use two or more people to move and install range. Failure to do so can result in back or other injury. 1. Remove shipping materials, tape and film from range. 2. Remove oven racks and parts package from inside oven. 3. Do not - Whirlpool WFG530S0ES | Installation Guide - Page 8
range using the following installation instructions. Explosion Hazard Use a new CSA International approved gas supply line. Install a shut-off valve. Securely tighten all gas include: licensed heating personnel, authorized gas company personnel, and authorized service personnel. Failure to do so can - Whirlpool WFG530S0ES | Installation Guide - Page 9
grates from parts package. range and the mounting wall. Changes to the gas supply must be performed by a qualified service technician. If you need assistance or service, refer to the "Assistance or Service" section of the Use and Care Guide, or the cover or "Warranty" section of the User Instructions - Whirlpool WFG530S0ES | Installation Guide - Page 10
Service" section of the Use and Care Guide, or the cover or "Warranty" section of the User Instructions, to contact service. Level Range oven control is turned to the desired setting, sparking occurs and ignites the gas. Check Operation of Cooktop Burners Standard Surface Burners Push in and turn - Whirlpool WFG530S0ES | Installation Guide - Page 11
and Care Guide or User Instructions for proper operation of the oven controls. Adjust Oven Bake Burner Flame (if needed) 1. On models with a needs to be adjusted, locate the air shutter near the center rear of the range. Loosen the locking screw and rotate the air shutter until the proper flame - Whirlpool WFG530S0ES | Installation Guide - Page 12
B. Air shutter 4. Press CANCEL/OFF when finished. Warming Drawer or Premium Storage Drawer (on some models) Remove all items from inside the warming drawer or premium storage drawer, and allow the range to cool completely before attempting to remove the drawer. To Remove: 1. Open the warming drawer - Whirlpool WFG530S0ES | Installation Guide - Page 13
Installation 1. Check that all parts are now installed. If there is an extra part, go back through the steps Troubleshooting" in the Use and Care Guide or User Instructions. 8. When the range has been on for 5 minutes, check for heat. If the range is cold, turn off the range and check that the gas - Whirlpool WFG530S0ES | Installation Guide - Page 14
and engaged. Failure to follow these instructions can result in death or serious burns to children and adults. 1. Turn the manual shutoff valve to the closed position. B A C A. To range B. Manual shutoff valve "closed" position C. Gas supply line 2. Unplug range or disconnect power. To Convert - Whirlpool WFG530S0ES | Installation Guide - Page 15
pressure regulator cap. To Convert Surface Burners (Natural Gas to LP Gas) 1. Remove burner cap. 2. Using a Phillips or Quadrex® screwdriver, remove the burner base. NOTE: Reinstall one of the screws through the range cooktop to hold the orifice spud holder in place while removing and replacing - Whirlpool WFG530S0ES | Installation Guide - Page 16
A 8. Replace the "49" spud with a "57" spud. Install the LP gas bake burner orifice spud, turning it clockwise until snug. IMPORTANT: Do not overtighten. oven bottom panel with 2 screws. To Convert Oven Broil Burner (Natural Gas to LP Gas) 1. Remove the screw from the broil burner. 2. Remove the - Whirlpool WFG530S0ES | Installation Guide - Page 17
these instructions can result in death or serious burns to children and adults. 1. Turn the manual shutoff valve to the closed position. B A C A. To range B. Manual shutoff valve "closed" position C. Gas supply line 2. Unplug range or disconnect power. To Convert Gas Pressure Regulator (LP Gas to - Whirlpool WFG530S0ES | Installation Guide - Page 18
Gas to Natural Gas) 1. Remove burner cap. 2. Using a Phillips or Quadrex® screwdriver, remove the burner base. NOTE: Reinstall one of the screws through the range N110 NOTE: Refer to the Model Number and Serial Number Plate located . 5. Place LP gas orifice spuds in plastic parts bag for future use - Whirlpool WFG530S0ES | Installation Guide - Page 19
bottom panel with 2 screws. To Convert Oven Broil Burner (LP Gas to Natural Gas) 1. Remove the screw from the broil burner. 2. Remove the Bake burner 7. Use a ³⁄₈" nut driver or combination wrench and turn the LP gas bake burner orifice spud counterclockwise to remove. The spud will be stamped with a - Whirlpool WFG530S0ES | Installation Guide - Page 20
LP Gas to Natural Gas) 1. Refer to the "Make Gas Connection" section for properly connecting the range to the gas Instructions" section of this manual to complete this procedure. NOTE: Make sure to save the orifices that have just been replaced in the conversion. W10658550A ®/™ ©2013 Whirlpool
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
 |
 |
INSTALLATION INSTRUCTIONS
30" (76.2 CM) FREESTANDING GAS RANGES
RANGE SAFETY
Table of Contents
RANGE SAFETY
.............................................................................
1
INSTALLATION REQUIREMENTS
...............................................
3
Tools and Parts
............................................................................
3
Location Requirements
...............................................................
3
Electrical Requirements
...............................................................
5
Gas Supply Requirements
..........................................................
5
INSTALLATION INSTRUCTIONS
.................................................
7
Unpack Range
.............................................................................
7
Install Anti-Tip Bracket
................................................................
7
Make Gas Connection
.................................................................
8
Verify Anti-Tip Bracket Is Installed and Engaged
.......................
9
Level Range
...............................................................................
10
Electronic Ignition System
.........................................................
10
Warming Drawer or Premium Storage Drawer
.........................
12
Storage Drawer
..........................................................................
12
Oven Door
..................................................................................
13
Complete Installation
.................................................................
13
GAS CONVERSIONS
...................................................................
14
LP Gas Conversion
....................................................................
14
Natural Gas Conversion
............................................................
17
W10658550A
IMPORTANT:
Save for local inspector's use.
Installer:
Leave installation instructions with the homeowner.
Homeowner:
Keep installation instructions for future reference.
You can be killed or seriously injured if you don't immediately
You
can be killed or seriously injured if you don't follow
All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can
happen if the instructions are not followed.
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety
messages.
This is the safety alert symbol.
This symbol alerts you to potential hazards that can kill or hurt you and others.
All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.”
These words mean:
follow instructions.
instructions.
DANGER
WARNING